Académique Documents
Professionnel Documents
Culture Documents
You already learn about balance cement plug and I would like to show how to calculate balance
cement plug.
1. Determine volume of cement that you need.
2. Determine height of cement and spacer when pipe in hole.
3. Determine displace volume to balance the hydrostatic both sides. When the displacement
is completed, you should have equal height of cement/spacer/mud. You can see the figure
below for more understanding.
4. When you pull cement stinger, you will have the balance set properly like this.
The operator plans to set abandonment plug in the open hole across the pay sand.
Well information is listed below:
7 casing shoe is set at 6000MD/5500TVD.
7 casing grade 23 ppf BTC, ID = 6.366 inch.
Drilling fluid: 10.0 ppg oil based mud
Hole size = 6.25 based on caliper log.
Hole TD = 12,000MD/10,000TVD
Pay sand is from 9000 9500 ft
The planned cement length is 1,000 ft.
The planned bottom of cement plug is 9,600 ft.
Spacer: 50 bbl of spacer and weight of spacer 10.5 ppg.
Cement stinger: 1200 ft of 2-7/8 tubing.
2-7/8 tubing ID is 2.44 inch.
Drill pipe size: 4 DP and ID of drill pipe is 3.35 inch.
Use 0% excess
Cement weight 16.0 ppg
Determine how much cement that we should need and how the displacement plan
should be.
Since there is pipe in the hole, the top of cement (TOC) will be higher.
It means that height of cement is 1,059 ft, therefore TOC when pipe in hole is 8541 ft (9,6001,059).
The plan is to pump 50 bbl of spacer; therefore, there might be some spacer up above the
cement stinger.
Volume of spacer from top of cement to top of cement stinger (Spacer volume1)
Spacer volume1 = annular capacity between hole and cement stinger x length of cement stinger
from TOP to top of stinger.
The rest of spacer which is 45.77 (50-4.23) bbl is in between drill pipe and hole.
Length of spacer between drill pipe and hole = spacer volume annular capacity between hole
and 4 DP
Length of spacer between drill pipe and hole = 45.77 0.0224 = 2043 ft
So the top of spacer is equal to top of stinger minus length of spacer between drill pipe and
hole.
Top of spacer = 8400 2043 = 6357 ft.
The volume of spacer inside string is equal to volume of spacer in cement stinger plus volume
of spacer in 4 DP.
Volume of spacer in cement stinger = cement stinger capacity x length from top of stinger to
top of cement
Volume of spacer in 4 DP = 4DP capacity x length from top of stinger to top of spacer
4 DP capacity = 3.352 1029.4 = 0.0109 bbl/ft
Volume of spacer in 4 DP = 0.0109 x (8400 6357) = 22.27 bbl
Total spacer volume in the string = 22.27 + 0.8178 = 23.1 (round up figure) bbl.
Final cement in place after pulling the cement stinger out of hole is below.
Ref books: