Académique Documents
Professionnel Documents
Culture Documents
based operation
Graphic LC display
Built-in DSC / NBDP telex modem
Frequency range 0.1 to 30 MHz
continuous operation
Built-in DSC watchkeeping
receiver
The standard power supply voltage of
the MF/HF system is 24 VDC. A built-in
power supply for 115/230 VAC can be
supplied for the 250 W transceiver unit.
The 500 W system will be supplied
by external AC power units.
The system fully complies with IMO,
IEC and ETSI standards mentioned in
Commission Directive 2002/75/EC.
Technical data
Complies with relevant IMO performance standards, ITU Regulations, relevant
ITU-R recommendations and meets the performance specifications of ETSI
General
Frequency stability
Operating modes
Power supply
- Option
Power consumption
- RX only
- SSB unmodulated
- TX, SSB speech
- TX, SSB two-tone
- TX, FEC
- TX, DSC, ARQ Telex
Operating temperature range
Dimensions / weight
- Control unit
-
Handset
Loudspeaker
Transceiver unit 250 W
Transceiver unit 500 W
Antenna tuning unit 250 W
Antenna tuning unit 500 W
0.35 ppm
Simplex and semi-duplex, SSB and AM
telephony, NBDP telex and DSC.
24 VDC (-10 % to +30 %)
Power reduction below 26 VDC
110-120 / 220-240 VAC (10 %),
50/60Hz, AC Power Supply (internal
switch) integrated or external with
automatic change-over to reserve
battery during AC mains failure
250 W
500 W
60 W
75 W
125 W
125 W
220 W
360 W
925 W
360 W
510 W
700 W
-20 C to +55 C
(W x H x D)
231 x 120 x 93 mm / 1 kg
incl. mounting bracket and knobs
67x210x73 mm / 0.4 kg
100x100x73 mm / 0.6 kg
440x635x160 mm / 19 kg
495x678x356 mm / 59 kg
290x500x80 mm / 3.6 kg
401x603x170.5 mm / 17 kg
Receiver
Frequency range
Antenna impedance
Antenna input protection
IF selectivity
- SSB telephony
- AM telephony
- Telex
Sensitivity
- SSB telephony
- AM telephony
- Telex
Spurious emissions
Audio output power
Frequency range
Intermodulation
Hum and noise
Spurious emissions
Suppression of unwanted sideband
Ship`s identity
- DSC
- Telex
Interfaces
- Alarm
- NMEA
- COM
- Line, Key
- AUX alarm 2
2187.5 kHz
100 kHz to 30 MHz
50
0 dBV
< 1 nW
30 VRMS (EMV)
Antenna unit
Frequency range
Antenna requirements
Antenna tuning
Tuning speed
Power capability
- 250 W system
- 500 W system
Options
Telex Data Terminal DEBEG 3646
with LCD and message processor is
recommended for extended radiotelex
communications which enables
generation and editing of stored
telex messages,
automated radio telex facilities for