Académique Documents
Professionnel Documents
Culture Documents
MANUAL
Preface
Thank you for purchasing the tracker. This manual shows how to operate the device
smoothly and correctly. Make sure to read this manual carefully before using this
product. Please note that specification and information are subject to changes without
prior notice in this manual. Any change will be integrated in the latest release. The
manufacturer assumes no responsibility for any errors or omissions in this document.
1.Summary
Working Based on existing GSM/GPRS network and GPS satellites, this product can
locate and monitor any remote targets by SMS or internet.
2.Introduction
1
S/N
A
B
C
D/J
E
F
G
H
I
Button Key
Speaker
Call 1
Call 2
SOS button
ON/OFF
MIC
SIM slot
USB
Lanyard Loop
Function
For voice and ringtone output
Predetermined number 1
Predetermined number 2
Emergency aid
Turn on/turn off/answer/hang-up
For voice transmission during a call
SIM Card Holder
For power charger
Hung on the neck
3.LED Indication
2
Meaning
GPS signal has been acquired successfully
GPS signal was searching
GPS stops working/ the gps was sleeping
Specification
Charging Voltage
Internal Battery
Dimension
85mm*50mm*15mm
Weight
Operating temperature
-20to 55C
Humidity
5% to 95% Non-condensing
GSM module
GPS Chipset
G-TOP
GPS Sensitivity
-158Db
GPS Frequency
C/A Code
Channels
Position Accuracy
10 meters, 2D RMS
Velocity Accuracy
0.1 m/s
Time Accuracy
Default datum
WGS-84
Reacquisition
Hot start
1 sec., average
Warm start
38 sec., average
Cold start
42 sec., average
Altitude Limit
Velocity Limit
Acceleration Limit
Less than 4g
Jerk Limit
20 m/sec
Work time
7.Operating Instructions
default password is 0000.
7.1 Set up administrator
the command SMS: #710#administrator1#administrator2#administrator3#password##
When you sending successfully, it will reply 770CONFIG OK when the pass word
is wrong; it will reply 770PASSWORD ER
7.4 Read the parameter
The command SMS: #901#userpassword#
When you sending successfully you will get the sms include the admin number
password and the IMEI.
7.5 The interval of gps data
The command SMS: # 730# time # data groups # User password ##
The command SMS: # 751 # fence radius # sampling interval # longitude # latitude #
user password ##
after the command is set successfully, the terminal will read the data of the module
fence working status and return message to the sending mobile phone, or PASSWORD
ER if the password is wrong.
For example: #752#0000##
Return: #open:1#lat:11456.209400#lng:2233.470100#distance:500#time:5#status:2
Where, open: 1 indicates fence open; Open: 0 indicates fence closed;
lat:11456.209400, latitude;
lng: 2233.470100; longitude;
distance: 500; fence radius;
time: 5 sampling interval;
status: 2 , terminal has obtained valid satellite data, fence works normally;
status: 1; fence open, but there are no valid satellite data have been received;
status: 0, no electronic fence is set.
7.9 close the Geo-fence
The command SMS: #760 # user password ##
Example: #760#0000##
When you sending successfully, it will reply 760CONFIG OK all the Geo-fence
will be cancelled. when the pass word is wrong; it will reply PASSWORD ER
7.10 Monitoring Function
When you sending successfully, will get the reply: Reset ok. All the setting will be
Restore factory settings
7.12 SOS alarm
When the SOS button is pressed for 3 seconds or more than 3 seconds, the terminal
will dial the administrator number .
7.13 low battery alarm
the
administrator number