Vous êtes sur la page 1sur 3

Homework 1 Solution Set

Blake Chapter 6 Problems 1-8


8 points (1 per problem)


1. Find the wavelength for radio waves in free space at each of the following frequencies:

a) 160 MHz: m
MHz
s m
f
v
875 . 1
160
/ 10 3
8
=

= =
b) 800 MHz: m
MHz
s m
f
v
375 . 0
800
/ 10 3
8
=

= =
c) 2 GHz: m
GHz
s m
f
v
15 . 0
2
/ 10 3
8
=

= =


2. How far does a radio wave travel through space in one microsecond?

m s s m RT D 300 ) 1 )( / 10 3 (
8
= = =

3. Visible light has a range of wavelengths from approximately 400 nanometers (violet) to 700
nm (red). Express this as a frequency range.

Since
f
v
= , we can rearrange the equation to solve for frequency:

THz Hz
nm
s m v
f
RED
57 . 428 10 2857 . 4
700
/ 10 3
14
8
= =

= =


THz Hz
nm
s m v
f
VIOLET
750 10 5 . 7
400
/ 10 3
14
8
= =

= =



4. Calculate the characteristic impedance of an open wire transmission line consisting of two
wires with diameter 1 mm and separation 1 cm.

=

= 359
1
) 1 ( 2
ln
1
120 2
ln
120
0
mm
cm
d
s
Z
r



Note:
r
is the dielectric constant of the insulator, air in this case. Textbook uses the
formula Z0=276log(D/r) which gives same result, but only for air dielectric lines.

5. Calculate the characteristic impedance of a coaxial line with a polyethylene dielectric, if the
diameter of the inner conductor is 3 mm and inside diameter of the outer conductor is 10
mm.

=

= 6 . 47
3
10
ln
3 . 2
60
ln
60
0
mm
mm
d
D
Z
r



Note: Polyethylene has a dielectric constant of 2.3. Textbook uses the formula
Z
0
=138/sqrt(
r
) * log(D/D) which is equivalent.



6. Repeat problem 1 for waves on a coaxial cable with a solid polyethylene dielectric.

To solve these, find the velocity of signals on the cable. First, calculate the velocity factor:

6593 . 0
3 . 2
1 1
= = =
r
VF

(You need to know the dielectric type; given as polyethylene)



The velocity of propagation is:

s m s m VF c v / 10 978 . 1 ) 6593 . 0 )( / 10 3 (
8 8
= = =

With this information in hand, we can now find the wavelengths:

a) 160 MHz: m
MHz
s m
f
v
236 . 1
160
/ 10 978 . 1
8
=

= =
b) 800 MHz: m
MHz
s m
f
v
247 . 0
800
/ 10 978 . 1
8
=

= =
c) 2 GHz: m
GHz
s m
f
v
099 . 0
2
/ 10 978 . 1
8
=

= =


7. Repeat problem 2 for a radio wave propagating along a coaxial cable with polyethylene foam
dielectric.

First, calculate the new velocity of propagation. NOTE that the dielectric constant for
polyfoam varies with its composition (it is polyethylene blown up with nitrogen gas, which is
inert.)

877 . 0
3 . 1
1 1
= = =
r
VF


s m s m VF c v / 10 63 . 2 ) 877 . 0 )( / 10 3 (
8 8
= = =

m s s m RT D 263 ) 1 )( / 10 63 . 2 (
8
= = =

8. How long a line is required to produce a 45 degree phase shift at 400 MHz if the dielectric is

a) air?

First, find the wavelength (which is 360 degrees of electrical length):


m
MHz
s m
f
v
75 . 0
400
/ 10 3
8
=

= = (Since dielectric is air, v=3x10


8
m/s, same as free space)

Now translate that into a physical length, knowing that 360 degrees = 0.75 m:

m m L 09375 . 0
360
45
) 75 . 0 (
360
= = =




b) solid polyethylene?

The velocity of propagation will fall, shortening the wavelength:

6593 . 0
3 . 2
1 1
= = =
r
VF


s m s m VF c v / 10 978 . 1 ) 6593 . 0 )( / 10 3 (
8 8
= = =

m
MHz
s m
f
v
494 . 0
400
/ 10 978 . 1
8
=

= =

Finally, the physical length will now be:

m m L 062 . 0
360
45
) 494 . 0 (
360
= = =

Vous aimerez peut-être aussi