Vous êtes sur la page 1sur 2

Apr 27 07:52:24 10.125.6.4 745839: Apr 27 12:52:24.

109: %CS7MTP3-5-LINKUPDOWN: Link 0


in linkset TNS_SA_STP is unavailable


These alerts are critical if both TNS_SA and TNS_FW links are reported "Unavailable" and are not
getting up after 10 seconds. It means there is a problem somewhere, and normally should be ip
connectivity failure between Toronto King Street and TNS's network in San Antonio or FortWorth
US.

Normally if one of this above two links goes down, the service is not affected because traffic will be
rerouted via the other link automatically.
If both links go down, then roaming traffic is affected.


005-120-004 is the Primary point code for traffic. In 005-120-004 STP there are 3 Links:
1* towards TNS_SA and 1* towards the other STP2 and 1* towards STP0 (Inuvik)



lsn=LINK_TO_STP_2G_IVK apc=5-73-8 state=avail avail/links=1/1
SLC Interface Service PeerState Inhib
00 199.47.48.142 3576 3576 avail InService -----

lsn=LINK_TO_STP_2 apc=5-120-11 state=avail avail/links=1/1
SLC Interface Service PeerState Inhib
00 10.125.6.5 4000 4000 avail InService -----

lsn=TNS_SA_STP apc=238-27-0 state=avail avail/links=1/1
SLC Interface Service PeerState Inhib
00 204.28.239.23 21060 3565 avail InService -----


In case the link TNS_SA fails, the STP will declare routeset Unavailable will choose the secondary
route for traffic (being STP which is linked to TNS_FW):

Destination Prio Linkset Name Route
---------------------- ---- ------------------- -------
5-73-4/24 acces 5 LINK_TO_STP_2G_IVK avail
5-73-6/24 acces 5 LINK_TO_STP_2G_IVK avail
5-73-8/24 acces 1 LINK_TO_STP_2G_IVK avail
5-120-11/24 acces 1 LINK_TO_STP_2 avail
238-1-0/24 acces 1 TNS_SA_STP avail
238-2-0/24 acces 1 TNS_SA_STP avail
238-13-150/24 acces 5 TNS_SA_STP avail
9 LINK_TO_STP_2 avail
238-27-0/24 acces 1 TNS_SA_STP avail



On TNS side is similar, 005-120-004 is Primary but if this link becomes unavailble, the route will
be declared unavailable as well and in that case TNS STP2 will choose the 005-120-011 for traffic
(STP2).

This is done like this as we do not support Virtual Point Code that would help to create redundancy
on MTP2 / M2PA level and not MTP3 level.

Vous aimerez peut-être aussi