Académique Documents
Professionnel Documents
Culture Documents
Adjustment Voltage Regulator circuit is an electronic device that can supply direct current or DC
that are contained in an electronic device can work well . Component that is the source of DC
power supply is best battery or batteries . However , for applications requiring larger power
supply , so that the source of the battery alone is not enough .
Power supply source and the greatest good in use is a source of alternating current AC (
alternating current ) which is a source of power generation . To be able to use the power plant , in
perlukanlah a power supply device that can alter the flow of AC ( alternating current ) into DC
current ( direct current) .
Usually the voltage regulator circuit adjustment using a stable power supply and zener diode as a
voltage stabilizer . To be able to control the level of higher precision , then we can use a voltage
regulator . Regulatory component that is in use is an IC which often have three legs terminals
and has a shape similar to a power transistor .
Rectifier circuit in saying nice if the voltage ripple is small. If the voltage PLN up and down ,
then the output voltage will also go up and down . When current flows greater , the DC voltage
discharge also go down . Changes in voltage applications is quite disturbing , so in need of active
components that can regulate the voltage becomes stable .
The following Image Adjustment Voltage Regulator circuit schematic :
MSK5012 is adjustable voltage regulator that is extremely reliable . Whose output can be
programmed by using two resistors . This regulator has a dropout voltage is very low ( 0.45v @
10A ) for use MOSFT with very low RDS . The MS5012 has a high degree of accuracy and
ripple rejection of about 45dB . It is available in a 5 pin package electrically isolated from the
internal circuits . It gives us the freedom to enter the IC directly to the heat sink and the heat sink
of this kind directly improve heat dissipation .
The output voltage of this circuit is adjustable from 1.3v to 36v DC . Resistors R1 and R2 are
used for programming voltage . For all applications , the value of R2 is fixed 10K . The
relationship between R1 , R2 and the output voltage Vout is according to the equation R1 = R2 (
Vout/1.235 ) -1 . C1 is a filter capacitor is also part of the MOSFET gate drive circuitry .
Approximately three times the input voltage will appear across the capacitor and the voltage
rating should be appropriate choices . C2 is the input filter capacitor while the output filter
capacitor C3 is .