Académique Documents
Professionnel Documents
Culture Documents
STANDAPOL WAQ-LC
3. Hazards identification
EMERGENCY OVERVIEW Warning: Causes severe skin and eye irritation, and possibly burns. May be harmful if swallowed.
Cognis Corporation
Material Safety Data Sheet
Page 2 of 8
SDS no. : 198435
STANDAPOL WAQ-LC
Color(s): almost colorless Routes of entry: Skin contact Potential Health Acute Effects: Inhalation: May cause respiratory irritation. Skin contact: Causes severe skin irritation. Eye contact: Causes serious eye irritation. Ingestion: May be harmful if swallowed. Potential Chronic Health Effects: None known Carcinogen Status
Hazardous components Formaldehyde 50-00-0 NTP Carcinogen HAZ_DES: Anticipated carcinogen.: Listed. IARC Carcinogen OSHA Carcinogen
CAR_HUMAN: Limited HAZ_DES: Potential data.CAR_ANIMAL: cancer hazard.REF: 29 Sufficient data.OVERALL: CFR 1910.1048 Group 1
Cognis Corporation
Material Safety Data Sheet
Page 3 of 8
SDS no. : 198435
STANDAPOL WAQ-LC
After ingestion: Give one to several glasses of water to drink and refer to medical personnel or take direction from either a physician or a poison control center.
Flammable/Explosive limits: Lower limits: Not determined. Upper limits: Not determined. Suitable extinguishing media: Water Spray Foam. Carbon dioxide. Dry Chemical Unusual fire or explosion hazards: None known Hazardous combustion products: Carbon dioxide., carbon monoxide, Sulphur oxides Additional fire fighting advice: In case of fire, keep containers cool with water spray. If a spill or leak has not ignited, use water spray to disperse the vapors. Water spray may be used to flush spills away from fire.
Cognis Corporation
Material Safety Data Sheet
Page 4 of 8
SDS no. : 198435
STANDAPOL WAQ-LC
Process for cleaning and take-up: Pick up spilled material and containerize for recovery or disposal. Flush area with water to remove residues.
USA Basis ACGIH NIOSH NIOSH NIOSH NIOSH OSHA OSHA OSHA OSHA OSHA Z1A OSHA Z1A US CA OEL US CA OEL US CA OEL
Type Ceiling Limit Value: Recommended exposure limit (REL): Recommended exposure limit (REL): Ceiling Limit Value and Time Period (if specified): Ceiling Limit Value and Time Period (if specified): Reference: Time Weighted Average (TWA). Short Term Exposure Limit (STEL): OSHA Action level: Time Weighted Average (TWA). Short Term Exposure Limit (STEL): Time Weighted Average (TWA) Permissible Exposure Limit (PEL): Short Term Exposure Limit (STEL): TWA Action Level: Value 0.3 ppm 0.016 ppm 0.016 ppm 0.1 ppm 0.1 ppm 29 CFR 1910.1048 others 0.75 ppm 2 ppm 0.5 ppm 0.75 ppm 2 ppm 0.75 ppm 2 ppm 0.5 ppm Category Remarks
15-min 15-min
Cognis Corporation
Material Safety Data Sheet
Page 5 of 8
SDS no. : 198435
STANDAPOL WAQ-LC
Personal protection measures: Respiratory protection: NIOSH/MSHA approved respirator if necessary. Follow manufacturer's recommendations. Hand protection: Protective gloves made of plastic. Protective gloves made of rubber. Eye protection: Wear tight fitting goggles.
Designation
pH-value; Solvent: Water pH-value; Conc.: % Melting point Density Specific gravity Solubility in Water
Value
7-9 7-9 < 10 C (< 50F) 1.030 g/cm3 1.030 Complete, Soluble in All Proportions
Method
no information
no information
Cognis Corporation
Material Safety Data Sheet
Page 6 of 8
SDS no. : 198435
STANDAPOL WAQ-LC
Hazardous polymerization: Will not occur
Cognis Corporation
Material Safety Data Sheet
Page 7 of 8
SDS no. : 198435
STANDAPOL WAQ-LC
Immediate Health
none
none
US. EPA Emergency Planning and Community Right-To-Know Act (EPCRA) SARA Title III Section 302 Extremely Hazardous Substance (40 CFR 355, Appendix A) Formaldehyde CAS: 50-00-0 0.035%
US. EPA CERCLA Hazardous Substances (40 CFR 302) Formaldehyde CAS: 50-00-0 0.035%
This product contains the following chemical/s known to the State of California to cause cancer and/or birth defects or other reproductive harm. Formaldehyde CAS: 50-00-0 0.035%
Cognis Corporation
Material Safety Data Sheet
Page 8 of 8
SDS no. : 198435
STANDAPOL WAQ-LC
Value 3 1 0
All information, recommendations, and suggestions appearing herein concerning our product are based upon tests and data believed to be reliable. However, it is the user's responsibility to determine the safety, toxicity, and suitability for his own use of the product described herein. Since the actual use by others is beyond our control, no guarantee, express or implied, is being made as to the effects of such use, the results obtained, or the safety and toxicity of the product nor is their any assumed liability arising out of use, by others, of the product referred to herein. The information herein is not to be construed as absolutely complete since additional information may be necessary or desirable when particular or exceptional conditions or circumstances exist or because of applicable laws or government regulations.