Vous êtes sur la page 1sur 7

4/8/2014

EASA part 66 licence, from Licence By Post

Aircraft licence distance learning


In very general terms the present system of the EASA Part 66 licence came in, for almost all aircraft weights, in 2005. In 2012 Part 66 was amended to include aircraft at or below 2000kg MTOM (mean take-off mass). EASA Part 66 applies to all EU countries as well as some countries outside the EU. Before then the British Civil Airworthiness Requirement (BCAR) section L licence was used (the Licence Without Type Rating - LWTR) and is still in use in some countries. The EASA Part 66 Licence Experience Requirements The EASA Modules The BCAR Licences CAA Examination Venues

The EASA Part 66 Licence


The Part 66 licence is required for engineers to obtain approvals to work on aircraft. These approvals are issued by companies who are themselves approved by the CAA (EASA Part 145) usually after type training. The approved engineer can sign off work on the aircraft within his/her licence authority. So for anyone who aspires to work on civil aircraft as a maintenance engineer the Part 66 is a must. This means passing all the modules that go to make up that particular licence. The licence categories are: Category A Category B1 Category B2 Category B3 Category C Line mechanic (airframes and engines). Licensed engineer (mechanical, airframes and engines). Licensed engineer (avionics). Licensed engineer (piston engined aircraft of mass 2000kg and below). Licensed engineer (base maintenance).

Category A
Issued after passing the appropriate modules and obtaining the appropriate experience. The person is allowed to sign for certain designated tasks only. Not recommended as a stepping stone to the B1 licence as all the module examinations will have to be taken again to the higher level. A1 Turbine Engined Aeroplanes
1/7

http://www.licencebypost.com/easa_part_66_licence.htm

4/8/2014

EASA part 66 licence, from Licence By Post

A2 A3 A4

Piston Engined Aeroplanes Turbine Engined Helicopters Piston Engined Helicopters

Experience requirements can vary but would be a maximum of 3 years maintenance experience on operating aircraft (certified in a record of experience log book).

Category B
The licence is issued after passing all the appropriate modules and obtaining the appropriate experience. Allows the engineer to sign the Certificate of Release to Service for the aircraft in the category for which he/she is licensed. Experience required (gained within the 10 years preceding application): B1.1 B1.2 B1.3 B1.4 B2 B3 Turbine Engined Aeroplanes Piston Engined Aeroplanes Turbine Engined Helicopters Piston Engined Helicopters Avionic Aircraft below 2,000kg mass 5 years maximum 3 years maximum 5 years maximum 3 years maximum 5 years maximum 3 years maximum

At least 1 year of the experience shall be recent experience gained on aircraft type for which application is to be made. Experience requirements stated above are based on no previous qualifying technical training or approved courses passed. If you have technical qualifications and/or passed an approved course then you may be eligible for a reduced experience requirement in this case you should apply to the CAA for details/check their website. The experience requirement is based on appropriate maintenance engineering on operating aircraft. For UK service personnel with qualifying service experience this may count for all of the experience requirement except for 1 year this will have to be gained on civil aircraft (all recorded in the log book of course).

Category C
Requires 3 years experience as a B1.1, B1.3, or B2 engineer or 5 years as a B1.2 or B1.4 engineer.

Experience Requirements
There are no experience requirements to be allowed to sit the examinations, they apply only when licence application is made. As the individual module examination passes have a life of 10 years it is important that all the exams for a particular licence are passed within 10 years of passing the first module. All the above experience requirements must include one year's recent experience and that experience must include equipment for which application is made. In other words if you are
http://www.licencebypost.com/easa_part_66_licence.htm 2/7

4/8/2014

EASA part 66 licence, from Licence By Post

applying for the B1.1 licence mechanical jet engined aircraft the one year recent experience must be on this type of aircraft not on helicopters for example. The experience must include a representative cross section of tasks on operating aircraft* and should include, for the mechanical person, some experience on instrument, electrical and avionic systems. Experience in maintenance bays (engine bays, instruments bays, tyre bays etc) is not considered appropriate.
* The term operating aircraft means that the aircraft must be a flying aircraft and the servicing could include ramp/first line servicing and/or hangar maintenance. The term operating aircraft does not include work on gliders and UAVs (Unmanned Aerial Vehicles).

For more details you are advised to read EASA Part 66. It can be obtained from TSO at Norwich, UK or viewed on the net www.caa.co.uk/publications.

The EASA Modules


The syllabus for these is published in the EASA Part 66, which is issued by EASA as an official publication of the EU. Note that for licences A, B1, B2 and B3 the level of some module examinations is different. Note that, in the following table, shortened titles are used to save space. MODULE 1 2 3 4 5 6 7A 7B 8 9A 9B 10 11A 11B 11C 12 13 14 SHORT TITLE Mathematics Science Electrics Electronic Digital techniques Hardware Maintenance practices Maintenance practices Aerodynamics Human factors Human factors Air law Airframes (jet) Airframes (piston) Airframes (piston) Helicopters Avionics Engine instruments
3/7

APPLICABILITY A B1 B2 B3

A1 A2 A3, A4

B1.1 B1.2 B1.3, B1.4

http://www.licencebypost.com/easa_part_66_licence.htm

4/8/2014

EASA part 66 licence, from Licence By Post

15 16 17A 17B

Jet engines Piston engines Propellers Propellers

A1, A3 A2, A4 A1, A2

B1.1, B1.3 B1.2, B1.4 B1.1, B1.2

M odules Required
For Category A licence - modules 1 to 6 except module 4, plus modules 7A, 8, 9A and 10 plus: A1 A2 A3 A4 11A, 15 & 17A 11B, 16 & 17A 12 & 15 12 & 16

For Category B licence - modules 1 to 6, plus: B1.1 B1.2 B1.3 B1.4 B2 B3 7A, 8, 9A, 10, 11A, 15 & 17A 7A, 8, 9A, 10, 11B, 16 & 17A 7A, 8, 9A, 10, 12 & 15 7A, 8, 9A, 10, 12 & 16 7A, 8, 9A, 10, 13 & 14 7B, 8, 9B, 10, 11C, 16 & 17B

Notes
1. The first 10 modules are common (except for module 4 for the category A person). However, the exact content of each exam for a particular module will vary depending on what licence the engineer is aiming for. This means that for the A person, parts of some modules are not examined on at all and other areas are taken at a lower level than the B level. For the B person (in very general terms) the differences in the level of difficulty in those modules where there are differences are: MODULE 1 2 3 4 5 6 7A 8 9A THE HIGHER LEVEL IS THE: B B1 B1/B2 B2 B2 B1 B1 but B2 for item 7.7 B1/B2 B1/B2
4/7

http://www.licencebypost.com/easa_part_66_licence.htm

4/8/2014

EASA part 66 licence, from Licence By Post

10

B1/B2/B3

The above is not significant (assuming you take the examination to the correct level for the licence you are aiming for), unless you intend taking another licence after you have obtained the present one. For example: If you are going for the B1 and intend taking the B2 at a later date then it would be prudent to take modules 4 and 5 as a B2 examination (the higher level). If you are presently going for the B2 and plan to eventually go for the B1 then it would be wise to take modules 2, 6 and 7 at the B1 level. The levels of modules 1, 3, 8, 9A and 10 are the same for both B1 and B2 examinations. 2. Some of our modules (6 and 7A for example) we have managed to split into B1 and B2. When ordering ensure that you order the correct module. 3. For those modules we have not split into B1/B2, then they have been written to the higher level in each case. 4. The CAA examination consists of a multi-choice paper for each module and an essay paper for modules 7, 9 and 10. 5. For CAA examination purposes the modules can be taken in any order (including the essay papers), though there are too many to be taken all in one day. Unless you have a long way to travel it would be better to take the bigger modules one at a time and the smaller ones either singly or in twos or threes. 6. It is generally considered better to take the essay exam for module 7 when doing the multi choice paper for module 7, with the same principle applying for the essay papers for modules 9 and 10. Remember, in all cases there is an exam fee payable for both the essay paper and the multi choice paper. (If the essay questions are all taken together then there is one fee payable.) 7. Suggested sequence for taking the modules. Take 1 to 5 in order. Take 6 and 7 together at any time. Take 8, 9 and 10 at any time in any order. Take the trade modules last (11 to 17). 8. There are almost no exemptions allowed against any of the module examinations. Certain degrees will attract exemptions to some modules for details contact the CAA. Remember. The modules, once passed, have a life of 10 years so if you do not complete all the modules in 10 years you will start to loose the first modules passed. Applicants must be at least 18 years of age.

The BCAR Licences


Used in the UK for all civil aircraft until 2001 when it was phased out (for aircraft above 5700kg) in favour of the then JAR66 licence. In 2003 the JAR66 licence was replaced by the EASA Part 66 licence which, effectively, covered all aircraft weights. Conversions for those holding BCAR licences where allowed and must have been completed by November 2005. For those still holding BCAR licences; these had to be converted to EASA Part 66 licences (with restrictions). (We provide part modules to cover the lifting of the restrictions contact LBP.) In some countries the BCAR section L issue 14 Licence Without Type Rating (LWTR) is still
http://www.licencebypost.com/easa_part_66_licence.htm 5/7

4/8/2014

EASA part 66 licence, from Licence By Post

being used. Divided into: Cat A Cat C Cat A & C Cat X Aeroplanes 1 Piston engines (with aeroplanes 1) Turbine engines (with aeroplanes 1) Rotorcraft piston Rotorcraft turbine Electrical Instruments Autopilots (fixed wing or rotary wing) Radio Radar

Cat R

We stock Study Books covering the LWTR licences. Please contact LBP for details.

CAA Examination Venues


The module examinations are taken at CAA examination centres in the UK (currently Gatwick, Oxford, Glasgow, Manchester and Shuttleworth College near Biggleswade); also at some Part 145 companies and certain overseas locations (check CAA website). The CAA centre at Aviation House Gatwick is a 5 minute bus ride from the terminals at London Gatwick Airport and is a popular venue for students coming from overseas. Gatwick can also be reached by bus from London Heathrow Airport (about 25 miles 40km). Another venue used by overseas students is the one at Oxford. This can be reached by bus from London Heathrow Airport (about 45 miles 72km). The exams are held at Oxford Airport which is a 10 minute walk from the village of Kidlington which is itself about 5 miles (8km) north of Oxford. Dates for exams at CAA centres are usually the first Friday in each month. The UK CAA examinations are mainly taken in the UK but there are now some locations else-where in the world where the exams are conducted, Malaysia for example. Check the CAAs website for details. For accommodation details at Oxford and Gatwick check our Contacts page. All students with LBP are provided with CAA application forms, dates, venues etc, and advice on how and when to apply for the examinations. CAA examination fees vary and at the time of writing (2012) are 43-00 each module. Note that if the essay papers for modules 7, 9 & 10 are taken in one sitting the fee is one fee (4300).

More from Aircraft licence distance learning


Click on the links below to learn in more detail about courses and the service we offer.
http://www.licencebypost.com/easa_part_66_licence.htm 6/7

4/8/2014

EASA part 66 licence, from Licence By Post

Aircraft Licences index A complete study and tutorial service for the aircraft engineer How to study for your aircraft licence The EASA part 66 licence Aircraft licence exams

http://www.licencebypost.com/easa_part_66_licence.htm

7/7

Vous aimerez peut-être aussi