Académique Documents
Professionnel Documents
Culture Documents
66
UFS
OKA
Open trunking system, flushfloor
Planner section
Selection aid, installation trunking with mesh 72
Selection aid, installation trunking
with floor trough
74
System overview
78
Products
Installation trunking with mesh
80
88
93
UFS
67
OKA-G
OKA-W
OKA-G
OKA-W
68
UFS
Two variants
OKA-W = system with floor trough
OKA-G = system with mesh side wall
The same basic structure allows
the combination of the benefits
of both variants.
OKA-W
System with floor trough
OKA-G
System with mesh side wall
OKA-W
Closed system
Clean installation, protection
against dirt and protected
against dust
No mechanical load on the
installed cables
OKA-G
OKA-G
OKA-W
OKA-W
OKA-G
Adaptable and particularly
flexible when combined
High flexibility when laid
in combination with other
systems (e.g. with pipes
crossing)
Particularly simple insertion
of pipes or screed-covered
trunking
UFS
69
OKA-G
OKA-W
OKA-G
OKA-W
70
UFS
OKA-G
OKA-W
OKA-G
OKA-W
System-specific benefits
OKA-G
OKA-W
OKA-W
Equipotential bonding
forwarding
Levelling units connect the
side profiles to forward of the
protective measure
OKA-W
UFS
71
Selection aid
Installation trunking OKA-G
The tables on these pages provide
information on the usable crosssection. The height adjustment increases the trunking volume. You
will find three values in the tables:
40 mm (lowest adjustment level),
140 mm (top adjustment level, trunking height 1) and 240 mm (top adjustment level, trunking height 2). If
service outlets are used, then the
usable cross-section is reduced according to the table on this page.
Stock length 2,400 mm
Screed anchor
Levelling unit
Trunking widths
The trunking units are available in
widths of 200, 300, 400, 500 and 600
mm.
Trunking heights
Two heights are available, which
cover the ranges 40140 or 40
240mm.
Stock lengths and lids
The trunking is available in lengths of
2,400 mm. The trunking sections are
covered with 4 mm sheet steel blind
or blanking lids. The joints possess a
joint seal or a joint support to which
a levelling unit should always be
added. Special end pieces are available as end components.
72
UFS
Usable cross2
section in mm
Trunking width
in mm
Trunking height
in mm
200
40
2,692
200
140
15,300
200
240
27,932
300
40
5,052
300
140
27,672
300
240
50,292
400
40
6,856
400
140
37,868
400
240
69,783
500
40
9,218
500
140
50,228
500
240
92,143
600
40
11,578
600
140
62,588
600
240
114,503
300
400
500
600
Trunking width in mm
40
140
240
40
140
240
40
140
240
40
140
240
40
140
240
Cable diameter in mm
54
306
559
101
553
1,006
137
757
1,396
184
37
213
388
70
384
699
95
526
969
128
698
27
156
285
52
282
513
70
386
712
94
21
120
218
39
216
393
54
296
545
17
94
172
31
171
310
42
234
10
13
77
140
25
138
251
34
11
11
63
115
21
114
208
12
53
97
18
96
13
45
83
15
14
39
71
15
34
16
13
18
1,005 1,843
232
1,252
2,290
1,280
161
869
1,590
513
940
118
639
1,168
72
392
720
90
489
895
431
57
310
569
71
386
707
189
349
46
251
461
58
313
573
28
156
288
38
208
381
48
259
473
175
24
131
242
32
174
320
40
217
398
82
149
20
112
206
27
149
273
34
185
339
13
71
128
17
97
178
24
128
235
30
160
292
62
11
61
112
15
84
155
20
112
205
26
139
254
30
55
10
54
98
13
74
136
18
98
180
23
122
224
26
48
48
87
12
66
121
16
87
159
20
108
198
24
43
43
78
11
58
108
14
78
142
18
97
177
GES4
12,513
11,320
GES6
12,459
15,348
GES9
15,769
15,034
GESR9
17,590
18,038
GESR9/10
23,935
24,960
GRAF9
26,688
22,638
UFS
73
Selection aid
OKA-W installation trunking
NEW
New duct, then
with compartments
Levelling unit
Useful cross-section
Trunking height
in mm
Trunking widths
The trunking units are available in
widths of 200, 300, 400, 500 and
600mm.
Trunking heights
Regarding the trunking height, versions are available in 40 (+30), 60
(+ 50) and 100 (+50) mm. The trunking is available in lengths of 2,400
mm.
Stock lengths and lids
The trunking sections are covered
with 4 mm sheet steel blind or blanking lids. The joints possess a joint
support or a height-adjustable joint
support. There are special trunking
end caps as end components.
74
UFS
Total
in mm2
200
40
2,692
2,692
200
60
5,216
5,216
200
100
10,264
10,264
300
40
1,454
1,169
1,382
4,005
300
60
2,894
2,459
2,822
8,175
300
100
5,774
4,424
5,702
15,900
400
40
2,213
1,928
2,141
6,282
400
60
4,313
3,878
4,241
12,432
400
100
8,513
7,183
8,441
24,137
500
40
2,972
2,687
2,900
8,559
500
60
5,732
5,297
5,660
16,689
500
100
11,252
9,902
11,180
32,334
600
40
3,754
3,469
3,682
10,905
600
60
7,194
6,759
7,122
21,075
600
100
14,074
12,724
14,002
40,800
Reserve
300
400
500
600
Trunking width in mm
40
60
100
40
60
100
40
60
100
40
60
100
40
60
100
Cable diameter in mm
5,216
10,264 4,005
8,175
15,900
54
104
205
37
72
27
40,800
80
164
318
126
249
483
171
334
647
218
422
816
143
56
114
221
87
173
335
119
232
449
151
293
567
53
105
41
83
162
64
127
246
87
170
330
111
215
416
21
41
80
31
64
124
49
97
189
67
130
253
85
165
319
17
32
63
25
50
98
39
77
149
53
103
200
67
130
252
10
13
26
51
20
41
80
31
62
121
43
83
162
55
105
204
11
11
22
42
17
34
66
26
51
100
35
69
134
45
87
169
12
18
36
14
28
55
22
43
84
30
58
112
38
73
142
13
15
30
12
24
47
19
37
71
25
49
96
32
62
121
14
13
26
10
21
41
16
32
62
22
43
82
28
54
104
15
12
23
18
35
14
28
54
19
37
72
24
47
91
16
10
20
16
31
12
24
47
17
33
63
21
41
80
17
18
14
28
11
22
42
15
29
56
19
36
71
18
16
13
25
10
19
37
13
26
50
17
33
63
UFS
75
Trunking units
200
300
400
OKA-G
OKA-W
500
600
Trunking units
200
300
400
OKA-G DAT
76
UFS
500
OKA-W DAT
600
Trunking units
Extension units
300
400
500
OKA-G 4
OKA-W 4
600
OKA-A-G 4
Width always 400 mm
Trunking units
Attached units
400
OKA-G 6
500
OKA-W 6
600
OKA-A-G 6
Width always 400 mm
Trunking units
Attached units
400
500
OKA-G 9
OKA-W 9
R9
600
OKA-A-G 9
Width always 400 mm
Trunking widths
in mm
Attached units
400
500
OKA-G R9
OKA-W R9
600
OKA-A-G R9
Width always 400 mm
UFS
77
System overview
OKA open trunking system, flushfloor
Extension units
Available with various
blanking lids for maintenance
of the full trunking volume
Page 86
78
UFS
Page 88
Page 83
UFS
79
81
System width
System height
Load capacity
Moisture protection
The open, screed-flush OKA-G and OKA-W trunking systems are used for cable routing and the installation of electrical
resources in the underfloor area. The entire length of the trunking systems can be opened, meaning that they are particularly
suited to frequent changes to the laid cables in dry and wet-cleaned floors.
The OKA-G possesses flexible, metal mesh side walls.
The OKA-W possesses a closed, sheet steel floor trough.
Resources are installed either directly in the trunking or in the side extension units. In the second option, the continuous
trunking is only used for cable routing, and its width can thus be adjusted to the amount of cables to be routed.
System components
Trunking units with blanking lids, extension units, floor covering contact profile, levelling units
80
UFS
There are standardised end pieces available for the OKAG and OKA-W trunking systems, which can be adjusted
to the appropriate trunking height and which are simple to
mount.
Create 90 angle
Before applying the screed, shorten any heightadjustment screws protruding over the top edge of the
trunking (at least 5 mm beneath screed height).
Create intersection
UFS
81
Extension unit
The OKAFD seal allows the use of the OKA-G and OKAW trunking systems in wet-cleaned floors. it is stuck into
the aluminium profile in the lengthwise position at the
position indicated.
OKA-W system with mesh
82
UFS
OKA-G20040140
OKA-G30040140
OKA-G40040140
OKA-G50040140
OKA-G60040140
Width Length
Duct
height
mm
mm
mm
200
300
400
500
600
2,400
2,400
2,400
2,400
2,400
40+100
40+100
40+100
40+100
40+100
Pack.
Weight
borders
2.4 832.500
2.4 1155.400
2.4 1472.900
2.4 1846.700
2.4 2179.600
Item No.
ST
Price
price/m
/ FS
7424 00 0
7424 00 2
7424 00 4
7424 00 6
7424 00 8
Ready-to-mount trunking unit for cable routing consisting of 3 blind lids, 2 side profiles with
attached flexible side wallmade ofmetalmesh, floor covering contact profiles 4mm. The scope of
delivery contains 6 height-adjustable fixing brackets, 6 screed anchors and 3 lid butt seals (for
nominal trunking widths 200, 300 and 400) or 6 lid butt supports (for nominal trunking widths 500
and 600). The essential levelling units (observe height adjustment) for the 500 and 600 lid support
are not contained in the scope of delivery and should be ordered separately. The trunking lids are
screwed up to and including the nominal width 400 on delivery.
Type
OKA-G20040240
OKA-G30040240
OKA-G40040240
OKA-G50040240
OKA-G60040240
Width Length
Duct
height
mm
mm
mm
200
300
400
500
600
2,400
2,400
2,400
2,400
2,400
40+200
40+200
40+200
40+200
40+200
Pack.
Weight
borders
2.4 852.100
2.4 1175.000
2.4 1492.500
2.4 1866.300
2.4 2199.200
Item No.
ST
Price
price/m
/ FS
7424 02 0
7424 02 2
7424 02 4
7424 02 6
7424 02 8
Ready-to-mount trunking unit for cable routing consisting of 3 blind lids, 2 side profiles with
attached flexible side wallmade ofmetalmesh, floor covering contact profiles 4mm. The scope of
delivery contains 6 height-adjustable fixing brackets, 6 screed anchors and 3 lid butt seals (for
nominal trunking widths 200, 300 and 400) or 6 lid butt supports (for nominal trunking widths 500
and 600). The essential levelling units (observe height adjustment) for the 500 and 600 lid support
are not contained in the scope of delivery and should be ordered separately. The trunking lids are
screwed up to and including the nominal width 400 on delivery.
OKA-G20040140R
OKA-G30040140R
OKA-G40040140R
OKA-G50040140R
OKA-G60040140R
Width Length
Duct
height
mm
mm
mm
200
300
400
500
600
2,400
2,400
2,400
2,400
2,400
40+100
40+100
40+100
40+100
40+100
Pack.
Weight
borders
2.4 836.250
2.4 1158.700
2.4 1484.200
2.4 1850.400
2.4 2183.300
Item No.
ST
Price
price/m
/ FS
7424 04 0
7424 04 2
7424 04 4
7424 04 6
7424 04 8
Ready-to-mount trunking unit for cable routing consisting of 3 self-locking blind lids, 2 side profiles
with attached flexible side wallmade ofmetalmesh, floor covering contact profiles 4mm. The
scope of delivery contains 6 height-adjustable fixing brackets, 6 screed anchors and 3 lid butt
seals (for nominal trunking widths 200, 300 and 400) or 6 lid butt supports (for nominal trunking
widths 500 and 600). The essential levelling units (observe height adjustment) for the 500 and 600
lid support are not contained in the scope of delivery and should be ordered separately. The
trunking lids are screwed up to and including the nominal width 400, pre-mounted with locking
springs.
Type
OKA-G20040240R
OKA-G30040240R
OKA-G40040240R
OKA-G50040240R
OKA-G60040240R
Width Length
Duct
height
mm
mm
mm
200
300
400
500
600
2,400
2,400
2,400
2,400
2,400
40+200
40+200
40+200
40+200
40+200
Pack.
Weight
borders
2.4 855.800
2.4 1178.300
2.4 1503.800
2.4 1870.000
2.4 2202.900
Item No.
ST
Price
price/m
/ FS
7424 06 0
7424 06 2
7424 06 4
7424 06 6
7424 06 8
Ready-to-mount trunking unit for cable routing consisting of 3 self-locking blind lids, 2 side profiles
with attached flexible side wallmade ofmetalmesh, floor covering contact profiles 4mm. The
scope of delivery contains 6 height-adjustable fixing brackets, 6 screed anchors and 3 lid butt
seals (for nominal trunking widths 200, 300 and 400) or 6 lid butt supports (for nominal trunking
widths 500 and 600). The essential levelling units (observe height adjustment) for the 500 and 600
lid support are not contained in the scope of delivery and should be ordered separately. The
trunking lids are screwed up to and including the nominal width 400, pre-mounted with locking
springs.
UFS
83
Width Length
OKA-G20040140DAT
OKA-G30040140DAT
OKA-G40040140DAT
OKA-G50040140DAT
OKA-G60040140DAT
Duct
height
mm
mm
mm
200
300
400
500
600
2,400
2,400
2,400
2,400
2,400
40+100
40+100
40+100
40+100
40+100
Pack.
Weight
borders
2.4 826.300
2.4 1148.800
2.4 1583.300
2.4 1732.100
2.4 2032.100
Item No.
ST
Price
price/m
/ FS
7424 08 0
7424 08 2
7424 08 4
7424 08 6
7424 08 8
Ready-to-mount trunking unit for cable routing with 3 or 6 device connection lids for the setup of
Telitanks, consisting of 2 side profiles with attached flexible side wallmade ofmetalmesh, floor
covering contact profiles 4mm and trunking lid with DAT system opening. The scope of delivery
contains 6 height-adjustable fixing brackets, 6 screed anchors and 3 lid butt seals (for nominal
trunking widths 200 and 300) or 3 lid butt supports for nominal trunking width 400 and 6 lid butt
supports for nominal trunking widths 500 and 600. The essential levelling units (please observe
height adjustment) for the 400, 500 and 600 lid support are not contained in the scope of delivery
and should be ordered separately. The trunking lids are screwed up to and including the nominal
width 400. .
Type
Width Length
OKA-G20040240DAT
OKA-G30040240DAT
OKA-G40040240DAT
OKA-G50040240DAT
OKA-G60040240DAT
Duct
height
mm
mm
mm
200
300
400
500
600
2,400
2,400
2,400
2,400
2,400
40+200
40+200
40+200
40+200
40+200
Pack.
Weight
borders
2.4 845.800
2.4 1168.300
2.4 1493.800
2.4 1751.700
2.4 2051.700
Item No.
ST
Price
price/m
/ FS
7424 10 0
7424 10 2
7424 10 4
7424 10 6
7424 10 8
Ready-to-mount trunking unit for cable routing with 3 or 6 device connection lids for the setup of
Telitanks, consisting of 2 side profiles with attached flexible side wallmade ofmetalmesh, floor
covering contact profiles 4mm and trunking lid with DAT system opening. The scope of delivery
contains 6 height-adjustable fixing brackets, 6 screed anchors and 3 lid butt seals (for nominal
trunking widths 200 and 300) or 3 lid butt supports for nominal trunking width 400 and 6 lid butt
supports for nominal trunking widths 500 and 600. The essential levelling units (please observe
height adjustment) for the 400, 500 and 600 lid support are not contained in the scope of delivery
and should be ordered separately. The trunking lids are screwed up to and including the nominal
width 400. .
OKA-G30040140D4
OKA-G40040140D4
OKA-G50040140D4
OKA-G60040140D4
Width Length
Duct
height
mm
mm
mm
300
400
500
600
2,400
2,400
2,400
2,400
40+100
40+100
40+100
40+100
Pack.
Weight
borders
2.4 1127.920
2.4 1453.300
2.4 1689.600
2.4 2002.100
Item No.
ST
Price
price/m
/ FS
7424 12 0
7424 12 2
7424 12 4
7424 12 6
Ready-to-mount trunking unit for cable routing with 3 or 6 device installation lids for the installation
of a flush-mount unit of nominal size 4, consisting of 2 side profiles with attached flexible side
wallmade ofmetalmesh, floor covering contact profiles 4mm. The scope of delivery contains 6
height-adjustable fixing brackets, 6 screed anchors and 3 lid butt seals (for nominal trunking
widths 200 and 300) or 3 lid butt supports for nominal trunking width 400 and 6 lid butt supports for
nominal trunking widths 500 and 600. The essential levelling units (please observe height
adjustment) for the 400, 500 and 600 lid support are not contained in the scope of delivery and
should be ordered separately. The trunking lids are screwed up to and including the nominal width
400.
OKA-G30040240D4
OKA-G40040240D4
OKA-G50040240D4
OKA-G60040240D4
Width Length
Duct
height
mm
mm
mm
300
400
500
600
2,400
2,400
2,400
2,400
40+200
40+200
40+200
40+200
Pack.
Weight
borders
2.4 1147.500
2.4 1472.900
2.4 1709.200
2.4 2021.700
Item No.
ST
Price
price/m
/ FS
7424 14 0
7424 14 2
7424 14 4
7424 14 6
Ready-to-mount trunking unit for cable routing with 3 or 6 device installation lids for the installation
of a flush-mount unit of nominal size 4, consisting of 2 side profiles with attached flexible side
wallmade ofmetalmesh, floor covering contact profiles 4mm. The scope of delivery contains 6
height-adjustable fixing brackets, 6 screed anchors and 3 lid butt seals (for nominal trunking
widths 200 and 300) or 3 lid butt supports for nominal trunking width 400 and 6 lid butt supports for
nominal trunking widths 500 and 600. The essential levelling units (please observe height
adjustment) for the 400, 500 and 600 lid support are not contained in the scope of delivery and
should be ordered separately. The trunking lids are screwed up to and including the nominal width
400.
84
UFS
Type
Width Length
mm
mm
Duct
height
mm
Pack.
Weight
Item No.
borders
ST
Price
price/m
/ FS
Ready-to-mount trunking unit for cable routing with 3 or 6 device installation lids for the installation
of a flush-mount unit of nominal size 6, consisting of 2 side profiles with attached flexible side
wallmade ofmetalmesh, floor covering contact profiles 4mm. The scope of delivery contains 6
height-adjustable fixing brackets, 6 screed anchors and 3 lid butt supports for nominal trunking
width 400 and 6 lid butt supports for nominal trunking widths 500 and 600. The essential levelling
units (please observe height adjustment) for the 400, 500 and 600 lid support are not contained in
the scope of delivery and should be ordered separately. The trunking lids are screwed up to and
including the nominal width 400.
Type
Width Length
mm
mm
Duct
height
mm
Pack.
Weight
Item No.
borders
ST
Price
price/m
/ FS
Ready-to-mount trunking unit with three or six device installation lids for cable laying and the
installation of installation units of nominal size 6, consisting of 2 side profiles with attached
flexiblemetalmesh side wall, floor coveringguide profiles and trunking lid with blankmounting
opening. The scope of supply contains six height-adjustable wall fixing brackets, six screed
anchors and three height-adjustable cover joint supports for nominal trunking width 400 and six
cover joint supports for nominal trunking widths 500 and 600. Trunking lid screwed down when
delivered.
Width Length
mm
mm
Duct
height
mm
Pack.
Weight
Item No.
borders
ST
Price
price/m
/ FS
Ready-to-mount trunking unit for cable routing with 3 or 6 device installation lids for the installation
of a flush-mount unit of nominal size 9, consisting of 2 side profiles with attached flexible side
wallmade ofmetalmesh, floor covering contact profiles 4mm. The scope of delivery contains 6
height-adjustable fixing brackets, 6 screed anchors and 3 lid butt supports for nominal trunking
width 400 and 6 lid butt supports for nominal trunking widths 500 and 600. The essential levelling
units (please observe height adjustment) for the 400, 500 and 600 lid support are not contained in
the scope of delivery and should be ordered separately. The trunking lids are screwed up to and
including the nominal width 400.
Type
Width Length
mm
mm
Duct
height
mm
Pack.
Weight
Item No.
borders
ST
Price
price/m
/ FS
Ready-to-mount trunking unit for cable routing with 3 or 6 device installation lids for the installation
of a flush-mount unit of nominal size 9, consisting of 2 side profiles with attached flexible side
wallmade ofmetalmesh, floor covering contact profiles 4mm. The scope of delivery contains 6
height-adjustable fixing brackets, 6 screed anchors and 3 lid butt supports for nominal trunking
width 400 and 6 lid butt supports for nominal trunking widths 500 and 600. The essential levelling
units (please observe height adjustment) for the 400, 500 and 600 lid support are not contained in
the scope of delivery and should be ordered separately. The trunking lids are screwed up to and
including the nominal width 400.
Width Length
mm
mm
Duct
height
mm
Pack.
Weight
Item No.
borders
ST
Price
price/m
/ FS
Ready-to-mount trunking unit for cable routing with 3 or 6 device installation lids for the installation
of a flush-mount unit of nominal size R9, consisting of 2 side profiles with attached flexible side
wallmade ofmetalmesh, floor covering contact profiles 4mm. The scope of delivery contains 6
height-adjustable fixing brackets, 6 screed anchors and 3 lid butt supports for nominal trunking
width 400 and 6 lid butt supports for nominal trunking widths 500 and 600. The essential levelling
units (please observe height adjustment) for the 400, 500 and 600 lid support are not contained in
the scope of delivery and should be ordered separately. The trunking lids are screwed up to and
including the nominal width 400.
UFS
85
Width Length
mm
mm
Duct
height
mm
Pack.
Weight
Item No.
borders
ST
Price
price/m
/ FS
Ready-to-mount trunking unit for cable routing with 3 or 6 device installation lids for the installation
of a flush-mount unit of nominal size R9, consisting of 2 side profiles with attached flexible side
wallmade ofmetalmesh, floor covering contact profiles 4mm. The scope of delivery contains 6
height-adjustable fixing brackets, 6 screed anchors and 3 lid butt supports for nominal trunking
width 400 and 6 lid butt supports for nominal trunking widths 500 and 600. The essential levelling
units (please observe height adjustment) for the 400, 500 and 600 lid support are not contained in
the scope of delivery and should be ordered separately. The trunking lids are screwed up to and
including the nominal width 400.
Dimension Dimension
A
a
mm
OKA-GA40140/4
OKA-GA40240/4
mm
400 201
400 201
Duct
height
Pack.
Weight
Item No.
mm
pcs
kg/% pc
ST
Price
price/pc.
/ FS
1 692.000 7424 32 0
1 700.000 7424 34 0
40+100
40+200
Ready-to-mount trunking extension unit with a device installation lid for the installation of an
installation unit of nominal size 4, consisting of side profiles with attached flexiblemetalmesh side
wall, floor coveringguide profiles, trunking lid with blankmounting opening and a flushfloor end
cap. The scope of delivery contains 3 height-adjustable fixing brackets, 3 screed anchors and
trunking connection brackets.
mm
OKA-GA40140/6
OKA-GA40240/6
mm
400 201
400 201
mm
Duct
height
Pack.
Weight
Item No.
mm
pcs
kg/% pc
ST
253 40+100
253 40+200
Price
price/pc.
/ FS
1 683.000 7424 32 2
1 692.000 7424 34 2
Ready-to-mount trunking extension unit with a device installation lid for the installation of an
installation unit of nominal size 6, consisting of side profiles with attached flexiblemetalmesh side
wall, floor coveringguide profiles, trunking lid with blankmounting opening and a flushfloor end
cap. The scope of delivery contains 3 height-adjustable fixing brackets, 3 screed anchors and
trunking connection brackets.
Dimension Dimension
A
a
mm
OKA-GA40140/9
OKA-GA40240/9
mm
400 244
400 244
Duct
height
Pack.
Weight
Item No.
mm
pcs
kg/% pc
ST
40+100
40+200
Price
price/pc.
/ FS
1 680.000 7424 32 4
1 689.000 7424 34 4
Dimension Dimension
A
d
mm
OKA-GA40140R9
OKA-GA40240R9
400
400
mm
Duct
height
Pack.
Weight
Item No.
mm
pcs
kg/% pc
ST
305 40+100
305 40+200
Price
price/pc.
/ FS
1 666.000 7424 32 6
1 675.000 7424 34 6
Ready-to-mount trunking extension unit with a device installation lid for the installation of a round
installation unit of nominal size R9, consisting of side profiles with attached flexiblemetalmesh
side wall, floor coveringguide profiles, trunking lid with blankmounting opening and a flushfloor
end cap. The scope of delivery contains 3 height-adjustable fixing brackets, 3 screed anchors and
trunking connection brackets.
86
UFS
Ready-to-mount trunking extension unit with a device installation lid for the installation of an
installation unit of nominal size 9, consisting of side profiles with attached flexiblemetalmesh side
wall, floor coveringguide profiles, trunking lid with blankmounting opening and a flushfloor end
cap. The scope of delivery contains 3 height-adjustable fixing brackets, 3 screed anchors and
trunking connection brackets.
Dimension
A
Pack.
Weight
Item No.
mm
pcs
kg/% pc
ST
DSD2/200
DSD2/300
Price
price/pc.
/ FS
1 10.250 7424 99 0
1 18.450 7424 99 2
200
300
For underlaying and sealing joints of nominal trunking widths of 200 or 300mm.
Dimension
A
Pack.
Weight
Item No.
mm
pcs
kg/% pc
ST
DSU2/400
DSU2/500
DSU2/600
Price
price/pc.
/ FS
1 28.650 7424 36 0
1 35.850 7424 36 2
1 44.050 7424 36 4
400
500
600
For underlaying and sealing joints of nominal trunking widths of 400. With installation option for
central, height-adjustable support.
Duct
height
Pack.
Weight
Item No.
mm
pcs
kg/% pc
ST
NEDSU2/4030
40+30
Price
price/pc.
/ FS
3 3.240 7424 84 0
For central support of a lid butt support of nominal widths 400, 500 or 600.
Type
Duct
height
Pack.
Weight
Item No.
mm
pcs
kg/% pc
ST
NEDSU2/6050
60+50
Price
price/pc.
/ FS
3 4.840 7424 84 2
For central support of a lid butt support of nominal widths 400, 500 or 600.
Type
Duct
height
Pack.
Weight
Item No.
mm
pcs
kg/% pc
ST
NEDSU2/10075 100+75
Price
price/pc.
/ FS
3 5.390 7424 84 4
For central support of a lid butt support of nominal widths 400, 500 or 600.
Type
Duct
height
Pack.
Weight
Item No.
mm
pcs
kg/% pc
ST
NEDSU2/17075 170+75
Price
price/pc.
/ FS
3 7.450 7424 84 6
For central support of a lid butt support of nominal widths 400, 500 or 600.
UFS
87
OKA-W2004030
OKA-W3004030
OKA-W4004030
OKA-W5004030
OKA-W6004030
Width Length
Duct
height
mm
mm
mm
200
300
400
500
600
2,400
2,400
2,400
2,400
2,400
40+30
40+30
40+30
40+30
40+30
Pack.
Weight
borders
2.4 966.700
2.4 1366.700
2.4 1775.000
2.4 2225.000
2.4 2637.500
Item No.
ST
Price
price/m
/ FS
7424 40 0
7424 40 2
7424 40 4
7424 40 6
7424 40 8
Ready-to-mount trunking unit with three blanking lids for cable laying, consisting of the trunking
base (floor base with side and floor coveringguide profiles) and trunking lid. Floor base with
holding shackles for self-contactingmounting of dividers. The scope of supply contains six heightadjustable fixing brackets, six screed anchors and three cover joint supports (for nominal trunking
widths 200 and 300) or three height-adjustable cover joint supports (for nominal trunking widths
400, 500 and 600). Trunking lid screwed down when delivered.
Type
OKA-W2006050
OKA-W3006050
OKA-W4006050
OKA-W5006050
OKA-W6006050
Width Length
Duct
height
mm
mm
mm
200
300
400
500
600
2,400
2,400
2,400
2,400
2,400
60+50
60+50
60+50
60+50
60+50
Pack.
Weight
borders
2.4 1004.200
2.4 1404.200
2.4 1812.500
2.4 2262.500
2.4 2675.000
Item No.
ST
Price
price/m
/ FS
7424 42 0
7424 42 2
7424 42 4
7424 42 6
7424 42 8
Ready-to-mount trunking unit with three blanking lids for cable laying, consisting of the trunking
base (floor base with side and floor coveringguide profiles) and trunking lid. Floor base with
holding shackles for self-contactingmounting of dividers. The scope of supply contains six heightadjustable fixing brackets, six screed anchors and three cover joint supports (for nominal trunking
widths 200 and 300) or three height-adjustable cover joint supports (for nominal trunking widths
400, 500 and 600). Trunking lid screwed down when delivered.
OKA-W20010050
OKA-W30010050
OKA-W40010050
OKA-W50010050
OKA-W60010050
Duct
height
mm
mm
mm
200
300
400
500
600
2,400
2,400
2,400
2,400
2,400
100+50
100+50
100+50
100+50
100+50
Pack.
Weight
borders
2.4 1070.800
2.4 1470.800
2.4 1879.200
2.4 2329.200
2.4 2741.700
Item No.
ST
Price
price/m
/ FS
7424 44 0
7424 44 2
7424 44 4
7424 44 6
7424 45 8
150
Width Length
100
Type
Ready-to-mount trunking unit with three blanking lids for cable laying, consisting of the trunking
base (floor base with side and floor coveringguide profiles) and trunking lid. Floor base with
holding shackles for self-contactingmounting of dividers. The scope of supply contains six heightadjustable fixing brackets, six screed anchors and three cover joint supports (for nominal trunking
widths 200 and 300) or three height-adjustable cover joint supports (for nominal trunking widths
400, 500 and 600). Trunking lid screwed down when delivered.
OKA-W2004030R
OKA-W3004030R
OKA-W4004030R
OKA-W5004030R
OKA-W6004030R
Width Length
Duct
height
mm
mm
mm
200
300
400
500
600
2,400
2,400
2,400
2,400
2,400
40+30
40+30
40+30
40+30
40+30
Pack.
Weight
borders
2.4 970.800
2.4 1370.800
2.4 1779.200
2.4 2229.200
2.4 2641.600
Item No.
ST
Price
price/m
/ FS
7424 46 0
7424 46 2
7424 46 4
7424 46 6
7424 46 8
Ready-to-mount trunking unit with three self-locking blanking lids for cable laying, consisting of the
trunking base (floor base with side and floor coveringguide profiles) and trunking lid. Floor base
with holding shackles for self-contactingmounting of dividers. The scope of supply contains six
height-adjustable fixing brackets, six screed anchors and three cover joint supports (for nominal
trunking widths 200 and 300) or three height-adjustable cover joint supports (for nominal trunking
widths 400, 500 and 600). Trunking lid screwed down when delivered.
Type
OKA-W2006050R
OKA-W3006050R
OKA-W4006050R
OKA-W5006050R
OKA-W6006050R
Width Length
Duct
height
mm
mm
mm
200
300
400
500
600
2,400
2,400
2,400
2,400
2,400
60+50
60+50
60+50
60+50
60+50
Pack.
Weight
borders
2.4 1008.300
2.4 1408.300
2.4 1816.700
2.4 2266.700
2.4 2679.200
Item No.
ST
Price
price/m
/ FS
7424 48 0
7424 48 2
7424 48 4
7424 48 6
7424 48 8
Ready-to-mount trunking unit with three self-locking blanking lids for cable laying, consisting of the
trunking base (floor base with side and floor coveringguide profiles) and trunking lid. Floor base
with holding shackles for self-contactingmounting of dividers. The scope of supply contains six
height-adjustable fixing brackets, six screed anchors and three cover joint supports (for nominal
trunking widths 200 and 300) or three height-adjustable cover joint supports (for nominal trunking
widths 400, 500 and 600). Trunking lid screwed down when delivered.
88
UFS
Type
100
150
OKA-W20010050R
OKA-W30010050R
OKA-W40010050R
OKA-W50010050R
OKA-W60010050R
Width Length
Duct
height
mm
mm
mm
200
300
400
500
600
2,400
2,400
2,400
2,400
2,400
100+50
100+50
100+50
100+50
100+50
Pack.
Weight
borders
2.4 1075.000
2.4 1475.000
2.4 1883.300
2.4 2333.300
2.4 2745.800
Item No.
ST
Price
price/m
/ FS
7424 50 0
7424 50 2
7424 50 4
7424 50 6
7424 50 8
Ready-to-mount trunking unit with three self-locking blanking lids for cable laying, consisting of the
trunking base (floor base with side and floor coveringguide profiles) and trunking lid. Floor base
with holding shackles for self-contactingmounting of dividers. The scope of supply contains six
height-adjustable fixing brackets, six screed anchors and three cover joint supports (for nominal
trunking widths 200 and 300) or three height-adjustable cover joint supports (for nominal trunking
widths 400, 500 and 600). Trunking lid screwed down when delivered.
Width Length
OKA-W2004030DAT
OKA-W3004030DAT
OKA-W4004030DAT
OKA-W5004030DAT
OKA-W6004030DAT
Duct
height
mm
mm
mm
200
300
400
500
600
2,400
2,400
2,400
2,400
2,400
40+30
40+30
40+30
40+30
40+30
Pack.
Weight
borders
2.4 960.400
2.4 1358.300
2.4 1766.700
2.4 2195.800
2.4 2584.700
Item No.
ST
Price
price/m
/ FS
7424 52 0
7424 52 2
7424 52 4
7424 52 6
7424 52 8
Ready-to-mount trunking unit with three or six device connection lids for cable laying and the
setup of Telitanks, consisting of the trunking base (floor base with side and floor coveringguide
profiles) and trunking lid with DAT system opening. Floor base with holding shackles for selfcontactingmounting of dividers. The scope of supply contains six height-adjustable fixing
brackets, six screed anchors and three cover joint supports (for nominal trunking widths 200 and
300) or three height-adjustable cover joint supports (for nominal trunking widths 400, 500 and
600). Trunking lid screwed down when delivered.
Type
Width Length
OKA-W2006050DAT
OKA-W3006050DAT
OKA-W4006050DAT
OKA-W5006050DAT
OKA-W6006050DAT
Duct
height
mm
mm
mm
200
300
400
500
600
2,400
2,400
2,400
2,400
2,400
60+50
60+50
60+50
60+50
60+50
Pack.
Weight
borders
2.4 997.900
2.4 1395.800
2.4 1804.200
2.4 2238.800
2.4 2637.500
Item No.
ST
Price
price/m
/ FS
7424 54 0
7424 54 2
7424 54 4
7424 54 6
7424 54 8
Ready-to-mount trunking unit with three or six device connection lids for cable laying and the
setup of Telitanks, consisting of the trunking base (floor base with side and floor coveringguide
profiles) and trunking lid with DAT system opening. Floor base with holding shackles for selfcontactingmounting of dividers. The scope of supply contains six height-adjustable fixing
brackets, six screed anchors and three cover joint supports (for nominal trunking widths 200 and
300) or three height-adjustable cover joint supports (for nominal trunking widths 400, 500 and
600). Trunking lid screwed down when delivered.
Type
150
100
Width Length
OKA-W20010050DAT
OKA-W30010050DAT
OKA-W40010050DAT
OKA-W50010050DAT
OKA-W60010050DAT
Duct
height
mm
mm
mm
200
300
400
500
600
2,400
2,400
2,400
2,400
2,400
100+50
100+50
100+50
100+50
100+50
Pack.
Weight
borders
2.4 1064.600
2.4 1462.500
2.4 1870.800
2.4 2304.600
2.4 2702.900
Item No.
ST
Price
price/m
/ FS
7424 56 0
7424 56 2
7424 56 4
7424 56 6
7424 56 8
Ready-to-mount trunking unit with three or six device connection lids for cable laying and the
setup of Telitanks, consisting of the trunking base (floor base with side and floor coveringguide
profiles) and trunking lid with DAT system opening. Floor base with holding shackles for selfcontactingmounting of dividers. The scope of supply contains six height-adjustable fixing
brackets, six screed anchors and three cover joint supports (for nominal trunking widths 200 and
300) or three height-adjustable cover joint supports (for nominal trunking widths 400, 500 and
600). Trunking lid screwed down when delivered.
OKA-W3006050D4
OKA-W4006050D4
OKA-W5006050D4
OKA-W6006050D4
Width Length
Duct
height
mm
mm
mm
300
400
500
600
2,400
2,400
2,400
2,400
60+50
60+50
60+50
60+50
Pack.
Weight
borders
2.4 1377.100
2.4 1785.400
2.4 2196.300
2.4 2607.500
Item No.
ST
Price
price/m
/ FS
7424 60 0
7424 60 2
7424 60 4
7424 60 6
Ready-to-mount trunking unit with three or six device installation lids for cable laying and the
installation of installation units of nominal size 4, consisting of the trunking base (floor base with
side and floor coveringguide profiles) and trunking lid with blankmounting opening. Floor base
with holding shackles for self-contactingmounting of dividers. The scope of supply contains six
height-adjustable fixing brackets, six screed anchors and three cover joint supports (for nominal
trunking widths 200 and 300) or three height-adjustable cover joint supports for nominal trunking
width 400 and six height-adjustable cover joint supports for nominal trunking widths 500 and 600.
Trunking lid screwed down when delivered.
UFS
89
OKA-W30010050D4
OKA-W40010050D4
OKA-W50010050D4
OKA-W60010050D4
Duct
height
mm
mm
mm
300
400
500
600
2,400
2,400
2,400
2,400
100+50
100+50
100+50
100+50
Pack.
Weight
borders
2.4 1439.600
2.4 1847.900
2.4 2262.100
2.4 2672.900
Price
price/m
Item No.
ST
/ FS
150
Width Length
100
Type
7424 62 0
7424 62 2
7424 62 4
7424 62 6
Ready-to-mount trunking unit with three or six device installation lids for cable laying and the
installation of installation units of nominal size 4, consisting of the trunking base (floor base with
side and floor coveringguide profiles) and trunking lid with blankmounting opening. Floor base
with holding shackles for self-contactingmounting of dividers. The scope of supply contains six
height-adjustable fixing brackets, six screed anchors and three cover joint supports (for nominal
trunking widths 200 and 300) or three height-adjustable cover joint supports for nominal trunking
width 400 and six height-adjustable cover joint supports for nominal trunking widths 500 and 600.
Trunking lid screwed down when delivered.
Width Length
mm
OKA-W4006050D6
OKA-W5006050D6
OKA-W6006050D6
mm
Duct
height
mm
Pack.
Weight
Item No.
borders
ST
Price
price/m
/ FS
Ready-to-mount trunking unit with three or six device installation lids for cable laying and the
installation of installation units of nominal size 6, consisting of the trunking base (floor base with
side and floor coveringguide profiles) and trunking lid with blankmounting opening. Floor base
with holding shackles for self-contactingmounting of dividers. The scope of supply contains six
height-adjustable fixing brackets, six screed anchors and three height-adjustable cover joint
supports for nominal trunking width 400 or six height-adjustable cover joint supports for nominal
trunking widths 500 and 600. Trunking lid screwed down when delivered.
mm
mm
Duct
height
mm
Pack.
Weight
Item No.
borders
ST
Price
price/m
/ FS
150
Width Length
100
Type
Ready-to-mount trunking unit with three or six device installation lids for cable laying and the
installation of installation units of nominal size 6, consisting of the trunking base (floor base with
side and floor coveringguide profiles) and trunking lid with blankmounting opening. Floor base
with holding shackles for self-contactingmounting of dividers. The scope of supply contains six
height-adjustable fixing brackets, six screed anchors and three height-adjustable cover joint
supports for nominal trunking width 400 or six height-adjustable cover joint supports for nominal
trunking widths 500 and 600. Trunking lid screwed down when delivered.
Width Length
mm
mm
Duct
height
mm
Pack.
Weight
Item No.
borders
ST
Price
price/m
/ FS
Type
Width Length
mm
mm
Duct
height
mm
Pack.
Weight
Item No.
borders
ST
Price
price/m
/ FS
Ready-to-mount trunking unit with three or six device installation lids for cable laying and the
installation of installation units of nominal size 9, consisting of the trunking base (floor base with
side and floor coveringguide profiles) and trunking lid with blankmounting opening. Floor base
with holding shackles for self-contactingmounting of dividers. The scope of supply contains six
height-adjustable fixing brackets, six screed anchors and three height-adjustable cover joint
supports for nominal trunking width 400 or six height-adjustable cover joint supports for nominal
trunking widths 500 and 600. Trunking lid screwed down when delivered.
90
UFS
Ready-to-mount trunking unit with three or six device installation lids for cable laying and the
installation of installation units of nominal size 9, consisting of the trunking base (floor base with
side and floor coveringguide profiles) and trunking lid with blankmounting opening. Floor base
with holding shackles for self-contactingmounting of dividers. The scope of supply contains six
height-adjustable fixing brackets, six screed anchors and three height-adjustable cover joint
supports for nominal trunking width 400 or six height-adjustable cover joint supports for nominal
trunking widths 500 and 600. Trunking lid screwed down when delivered.
100
150
Width Length
mm
mm
Duct
height
mm
Pack.
Weight
Item No.
borders
ST
Price
price/m
/ FS
Ready-to-mount trunking unit with three or six device installation lids for cable laying and the
installation of installation units of nominal size 9, consisting of the trunking base (floor base with
side and floor coveringguide profiles) and trunking lid with blankmounting opening. Floor base
with holding shackles for self-contactingmounting of dividers. The scope of supply contains six
height-adjustable fixing brackets, six screed anchors and three height-adjustable cover joint
supports for nominal trunking width 400 or six height-adjustable cover joint supports for nominal
trunking widths 500 and 600. Trunking lid screwed down when delivered.
Width Length
mm
OKA-W4004030DR9
OKA-W5004030DR9
OKA-W6004030DR9
mm
Duct
height
mm
Pack.
Weight
Item No.
borders
ST
Price
price/m
/ FS
Ready-to-mount trunking unit with three or six device installation lids for cable laying and the
installation of installation units of nominal size R9, consisting of the trunking base (floor base with
side and floor coveringguide profiles) and trunking lid with blankmounting opening. Floor base
with holding shackles for self-contactingmounting of dividers. The scope of supply contains six
height-adjustable fixing brackets, six screed anchors and three height-adjustable cover joint
supports for nominal trunking width 400 or six height-adjustable cover joint supports for nominal
trunking widths 500 and 600. Trunking lid screwed down when delivered.
Type
Width Length
mm
OKA-W4006050DR9
OKA-W5006050DR9
OKA-W6006050DR9
mm
Duct
height
mm
Pack.
Weight
Item No.
borders
ST
Price
price/m
/ FS
Ready-to-mount trunking unit with three or six device installation lids for cable laying and the
installation of installation units of nominal size R9, consisting of the trunking base (floor base with
side and floor coveringguide profiles) and trunking lid with blankmounting opening. Floor base
with holding shackles for self-contactingmounting of dividers. The scope of supply contains six
height-adjustable fixing brackets, six screed anchors and three height-adjustable cover joint
supports for nominal trunking width 400 or six height-adjustable cover joint supports for nominal
trunking widths 500 and 600. Trunking lid screwed down when delivered.
Type
150
100
Width Length
mm
mm
Duct
height
mm
Pack.
Weight
Item No.
borders
ST
Price
price/m
/ FS
Ready-to-mount trunking unit with three or six device installation lids for cable laying and the
installation of installation units of nominal size R9, consisting of the trunking base (floor base with
side and floor coveringguide profiles) and trunking lid with blankmounting opening. Floor base
with holding shackles for self-contactingmounting of dividers. The scope of supply contains six
height-adjustable fixing brackets, six screed anchors and three height-adjustable cover joint
supports for nominal trunking width 400 or six height-adjustable cover joint supports for nominal
trunking widths 500 and 600. Trunking lid screwed down when delivered.
Type
Dimension Dimension
A
a
mm
OKA-WA6050/4
OKA-WA10050/4
mm
400 201
400 201
Duct
height
Pack.
Weight
Item No.
mm
pcs
kg/% pc
ST
60+50
100+50
Price
price/pc.
/ FS
1 947.000 7424 90 0
1 976.000 7424 92 0
Ready-to-mount trunking extension unit with a device installation lid for the installation of an
installation unit of nominal size 4, consisting of the trunking base (floor base with side and floor
coveringguide profiles), trunking lid with blankmounting opening and a flushfloor end cap. The
scope of delivery contains three height-adjustable fixing brackets, three screed anchors and
trunking connection brackets.
UFS
91
mm
OKA-WA6050/6
OKA-WA10050/6
mm
400 201
400 201
mm
Duct
height
Pack.
Weight
Item No.
mm
pcs
kg/% pc
ST
253 60+50
253 100+50
Price
price/pc.
/ FS
1 922.000 7424 90 2
1 951.000 7424 92 2
Ready-to-mount trunking extension unit with a device installation lid for the installation of an
installation unit of nominal size 6, consisting of the trunking base (floor base with side and floor
coveringguide profiles), trunking lid with blankmounting opening and a flushfloor end cover. The
scope of delivery contains three height-adjustable fixing brackets, three screed anchors and
trunking connection brackets.
Dimension Dimension
A
a
mm
OKA-WA4030/9
OKA-WA6050/9
OKA-WA10050/9
mm
400 244
400 244
400 244
Duct
height
Pack.
Weight
Item No.
mm
pcs
kg/% pc
ST
40+30
60+50
100+50
Price
price/pc.
/ FS
1 868.000 7424 88 4
1 882.000 7424 90 4
1 911.000 7424 92 4
Ready-to-mount trunking extension unit with a device installation lid for the installation of an
installation unit of nominal size 9, consisting of the trunking base (floor base with side and floor
coveringguide profiles), trunking lid with blankmounting opening and a flushfloor end cover. The
scope of delivery contains three height-adjustable fixing brackets, three screed anchors and
trunking connection brackets.
Dimension Dimension
A
d
mm
OKA-WA4030R9
OKA-WA6050R9
OKA-WA10050R9
mm
400
400
400
Duct
height
Pack.
Weight
Item No.
mm
pcs
kg/% pc
ST
305 40+30
305 60+50
305 100+50
Price
price/pc.
/ FS
1 868.000 7424 88 6
1 882.000 7424 90 6
1 911.000 7424 92 6
Ready-to-mount trunking extension unit with a device installation lid for the installation of an
installation unit of nominal size R9, consisting of the trunking base (floor base with side and floor
coveringguide profiles), trunking lid with blankmounting opening and a flushfloor end cover. The
scope of delivery contains three height-adjustable fixing brackets, three screed anchors and
trunking connection brackets.
DSD2/200
DSD2/300
Dimension
A
Pack.
Weight
Item No.
mm
pcs
kg/% pc
ST
Price
price/pc.
/ FS
1 10.250 7424 99 0
1 18.450 7424 99 2
200
300
For underlaying and sealing joints of nominal trunking widths of 200 or 300mm.
Duct
height
Pack.
Weight
Item No.
mm
mm
pcs
kg/% pc
ST
/ FS
DSU2/400/4030
DSU2/500/4030
DSU2/600/4030
400 40+30
500 40+30
600 40+30
1 31.890 7424 94 0
1 39.090 7424 94 2
1 47.290 7424 94 4
DSU2/400/6050
DSU2/500/6050
DSU2/600/6050
400 60+50
500 60+50
600 60+50
1 33.490 7424 96 0
1 40.690 7424 96 2
1 48.890 7424 96 4
DSU2/400/10050
DSU2/500/10050
DSU2/600/10050
400 100+50
500 100+50
600 100+50
1 34.040 7424 98 0
1 41.240 7424 98 2
1 49.440 7424 98 4
ST
ST
Price
price/pc.
/ FS
/ FS
For underlaying and sealing joints of nominal trunking widths of 400, 500 or 600. With central,
height-adjustable support.
92
UFS
Type
Pack.
Weight
mm
mm
pcs
kg/% pc
200
300
400
500
600
40+110
40+110
40+110
40+110
40+110
Type
Width
OKA-G20040150ES
OKA-G30040150ES
OKA-G40040150ES
OKA-G50040150ES
OKA-G60040150ES
1
1
1
1
1
33.000
45.000
57.000
78.000
91.000
Price
price/pc.
Item No.
ST
/ FS
7424 28 0
7424 28 2
7424 28 4
7424 28 6
7424 28 8
Ready-to-mount trunking end cap, consisting of a flexible apron with side and floor coveringguide
profiles. The scope of delivery contains trunking connection brackets and a height-adjustable
fixing bracket.
Duct
height
Pack.
Weight
mm
mm
pcs
kg/% pc
200
300
400
500
600
40+200
40+200
40+200
40+200
40+200
Type
Width
OKA-G20040240ES
OKA-G30040240ES
OKA-G40040240ES
OKA-G50040240ES
OKA-G60040240ES
1
1
1
1
1
34.000
47.000
59.000
81.000
94.000
Price
price/pc.
Item No.
ST
/ FS
7424 30 0
7424 30 2
7424 30 4
7424 30 6
7424 30 8
Ready-to-mount trunking end cap, consisting of a flexible apron with side and floor coveringguide
profiles. The scope of delivery contains trunking connection brackets and a height-adjustable
fixing bracket.
OKA cassettes
Type
Width Cassette
height
mm
mm
Pack.
Weight
Item No.
pcs
kg/% pc
V2A / FS
Price
price/pc.
OKARK200/15 200
OKARK300/15 300
OKARK400/15 400
15
15
15
1 718.000 7425 30 0
1 1077.000 7425 31 0
1 1436.000 7425 32 0
OKARK500/15 500
OKARK600/15 600
15
15
1 1795.000 7425 33 0
1 2154.000 7425 34 0
V2A
To accept wet or dry-cleaned floor coverings. Supplied with floor coveringguide profiles and
spacer bars (length = 1,200mm) of cassette height. Six cassettes in the nominal trunking system
width.
Dimension Width
A
mm
OKA2D200
OKAD300
OKA2/D400
OKAD500
OKAD600
mm
200 200
300 300
400 400
500
600
Pack.
Weight
pcs
kg/% pc
1 442.000
1 692.000
1 942.000
1 1192.000
1 1442.000
Item No.
ST
Price
price/pc.
/ FS
7401 87 0
7401 99 7
7401 89 8
7425 00 6
7425 00 8
For blank closing of a trunking unit. Lid fixing screws contained in scope of delivery.
8AWR
Pack.
Weight
Item No.
pcs
kg/% pc
ST
10
Price
price/pc.
0.641 6288 70 4
UFS
93
Dimension Width
A
mm
OKAD200R
OKAD300R
OKAD400R
OKAD500R
OKAD600R
mm
200
300
400
500
600
200
300
400
500
600
Pack.
Weight
pcs
kg/% pc
1 443.000
1 693.000
1 943.000
1 1193.000
1 1443.000
Price
price/pc.
Item No.
ST
/ FS
7425 02 0
7425 02 2
7425 02 4
7425 02 6
7425 02 8
For blank closing of a trunking unit. Lid fixing screws and locking elements contained in scope of
delivery. Trunking lids with locking elements can be stacked, without any damage to the locking
elements.
Dimension Dimension
A
a
mm
OKA2DAT200
OKA2DAT300
OKA2DAT400
mm
Pack.
Weight
Item No.
pcs
kg/% pc
ST
Price
price/pc.
/ FS
1 436.000 7401 90 4
1 686.000 7401 91 2
1 936.000 7401 92 0
200 100
300 100
400 100
Withmounting opening for the setup of a Telitank. Mounting opening closed with blanking plate lid.
Lid fixing screws contained in scope of delivery.
Type
mm
OKAD500DAT
OKAD600DAT
mm
500 100
600 100
mm
141
141
pcs
Weight
Item No.
kg/% pc
ST
Price
price/pc.
/ FS
1 585.000 7425 04 6
1 710.000 7425 04 8
Withmounting opening for the setup of a Telitank. Mounting opening closed with blanking plate lid.
Lid fixing screws contained in scope of delivery.
mm
OKA/DG4/300
OKA/DG4/400
mm
300 201
400 201
Pack.
Weight
Item No.
pcs
kg/% pc
ST
Price
price/pc.
/ FS
1 669.000 7402 04 0
1 919.000 7402 04 8
Withmounting opening for the installation of an installation unit of nominal size 4. Mounting
opening closed with blanking lid plate. Lid fixing screws contained in scope of delivery.
94
UFS
Type
mm
OKAD500/4
OKAD600/4
mm
500 201
600 201
mm
Pack.
Weight
Item No.
pcs
kg/% pc
ST
Price
price/pc.
/ FS
1 570.000 7425 06 4
1 693.000 7425 06 6
141
141
Withmounting opening for the installation of an installation unit of nominal size 4. Mounting
opening closed with blanking lid plate. Lid fixing screws contained in scope of delivery.
mm
OKA/DG6/400
mm
400 201
mm
Pack.
Weight
Item No.
pcs
kg/% pc
ST
Price
price/pc.
/ FS
1 905.000 7402 05 6
253
Withmounting opening for the installation of an installation unit of nominal size 6. Mounting
opening closed with blanking lid plate. Lid fixing screws contained in scope of delivery.
Type
mm
OKAD500/6
OKAD600/6
mm
500 201
600 201
mm
253
253
mm
141
141
pcs
Weight
Item No.
kg/% pc
ST
Price
price/pc.
/ FS
1 570.000 7425 08 4
1 693.000 7425 08 6
Withmounting opening for the installation of an installation unit of nominal size 6. Mounting
opening closed with blanking lid plate. Lid fixing screws contained in scope of delivery.
Dimension Dimension
A
a
mm
OKA/DG9/400
mm
400 244
Pack.
Weight
Item No.
pcs
kg/% pc
ST
Price
price/pc.
/ FS
1 903.000 7402 06 4
Withmounting opening for the installation of an installation unit of nominal size 9. Mounting
opening closed with blanking lid plate. Lid fixing screws contained in scope of delivery.
UFS
95
mm
OKAD500/9
OKAD600/9
mm
mm
500 244
600 244
Pack.
Weight
Item No.
pcs
kg/% pc
ST
Price
price/pc.
/ FS
1 570.000 7425 10 2
1 693.000 7425 10 4
161
161
Withmounting opening for the installation of an installation unit of nominal size 9. Mounting
opening closed with blanking lid plate. Lid fixing screws contained in scope of delivery.
Dimension Dimension
A
d
mm
OKA/DGR9/400
400
mm
Pack.
Weight
Item No.
pcs
kg/% pc
ST
Price
price/pc.
/ FS
1 888.000 7402 06 8
305
Withmounting opening for the installation of an installation unit of nominal size R9. Mounting
opening closed with blanking lid plate. Lid fixing screws contained in scope of delivery.
Type
mm
OKAD500R9
OKAD600R9
500
600
mm
192
192
mm
305
305
pcs
Weight
Item No.
kg/% pc
ST
Price
price/pc.
/ FS
1 570.000 7425 12 2
1 693.000 7425 12 4
Withmounting opening for the installation of an installation unit of nominal size R9. Mounting
opening closed with blanking lid plate. Lid fixing screws contained in scope of delivery.
OKAFB
Pack.
Weight
Item No.
pcs
kg/% pc
ST
Price
price/pc.
/ FS
1 10.500 7424 82 0
EA3/6
Pack.
Weight
Item No.
pcs
kg/% pc
V2A
Price
price/pc.
1.300 7425 14 0
For anchoring trunking units, end caps and extension units in the screed.
96
UFS
Length Width
mm
mm
OKA/BA4/3 2,400
Pack.
Weight
Item No.
borders
Al
Price
price/m
Floorguide profile for the OKA-G and OKA-W trunking systems. Insertable in the side profile flush
with floor or at a height of 3mm above the floor. Spare part.
Length
Pack.
Weight
Item No.
mm
borders
MGUM
OKAFD 15,000
15
Price
price/m
1.000 7424 82 2
Forgluing in the side profiles of the OKA-G/-W trunking system at a later date to create a wetcleanable state, sold by the roll.
OKA2TW30
OKA2TW40
OKA2TW50
OKA2TW60
OKA2TW70
OKA2TW80
OKA2TW90
OKA2TW100
OKA2TW110
OKA2TW120
OKA2TW130
OKA2TW140
OKA2TW150
Length
Duct
height
mm
mm
2,400
2,400
2,400
2,400
2,400
2,400
2,400
2,400
2,400
2,400
2,400
2,400
2,400
40
60
70
80
90
100
110
120
130
140
150
160
170
Pack.
Weight
borders
2.4 23.300
2.4 31.300
2.4 39.200
2.4 46.700
2.4 54.600
2.4 62.500
2.4 70.000
2.4 77.900
2.4 85.800
2.4 93.800
2.4 101.300
2.4 109.200
2.4 117.100
Item No.
ST
Price
price/m
/ FS
7401 98 4
7401 98 8
7401 99 2
7401 99 6
7402 00 0
7402 00 4
7402 00 8
7401 96 0
7401 96 4
7401 96 8
7401 97 2
7401 97 6
7401 98 0
Divider for use in the floor base of previously prepared OKA-W trunking units.
Duct
height
mm
OKA-NEVE110 40+70
OKA-NEVE150 40+110
OKA-NEVE250 40+210
Dimension Pack.
h
mm
110
150
250
pcs
Weight
Item No.
kg/% pc
ST
Price
price/pc.
1 14.200 7425 97 0
1 15.300 7425 97 2
1 18.000 7425 97 4
Complete levelling unit with express height adjustment for connecting, fastening and adjusting the
height of trunking units of the OKA-G and OKA-W systems. For additional requirements.
Lifting tools
08 UFS_Katalog_2008_deutsch / en / 18/09/2009 (LLExport_00047)
Type
WZ1028
Pack.
Weight
pcs
kg/% pc
Item No.
Price
price/pc.
1 201.600 7408 63 0
For lifting out cassettes, boxes and duct or trunking lids. Adhesive force: 1,300 N.
Type
WZ1029
Pack.
Weight
pcs
kg/% pc
Item No.
Price
price/pc.
1 51.000 7408 63 4
For lifting out cassettes, boxes and duct or trunking lids. Support force 300 N.
UFS
97