Académique Documents
Professionnel Documents
Culture Documents
Correct
Correct!
32.
You run the following command:<br/><br/> # ping host2<br
/><br/> After waiting a short time, you receive the response:<br/><br/> No answe
r from host2<br/><br/> Which option would cause this response from the ping comm
and?
Mark for Review
(1) Points
Your local network interface is configured as down.
The interface on host2 has been configured as down.
Your IP address is not in the /etc/hosts file on host2.
Correct
Correct!
33.
A particular host has become unreachable. The following
traceroute command is run to identify the path followed by a network packet to r
each the host.<br/><br/> # traceroute 172.17.22.93<br/><br/> The traceroute comm
and fails with the following output generated:<br/><br/> traceroute: Warning: Mu
ltiple interfaces found; using 172.17.22.93 @ hme0<br/> traceroute to 172.16.32.
100 (172.16.32.100), 30 hops max, 40 byte packets<br/> 1
172.17.22.1 (172
.17.22.1) 1.057 ms 0.875 ms 0.790 ms<br/> 2 172.17.22.1 (172.17.22.1) 0.808 ms !
H 0.810 ms !H 0.812 ms !H<br/><br/> In this instance, the traceroute command fai
led to find the route followed by a packet to reach this host on the network.<br
/><br/> Which two options would be the cause of the traceroute command to fail?
Mark for Review
(1) Points
(Choose all correct answers)
Unable to identify path followed by a packet to reach the host.
Host is unreachable.
Run during normal operations and a load was imposed on the network.
Network packet did not proceed beyond default gateway.
Timed out.
Correct
Correct!
34.
The customer s system is currently running at the multi-us
er-server milestone. They need to install operating system patches on the server
and it is required that all users be logged off from the system. Therefore, you
need to bring the system down to the single-user milestone. <br/><br/> Which tw
o options would you use to transition the system from the multi-user-server mile
stone to the single-user milestone?
Mark for Review
(1) Points
(Choose all correct answers)
svcadm milestone milestone/multi-user-server:default
svcs | grep milestone
boot -sw
svcadm milestone single-user
svcadm milestone milestone/single-user
Incorrect
tent and try again.
35.
In an attempt to connect to a server using telnet, you c
annot get a login prompt.<br/><br/> From the system console, you display the fol
lowing information about the telnet service:<br/><br/> fmri svc:/network/telnet:
default<br/> name Telnet server<br/> enabled false<br/> state disabled<br/> next
_state none<br/> state_time Mon Aug 13 00:24:45 2007<br/> restarter svc:/network
/inetd:default<br/> contract_id<br/><br/> Which option describes what you could
do to get the telnet service working again?
Mark for Review
(1) Points
inetadm -a telnet
inetadm enable svc:/network/telnet:default
inetadm -a svc:/network/inetd:default
Enable telnetd in the /etc/inetd.conf file.
Correct
Correct
Previous
Page 7 of 11
Next
Summary