Académique Documents
Professionnel Documents
Culture Documents
Main Features
One to six hot-swap rectifiers
Active current sharing among rectifiers
Universal input voltage
A built-in dual 70A Electronic Low Voltage Disconnect device (ELVD)
for battery protection
A high-performance, hot-swap system controller (SC 1006)
measure, monitor and control voltages, current, power, battery,
temperature parameters etc.
RS232 (SC1006) or TCP/IP communication (SC 1006 NET)
Temperature compensation enhance battery life
Battery current limit
Up to two battery sets handled in one system
Automatic and pre-programmed battery test (for each battery set)
Automatic and pre-programmed equalize charging mode
Comprehensive remote control and monitoring of the system using
a dedicated graphical used interface (GeMSi, PSM-DC 1006)
Breaking alert by modem (option)
Battery / Load terminals protected by a dedicated thermal-magnetic
circuit breaker
12V-18A
100
GENERAL
System Controller
24V-15A
24V-30A
N*3.5
48V-30A
13.5
0.2Vdc
10-15Vdc
85Vac to 270Vac
N*10A
N*6A
N*10A
N*10A
0.99
27 0.2Vdc
20-30Vdc
N*30A
54
N*15A
N*30A(Vin>100V)
N*20A(Vin<100V)
86% @ 230Vac
88% @ 230Vac
82% @ 115Vac
<N*20A
<N*31A
84% @ 115Vac
<N*16A
<N*31A(Vin>100V)
<N*21A(Vin>100V)
N*3A<Isc<N*4A
N*6A<Isc<N*8A
30V
N*12A(Vin>150V)
N*8A(Vin<150V)
-10 to +45 C
90% @ 230Vac
87% @ 115Vac
<N*13A(Vin>150V)
<N*9A(Vin>150V)
N*3A<Isc<N*5A
o
-10 to +65 C
<1 sec
40ms
20ms
20ms
10ms
-20 to 80<C
EN 300 386-2 V1.1.1.3 (1997), EN55022, EN6100-4-2, 3, 4, 5, 6, 11,
EN 61000-3-2 and EN 61000-3-3
1. N=number of modules
2. Basic Shelf 1 has V/A meter. Basic Shelf 2 has a system controller.
3. Equipment DC test voltage is applied to overcome Y-capacitors leakage current to ground.
Output is floating (not grounded) during test.
4. Programmable with SC1006 if included
5. N*18A to N*12A decreases linearly for Vin<120V [N*12A (for Vin=85V)]
All specifications are subject to change without prior notice
67.5
0.5%
N*25A(Vin>165V)
N*18A(165>Vin>120V)5
N*30A(Vin>200V)
N*16A(Vin=110V)
0.5Vdc
15ms
0.2Vdc
60-75Vdc
N*31A(Vin>200V)
<N*14A(Vin=230V)
-10 to +40 C
-10 to +45 C
<1 sec
Disconnect:42
0.2Vdc
47-60Vdc
N*3A<Isc<N*5A
N*6A<Isc<N*8A
15V
o
o
-10 to +65 C
N*10A
47Hz to 63Hz
0.5%
N*18A
60V-15A
47Hz to 63Hz
0.99
ELVD
Max. Current Withstand
4
48V-25A
100
48V-12A
85Vac to 270Vac
N*6A
N*6A
Frequency
Power Factor (at full load)
OUTPUT
Voltage (default)
Adjustable Range (manual)
Regulation (line & load)
Nominal Current 1
12V-30A
10ms
10 LEDs bar-graph (1st LED indications operation only)
10% accuracy at full load
N*15A(Vin>100V)
N*10A(Vin<100V)
92% @ 230Vac
89% @ 115Vac
<N*18A
N*3A<Isc<N*5A
75V
o
-10 to +40 C