Académique Documents
Professionnel Documents
Culture Documents
To finish the Autocom Cars software update to 2011-3 version, you need to use two computers:
one connected to internet for autocom activation and the other disconnected to internet for
autocom installation.
1. Put the autocom CD into the computer that disconnected to internet and run the sart.exe:
4. Input the S/N and Hardware Key for Cars serial number: 30250, HW key: NZTTOOCNHVE
5.
6.
10. Click Finish button to complete the autocom installation, select Run application, at this
step, please dont connect the autocom device:
11. Run the autcom software installed, it will show this information, click the forward button:
13. At this step, connect the USB stick at least 1MB free space to computer, then you will see
second display:
14. The software is writing the FileActivation.xml and other information to USB stick. In the USB
stick, you will see those files:
You will see the display on software window, disconnect the USB stick from computer, keep the
software running for next steps:
20. If the program does nothing, click manual mode, click open file to select the activated file
21. Eject out usb-memory stick, software will open then will have an error (Failed to load
vehicle ......), just close software
22. Run '' Update_3_-_2011_Release_3 '' , write product id ( for cars : a-710-479 ) ,then software
will open !!
23. If you used already old version autocom, for use interface you need make firmware update:
Connect interface to car. (For power)
Select setting, do hardware test, it will have a message asking about firmware update. Click
ok and it will make firmware update.
You need wait few minute for firmware update. (When is doing firmware update, dont close
software or remove power, etc)
Then you can use autocom 2011 release3!