Académique Documents
Professionnel Documents
Culture Documents
The Inorganic salts can be decomposed in the crude oil pre-heat exchangers and
heaters. As a result, hydrogen chloride gas is formed which condenses to liquid
hydrochloric acid at overhead system of distillation column, that may causes
serious corrosion of equipment.
To avoid corrosion due to salts in the crude oil, corrosion control can be used.
But the byproduct from the corrosion control of oil field equipment consists of
particulate iron sulfide and oxide. Precipitation of these materials can cause
plugging of heat exchanger trains, tower trays, heater tubes, etc. In addition,
these materials can cause corrosion to any surface they are precipitated on.
The sand or silt can cause significant damage due to abrasion or erosion to
pumps, pipelines, etc.
The calcium naphthanate compound in the crude unit residue stream, if not
removed can result in the production of lower grade coke and deactivation of
catalyst of FCC unit
Crude oil passes through the cold preheat train and is then pumped to the Desalters
by crude charge pumps. The recycled water from the desalters is injected in the
crude oil containing sediments and produced salty water. This fluid enters in the
static mixer which is a crude/water disperser, maximizing the interfacial surface
area for optimal contact between both liquids.
The wash water shall be injected as near as possible emulsifying device to avoid a
first separation with crude oil. Wash water can come from various sources
including relatively high salt sea water, stripping water, etc. The static mixers are
installed upstream the emulsifying devices to improve the contact between the salt
in the crude oil and the wash water injected in the line.
The oil/water mixture is homogenously emulsified in the emulsifying device. The
emulsifying device (as a valve) is used to emulsify the dilution water injected
upstream in the oil. The emulsification is important for contact between the salty
production water contained in the oil and the wash water. Then the emulsion enters
the Desalters where it separates into two phases by electrostatic coalescence.
The electrostatic coalescence is induced by the polarization effect resulting from an
external electric source. Polarization of water droplets pulls them out from oilwater emulsion phase. Salt being dissolved in these water droplets, is also
separated along the way.
The produced water is discharged to the water treatment system (effluent water). It
can also be used as wash water for mud washing process during operation.
A desalting unit can be designed with single stage or two stages. In the refineries,
the two stages desalting system is normally applied, that consists of 2 electrostatic
Coalescers (Desalter).