0 évaluation0% ont trouvé ce document utile (0 vote)
13 vues4 pages
Detroit Diesel Diagnostic Link - Instrumentation Printed on J uly 01, 2013 DDC VIN: 1FUJ A6CV75LN90529 Engine Serial Number: 460926 00 787457, - VCU version:14.19, PLD version:60A ( ) - Page 1 of 4 Chart Recorder Name Value Minimum Maximum Units Accelerator Pedal Pos 0 0 100 % 0:00 2:00.
Detroit Diesel Diagnostic Link - Instrumentation Printed on J uly 01, 2013 DDC VIN: 1FUJ A6CV75LN90529 Engine Serial Number: 460926 00 787457, - VCU version:14.19, PLD version:60A ( ) - Page 1 of 4 Chart Recorder Name Value Minimum Maximum Units Accelerator Pedal Pos 0 0 100 % 0:00 2:00.
Detroit Diesel Diagnostic Link - Instrumentation Printed on J uly 01, 2013 DDC VIN: 1FUJ A6CV75LN90529 Engine Serial Number: 460926 00 787457, - VCU version:14.19, PLD version:60A ( ) - Page 1 of 4 Chart Recorder Name Value Minimum Maximum Units Accelerator Pedal Pos 0 0 100 % 0:00 2:00.
DDC VIN: 1FUJ A6CV75LN90529 Engine Serial Number: 460926 00 787457 , - VCU version:14.19, PLD version:60A ( ) - Page 1 of 4 Chart Recorder Name Value Minimum Maximum Units Accelerator Pedal Pos 0 0 100 %
0:00 2:00
Detroit Diesel Diagnostic Link - Instrumentation Printed on J uly 01, 2013 DDC VIN: 1FUJ A6CV75LN90529 Engine Serial Number: 460926 00 787457 , - VCU version:14.19, PLD version:60A ( ) - Page 2 of 4
Other Instrumentation EGR Temperature after EGR cooler --- Engine Speed 705 rpm Barometric Pressure 14.4 psi Boost Pressure 0.1 psi Vehicle Speed 0 mph Battery Potential 12.6 V Accelerator Pedal Pos 0 % Percent Engine Load 11 % Engine Coolant Temp 187 F Intake Air Temp 108 F Engine Oil Temperature 189 F Fuel Temperature 145 F Mechanical Engine Speed 705 rpm Battery Potential 12.6 V Requested Engine Torque(VCU) -92 ft.lb Output Torque 0 ft.lb Actual engine torque(PLD) 26 ft.lb Vehicle Speed 0 mph Accelerator Pedal Pos 0 % Percent Engine Load 11 % Pressure Engine Oil Pressure 22.0 psi Boost Pressure 0.1 psi Air Inlet Pressure --- Air Filter Differential Pressure --- Barometric Pressure 14.4 psi Temperature Intake Air Temp 108 F Fuel Temperature 145 F Engine Coolant Temp 187 F Engine Oil Temperature 189 F Voltage Status Detroit Diesel Diagnostic Link - Instrumentation Printed on J uly 01, 2013 DDC VIN: 1FUJ A6CV75LN90529 Engine Serial Number: 460926 00 787457 , - VCU version:14.19, PLD version:60A ( ) - Page 3 of 4 Starter Output (MR-PLD) No Signal Starter Lock (MR-PLD) Not Active PWM1 -- Exhaust Flap or Turbobrake Status Active PWM2 -- EGR Valve or Constant Throttle Valve Status Active PWM3 -- Fan Status Not Active PWM4 -- Fan Status Not Active PWM5 -- Constant Throttle Valve (EGR) Not Active PWM6 -- Exhaust Flap or Turbobrake Sleeve Not Active Engine Protection / Derate Not Active Smoke Limiter Active Not Active Switches Throttle Select Switch Status (Pin 18/07) accelerator pedal Engine Brake Low Switch Status Not Active Engine Brake High Switch Status Not Active Remote PTO Switch Status Not Active Limiter 0 Set Switch Status Not Active Limiter 1 Set Switch Status Not Active Shutdown Override Switch Status Not Active Air Cond. / Limiter2 switch Status Not Active Fan Override Switch Status Not Active Idle Validation Switch Status forAccelerator Pedal Active Idle Validation Switch Status for Remote Accelerator Pedal Not Active DSF0 Pin 12/10 Switch Status Not Active DSF1 Pin 12/09 Switch Status Not Active Relay 1 Pin 15/12 Switch Status Not Active Relay 2 Pin 15/09 Switch Status --- Relay 3 Pin 15/11 Switch Status --- Relay 4 Pin 18/01 Switch Status --- Engine Hood (Bus) Switch Status --- Miscellaneous AC Status Comp Dischrg Not at high pressure Eng Ret Lvl switch 0Cyl Ign Sw Run On Warning Lmp Prot Off Warning Lmp Amber Off Warning Lmp Red Off Retarder Inhibit Status On Direction Switch Neutral N/A Brake Sys Stat Off Service Brake Stat Off Parking Brake Stat inactive CC Cruise Mode not active CC Clutch off CC Brake off CC Accel off CC Resume off CC Coast off CC Set off CC Cruise Cntl Sw off Cruise Ctrl Set Speed 0 mph PTO mode not active Detroit Diesel Diagnostic Link - Instrumentation Printed on J uly 01, 2013 DDC VIN: 1FUJ A6CV75LN90529 Engine Serial Number: 460926 00 787457 , - VCU version:14.19, PLD version:60A ( ) - Page 4 of 4 PTO Clutch off PTO Brake off PTO Accel off PTO Resume off PTO Coast off PTO Set off PTO Cntl Sw off Fuel Filter Differential Pressure 0.0 "Hg Engine Oil Level 100 % Coolant Level 100 % Engine Brake Off Trip Fuel 2752.0 gal Fuel Rate 0.7 gal/hour Inst. Fuel Economy 0.0 mpg Avg. Fuel Economy 4.5 mpg Rated Engine Speed 2208 rpm Total Idle Hours 7279.8 hours Trip Distance 12295.5 mi Total Vehicle Distance 596021.7 mi Speed Limit Adjustment --- OIThermostat --- OIAlarm --- OIArmed --- OIStarterRelay --- mmscOil Quality --- mmscAir Filter --- mmsc2nd Coolant Level --- mmscFuel Filter --- mmscOil Filter --- mmscOil Level --- PMC --- PMB --- PMA --- OIWarm --- OINormal --- OIOutside Normal --- OIAntiTamper --- OIArmed Time 0.0 sec OIRun Time 0.0 sec OIRecharge Battery 0.0 sec OISaving Trip Idle 0.0 min OISaving Total Idle 0.0 min OISaving Trip Fuel 0.0 gal OISaving Total Fuel 0.0 gal Active Code Count 0 Status Grid Heater Disabled