Académique Documents
Professionnel Documents
Culture Documents
ATrack Technology Inc. 9F, No. 285, Sec. 2, Tiding Blvd., Neihu Dist., Taipei City 11493, Taiwan (R.O.C.)
Confidential Document
Contents
1. Notification .............................................................................................................................. 3
1.1. Disclaimer .................................................................................................................................... 3 1.2. Copyright ...................................................................................................................................... 3 1.3. Warning ........................................................................................................................................ 3
2.
Hardware ................................................................................................................................. 4
2.1. Package Content ......................................................................................................................... 4 2.2. Pin Assignments........................................................................................................................... 5 2.2.1. Serial Cable (JST Female Connector to DB9 Female Connector) .......................................... 5 2.2.2. Power/IO connector (Male; On Device) ................................................................................... 5 2.3. Access Point/Router Security Mode Supported ........................................................................... 6
3.
4.
Appendix................................................................................................................................ 14
4.1. Hardware Specification .............................................................................................................. 14
Page 2 of 15
Confidential Document
1. Notification
1.1. Disclaimer
This document, and all other related products, such as device, firmware, and software, is developed by ATrack Technology Inc. thoroughly. At the time of release, it is most compatible with specified firmware version. Due to the functionalities of the devices are being developed and improved from time to time, the change in the protocol, specification, and firmware functions are subjects to change without notice. ATrack Technology Inc. is obligated to modify all the documentation without the limitation of time frame. A change notice shall be released to ATrack Technology Inc. customers upon the completion of document modification.
ATrack Technology Inc. products are not intended to be used as life support or rescue equipments. ATrack Technology Inc. is not liable for any loss or injury caused by using or referencing to any products. Any possible means of using or integrating ATrack Technology Inc. products shall be avoided.
1.2. Copyright
ATrack Technology Inc. holds all parts of intellectual rights applicable in the copyright laws in all the countries. Any or all parts of this document shall not be exposed to non-authorized party without any form of approval from ATrack Technology Inc. Any forms, including but not limited to oral, copy, or internet sharing, of releasing or exposing information to an unauthorized party shall be prohibited. ATrack Technology Inc. reserves the rights of litigation in the violation of such copyright laws.
1.3. Warning
Connecting the wire inputs can be hazardous to both the installer and your vehicles electrical system if not done by an experienced installer. This document assumes you are aware of the inherent dangers of working in and around a vehicle and have a working understanding of electricity.
Page 3 of 15
Confidential Document
2. Hardware
2.1. Package Content
Each package contains the following device/accessories: Device * 1 Wifi (COM) Antenna * 1
GPS Antenna * 1
Power/IO Cable * 1
Serial Cable * 1
Page 4 of 15
Confidential Document
Positive Inputs: IN0, IN1 (Triggered when connects to V+ range from 3.7 ~ 40V) Negative Inputs: IN2, IN3 (Triggered when connects to ground range from 0.8 ~ 0V) Analog Input: 0 ~ 40 V; 10-bit Resolution. All outputs are open collector type (grounded when enabled). DO NOT CONNECT ANY POWER SOURCE TO 1-WIRE IO AND 1-WIRE GND TO AVOID DAMAGE. ATrack Technology Inc. All Rights Reserved. Page 5 of 15
Confidential Document
AY5(i) supports the following WPA2-Personal/ WPA-Personal and WEP modes: WPA2/WPA-Personal: WPA2-Personal with AES-CCMP for both the unicast and group keys. The AP advertises the ciphers in the RSN information element (IE), number 48 WPA2-Personal mixed mode with AES-CCMP for the unicast key and TKIP for the group key. The AP advertises the ciphers in the RSN IE WPA-Personal with TKIP for both the unicast and group keys. The AP advertises the ciphers in the WPA IE, number 221 WPA-Personal mixed mode with AES-CCMP for the unicast key and TKIP for the group key. The AP advertises the ciphers in the RSN IE and the WPA IE WEP: WEP104 with pre-shared keys and open authentication
Page 6 of 15
Confidential Document
3. Firmware Upgrade
3.1. Firmware Upgrade by serial connection
(1) Run HyperTerminal program
Page 7 of 15
Page 8 of 15
Confidential Document (4) Choose 57600,8,N,1 None flow control properties and click [OK] button.
Page 9 of 15
Confidential Document (6) Click [Settings] tab and [ASCII Setup] button
Page 10 of 15
Confidential Document (8) Power ON the device. The startup message will show on the screen.
(9) Type AT$FWDL command and press [Enter] key. Choose [Transfer][Send File]
Page 11 of 15
Confidential Document (10) Choose the firmware filename which is provided by ATrack and select [Ymodem] Protocol option and click [Send] button.
(11) When [Send] button is clicked, the file transfer progress will show as below:
Page 12 of 15
Confidential Document (12) When file sending is completed, the device will program and restart itself automatically.
Page 13 of 15
Confidential Document
4. Appendix
4.1. Hardware Specification
AY5i Wireless LAN Specification Wireless Solution Standards Frequency Bandwidth RF Modulation Operating Channels Security Transmission Rates G2 Microsystems IEEE 802.11 b/g 2402 ~ 2480MHz 22MHz DSSS, OFDM 1-14 WEP, WPA-PSK, WPA2-PSK 802.11b: 1, 2, 5.5, 11Mbps 802.11g: 6, 12, 24, 36, 54Mbps TX Transmit Power 802.11b: 14dbm 802.11g: 12dbm RX Sensitivity WiFi Antenna Gain GPS Specification Frequency C/A code Channels Accuracy (Open Sky) Datum Time To First Fix (TTFF) L1, 1575.42 MHz 1.023 MHz chip rate. 48 <2.5 meters (50% 24hr Static, -130dBm). WGS-84. Hot start1 sec., average Warm start35 sec., average. Cold start35 sec., average. Sensitivity (Autonomous) Acquisition: -148dBm Tracking: -163dBm Navigation: -160dBm Dynamic Conditions Altitude : <18,288 meters Max Velocity515 m/s (<1,000 knots) Max Acceleration4G, Max -85dBm Max. 1.12 (dBi)
Page 14 of 15
Confidential Document Build In Function Accelerometer Real-Time Clock Memory Capacity Built-In 3-Axis @ 16GMAX Built-In 8MB
Electrical Characteristics Power Source Power Consumption Operational Sleep Deep Sleep 8-40 VDC 80 mA @ 12VDC 18 mA @ 12VDC 4 mA @ 12VDC
I/O Characteristics Device I/O Ports Positive Inputs Negative Inputs Analog Input Negative Outputs Serial Configurable Baud rates 2 2 1 3 1 1200, 2400, 4800, 9600, 19200, 38400, 57600, 115200 bps 1-Wire (AY5i only) 1 (Triggering voltage: 3.7 ~ 40V) (Triggering voltage: 0 ~ 0.8V) (0 ~ 40V with 10-bit resolution) (Open Collector Type @ 300mAMAX)
Environmental Characteristics Operation Temperature -30 ~ +65C (Note: Temp. up to +85C with extreme condition) Storage Temperature Relative Humidity -40 ~ +85C 5 ~ 95%
Page 15 of 15