Académique Documents
Professionnel Documents
Culture Documents
2. When you complete the first wrap, feed the wire through the center of the circle so it wraps around itself in the clockwise direction as shown. Use a little glue (hot melt or silicone preferable) to hold the wire in place where it crosses over itself.
4. Go around the circle about one third of the way, and wrap the cable around itself again, just like in step 3. Go around the circle another third of the way, and do the same thing again. You should have 3 wraps around the cable for each time you go around the circle.
5. Continue this way, repeating step 4, until you have used up all of the cable. As shown to the right, stay on the same side of the previous wrap with each new revolution. The 'knots' will run together.
When you are finished, use a little glue to hold the end of the cable in place. The coil should look like this when you are finished.
Just keep wrapping the cable around itself (clockwise) as you go around the circle. With a little practice, you will find that the windings form a pattern, and if you make a mistake it will be obvious as it does not fit the pattern. This coil tends to hold its shape better than the single knot style, and I generally just wind it by itself, not on a core. You should measure the diameter of the object you wish to place in the coil as a core when it is finished, and start with a circle a little larger than the diameter of the intended core.
We recommend using a Quartz, 'Moquis Marble', or Kyanite core for mobius coils, because scalar energy can sometimes be biologically disruptive when in 'raw' states. This information is primarily intended for those who wish to use mobius coils as a means of exciting Quartz crystals or Orgone Matrix Material, and you are responsible for your own safety. By making this coil you agree not to hold me responsible for any damages your experiments may cause to persons or property. Mobius coils generate scalar waves. Scalar waves can interfere with and/or damage electronics when high voltage is put through them. For the purposes of Orgone research, low voltages are sufficient to drive mobius coils.