Manual : 3.8 X (4' O US qt, 3.3 l mp qrl Automati c: 3.7 t {3.9 US qt, 3.3 l mp qt} H22Al engi no: Manuaf : 4.O f 9.2 US qt, 3' 5 l mp qt) Loosen the air bleed bolt in the thetmostat housing, then fi l l the radi ator to the bottom of the ti l l er neck wi th the cool ant mi xtu.e. Ti ghten the bl eed bol t as soon as coolant stans to run out in a steadv stream wi thout bubbl es. BLEED BOLT 60 N.m {6.0 kg-m, 43 lb-ft} Applv liquid gasket to the bol t threads when i nstal l i ng. 1O. Wi th the radi ator cap oft, start the engi ne and l et i t run unti l warmed up (Radi ator fan goes on at l east twi ce). Then, i f necessary, add more cool ant mi x to bring the level back up to the bottom ot the filler neck. 11. Put the radi ator cap on ti ghtl y, then run the engi ne agai n and check tor l eaks. 10- 6 Radiator Engine Coolant nefill\ and Bleeding CAUTlOttl: When pouting engino coolaisQgsuro to shut th6 ralay box lid and not to lst coolanl spill on tho elec- trical part6 or lh paint. lf any coolant spills, rinse it off immodiat6ly. 1. Set the heater temperature l ever or conttol di al to maxamum heat. 2. Remove the engi ne spl ash shi el d. 3. When the radi ator i s cool , remove the radi ator cap. Loosen the drai n pl ug, and drai n the cool ant. 4. Remove the drai n bol t trom the rear si de of the cyl i nder bl ock to drai n the bl ock and heater, 5. Appl y l i qui d gasket to the drai n bol t threads, then reinstall the bolt with a new washer and tighten it securel y. 6. Ti ghten the radi ator drai n pl ug securel y. 7, Remove, drai n and rei nstal l the reservoi r. Fi l l the tank haltway to the MAX mark with water, then up to the MAX mark wi th anti -freeze. 8. Mi x the recommended anti -freeze wi th an equal amount ol water i n a cl ean contai ner. NOTE: a Use onl y genui ne Honda anti -Jreeze/cool ant. a Fof best corrosion Drotection, the coolant concen- trati on must be mai ntai ned year-round at 50 mi ni mum. Cool ant concentrati ons l ess than 50% may not provide sutficient protection against cor- rosi on or treezi ng. a Coolant concentrations greater than 60% will im- paif cooling efficiency and are not recommended. CAUTION: a Do not mix dilferent brands of anti-freoze/ cool ants. a Do not uso additional rust inhibitors or anti-rust products; they may not be compatible with tho gnuine coolant. Engine Coolant Refill Capacity: including reservoir {0.6 t {0.6 US qt, 0.5 l mp qt}l and heatar {0.6 f (o.6 US qt, 0.5 l mp qt)| . F22Al engi ne: Manual : 3. 5 I ( 3. 7 US qt , 3. 1 l mp qt ) Automati c: 3.4 f {3.6 US qt, 3.0 l mp qtl DRAII{ BOLT