Académique Documents
Professionnel Documents
Culture Documents
\
|
+ =
Where V is the off state voltage across the switch, I is the ON state current through the
switch and
S
f is the switching frequency.
Figure Q2
Question 3
The convertor and snubber circuit shown in Figure Q3 has V
s
= 50V and I
L
= 5A, C=0.05F, R
=5O and t
f
= 0.5s. The switching frequency is 120kHz with a duty ratio of 0.4.
1) Determine expressions for i
Q
, i
c
and v
c
during turn off.
2) Determine the transistor turn off losses in the switch and the snubber.
Figure Q3
Question 4
a. Consider the single phase controlled half wave bridge rectifier shown in Figure Q4.
The firing delay angle is 45
0
. Draw the waveforms of the half wave bridge rectifier for
the following clearly labeling the graphs.
1) Supply voltage ( v
s
)
2) Output voltage ( v
o
)
3) Output current ( i )
4) Voltage across the SCR (v
SCR
)
Figure Q4
b. A controlled half wave rectifier has an ac source of 240Vrms
at 60 Hz. The load is a
25O resistor. Determine the following
1) delay angle such that the average load current is 3A.
2) power absorbed by the load.
3) power factor.
Question 5
The single phase full bridge rectifier shown below has an AC source with V
m
=100V at
60Hzand a series R-L load with R
L
=10 and L= 10mH.
Determine
1) the average current in the load
2) the power absorbed by the load
3) the average and rms current in the diode.
Figure Q5
END