Vous êtes sur la page 1sur 92

Machine serial number :

3689-97
3727-28-33-34-76-77-78-79-80
3810-11-14-13-18-To-23-31-32-40-41-42-44-45-46-47-64
3905-06-10-11-17-To-22-24-To-29-39-89-91-92-93-94
4002-4008-4009-4010-4016-4033-4034-4069-4070

OPERATORS

MANUAL

Through The Rock

2 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

3 (92)

AXERA 5 126-126NV

CONTENTS

INTRODUCTION TO MACHINE

1/1

INTENDED TO USE

1/2

RECOMMENDED OPERATING CONDITIONS

1/3

COMPONENTS OF THE MACHINE

SAFETY & ENVIRONMENTAL INSTRUCTIONS

15

2/1

OPERATOR SAFETY INSTRUCTIONS

15

2/2

MAIN SAFETY HAZARDS IN USE OR MAINTENANCE WORK

16

2/3

ENVIRONMENTAL PRECAUTIONS

18

2/4

TYPE PLATE

19

2/5

GRADIENT ANGLE

19

2/6

MACHINE IN TRAMMING POSITION AND PARKING

20

2/7

DANGER AREAS

21

2/7/1

DANGER AREA WHEN TRAMMING

21

2/7/2

DANGER AREA WHEN DRILLING

22

2/8

MANNERS AND CONDITIONS IN WHICH THE RIG SHOULD NOT BE USED.

23

2/9

NOISE LEVEL AND NOISE EMISSION

23

2/10

ACCELERATION VALUE

23

2/11

SAFETY EQUIPMENT

23

2/12

FIRE PREVENTION

24

2/12/1 REFILLING FUEL

24

2/13

FIRE EXTINGUISHER (OPTIONAL)

25

2/14

EMERGENCY STOPS, MAIN SWITCHES AND EMERGENCY BRAKES

26

2/15

ELECTRIC CABLE

28

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

4 (92)

AXERA 5 126-126NV

CHECKS AND INSTRUCTIONS

29

3/1

ASSEMBLY AND CHECKING OF A NEW MACHINE

29

3/2

ROUTINE CHECKS BEFORE STARTING A SHIFT

30

3/3

ELECTRIC PANEL

38

3/4

TRAMMING COMPARTMENT

39

3/5

BOOM MOVEMENTS

42

3/6

DRILLING COMPARTMENT

43

TRAMMING

48

4/1

STARTING THE ENGINE

48

4/2

EMERGENCY/PARKING BRAKE TEST

51

4/3

ELECTRIC CABLE

52

4/4

MOVING THE MACHINE

53

4/5

PARKING THE MACHINE

54

DRILLING

55

5/1

SETTING-UP THE MACHINE IN THE DRIFT

55

5/2

ELECTRIC POWER

57

5/3

PARALLELISM SETTING

63

5/4

SETTING DRILL FEED TTF AND TFX

65

5/5

COLLARING A HOLE

67

5/6

NORMAL DRILLING

67

5/7

ROD UNCOUPLING

69

5/8

ENDING A SHIFT

69

TRANSPORTATION

70

6/1

TRANSPORTATION ON A PLATFORM

70

6/2

TOWING THE MACHINE

71

6/3

LIFTING THE MACHINE

72

6/4

STORING THE MACHINE

74

TECHNICAL DATA

75

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

5 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
INTRODUCTION TO MACHINE

INTRODUCTION TO MACHINE

This manual provides instructions for the use and safe operation of an AXERA 5 machine.The
information contained in this manual must be studied and thoroughly assimilated before attempting to
operate this machine.
NOTE: Whenever FRONT, REAR, RIGHT and LEFT are mentioned throughout this
manual, it is assumed that the operator is standing at the rear of the machine (Engine end) and
looking toward the front (Boom end). Right and left DO NOT REFER to the operators seat but
refer to the right and left of the machine.
WARNING: It is the operators responsibility to ensure that the machine is in
perfect working condition. At each machine start-up, a pre-start check list MUST
be completed even if the machine has been used earlier in the day. It is the
operator who is at the controls that will assume full responsibility if an accident or
injury occurs.

1.1

INTENDED TO USE

AXERA 5 is intended for use in mining, preparation work and tunneling.It is an independently operating
hydraulic rig that drills vertical, inclined and horizontal holes.

1.2

RECOMMENDED OPERATING CONDITIONS

Ambient temperature -30C .... +50C


Maximum altitude from sea level 3000m
Before use in exceptional conditions, contact Sandvik Tamrock Secomas engineering department.

RIGHT

REAR

FRONT
LEFT

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

6 (92)

AXERA 5 126-126NV
INTRODUCTION TO MACHINE

1.3

COMPONENTS OF THE MACHINE


FRONT SECTION

FRONT SECTION

1. Rock drill
2. Feed
3. Boom
4. Front stabilizers

3
4
Rock drill

HLX5

1
2

2
4
HL510

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

1. Pressure accumulator
2. Rotation housing
3. Flushing housing
4. Gear housing

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
INTRODUCTION TO MACHINE
Drill feed

1
2

3
4

TF500

1
2
3
4

1. Hose reel
2. Rock drill carriage
3. Feed cylinder, wire ropes
4. Centralizers

TTF500

2
TFX500

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7 (92)

7849 3697-N-16-02-2006 SR-RB-FL

8 (92)

AXERA 5 126-126NV
INTRODUCTION TO MACHINE
Boom

B26F-XLF

2
1

1.Boom swing
2.Boom Extension
3.Divergence
4.Feed Extension
5.Feed Swing (main)
6.Boom lift
7.Feed swing (slave)
8.Feed Tilt
9.Feed Roll-over

8
7

B26NV-XLNV

2
4

6
3

8
10

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

1.Boom swing
2.Boom Extension
3.Divergence
4.Feed Extension
5.Feed Swing (main)
6.Boom lift
7.Feed swing (slave)
8.Feed Tilt
9.Feed Roll-over
10.Feed Angle

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
INTRODUCTION TO MACHINE

MIDDLE SECTION
MIDDLE SECTION

3b

3a

5
6

1. Tramming compartment
2. Drilling compartment
3a. Air circuit components
b. Mine air supply (optional)
4. Tramming power train
5. Drilling hydraulic components
6. Water Hose reel (optional)
7. Fire extinguisher (optional)

Tramming compartment

5
7
3

1. Steering wheel
2. Tramming control panel
3. Stabilizers and canopy controls
4. Tramming control pedals
5. Emergency brake push button
6. Operator seat
7. Cable reel control
8. Cable reel (and water hose reel :optional)
electric control

6
SANDVIK TAMROCK SECOMA S.A.S
19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

9 (92)

7849 3697-N-16-02-2006 SR-RB-FL

10 (92)

AXERA 5 126-126NV
INTRODUCTION TO MACHINE
Drilling compartment

3
1

3
10
9
1

1. Boom controls
8 2. Drilling controls
3. Drilling pressure adjustments
4. Gauges
5. Switches and light
6. Emergency stop push button
7. Indictor light Panel
8. Optional lever for boom movement (B26 NV
or LC) or rod clamp
4 9.Optional lever for rod clamp
10.Optional lever for TRS

8
6

Tramming power train

4
1. Axles
2. Drive lines
3. Central gear box
4. Tramming hydraulic motor
5. Bolster

3
SANDVIK TAMROCK SECOMA S.A.S
19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
INTRODUCTION TO MACHINE

Drilling hydraulic components

2
4

1. Drilling hydraulic oil tank


2. Drilling electric power pack
3. Drilling low pressure oil filter
4. Drilling high pressure oil filter
5. Hydraulic oil filling pump

REAR SECTION
REAR SECTION

1. Diesel power pack


2. Water circuit component
3. Electric cable reel
4. Electric Box
5. Rear stabilizers
6. Air circuit component

4
5
1

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

11 (92)

7849 3697-N-16-02-2006 SR-RB-FL

12 (92)

AXERA 5 126-126NV
INTRODUCTION TO MACHINE
Diesel power pack

1
6
3

2
1.Diesel engine
2.Engine air filter
3.Exhaust gas purifier
4.Fuel tank
5.Fuel tank filling cap
6.Tramming pump
7.Tramming oil cooler
8.Tramming oil tank

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
INTRODUCTION TO MACHINE
Water circuit components

1b

1.a Water supply connection


OR
1.b Water hose reel (optional)
2. Water pump
3. Oil water cooler

1a

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

13 (92)

7849 3697-N-16-02-2006 SR-RB-FL

14 (92)

AXERA 5 126-126NV
INTRODUCTION TO MACHINE
Air circuit components

4
1
5

1. Air compressor
2. Rock drill air oiler
3. Air cleaner
4. Air receivers (optional)
5.Mine air supply connection (optional)
6. Air mist sight glass (optional)

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

15 (92)

AXERA 5 126-126NV
SAFETY & ENVIRONMENTAL INSTRUCTIONS

SAFETY & ENVIRONMENTAL INSTRUCTIONS

RISK OF INJURY AND AUTOMATIC VOIDANCE OF SANDVIK TAMROCK WARRANTY


To Whom It May Concern:
SANDVIK TAMROCK HAS DESIGNED SAFETY FEATURES BECAUSE IT BELIEVES SUCH FEATURES WILL BETTER PROTECT PEOPLE. DO NOT DO ANYTHING THAT MAY HAMPER SAFETY
FEATURES ON EQUIPMENT.
It is strictly forbidden to make ANY modification to a Sandvik Tamrock product without prior written
approval of the factory. If ANY modifications are made without written approval, Sandvik Tamrock can not
be held responsible for any accidents, incidents or damage to persons or property, especially if modifications are made on any safety feature including, but not limited to, safety critical circuits or components.
In many cases, the affect of a modification to a machine's total performance is unknown.
Therefore, if a machine is modified for any reason, even if safety is not affected, Sandvik Tamrock's
warranty will be void.

2.1

WARNING

WARNING

OPERATOR SAFETY INSTRUCTIONS


WARNING: Operation, maintenance and adjustments are only allowed to persons
with specific training in operation and maintenance of the equipment. Read the
operating and maintenance instructions before using or servicing the equipment.
WARNING: Plan your work carefully in advance to avoid possible accidents and
injuries. The operator must be familiar with the functions of the equipment before
taking it into use.
WARNING: The operator must always wear required personal protection, such as
safety helmet, protective overall, safety boots, hearing protectors, safety goggles
etc...
Always ensure that those protections are in good shape before using them.

WARNING

WARNING: Adequate ventilation must always be provided.


Make sure that ventilation is sufficient to prevent exhaust fumes and dust.
Exhaust fumes can be lethal.
When operating in confined conditions the exhaust gases and dust must be
directed in such a way that they do not return to the working area and create a
hazard.
Check regularly the exhaust purifier clogging according to its maintenance
manual.
WARNING: Always have a fire extinguisher at hand and learn how to use it.
Have the extinguisher inspected and serviced regularly according to the local
regulations and to the extinguisher maintenance manual.

WARNING

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

16 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
SAFETY & ENVIRONMENTAL INSTRUCTIONS

WARNING: Take care of sufficient lightning.


WARNING: Insufficient scaling of drilling site

2.2

Main safety hazards in use or maintenance work


WARNING: MAKE SURE THAT THERE ARE NO UNAUTHORIZED PERSONS IN THE
DANGER AREAS DURING DRILLING OR TRAMMING.
WARNING: Simultaneous charging and drilling is strictly forbidden.
WARNING: Always check the efficiency of the safety devices before using the
machines: emergency stop push button, emergency brakes, backward tramming
light and buzzer, tramming and working light, horn, etc...
WARNING: All hoods must be correctly mounted on the machine and the doors
correctly closed and locked, this all the time in order to prevent accident with moving
components such a engine belt, cable reel chain, etc...

WARNING

WARNING: danger of slipping, tripping or falling.


Keep the ladders, steps, hand rails, handles and working platforms clean of oil, dirt
and ice.
WARNING: Observe the balance of the rig.
Never exceed the specified inclination angles when parking, tramming or drilling.

WARNING: While tramming NEVER SWING THE BOOMS, if needed SWING THE
DRILL FEED(S).

WARNING: Before moving the booms make sure that the jacks and the stabilizers are
firmly in contact to the ground.

WARNING: Crushing hazard : do not stay in dangerous area, for instance: central
articulation, front chassis and rear chassis..
WARNING

WARNING: The movements and rotation of components form also danger areas
(boom, feed and drilling equipment).
MAKE SURE THAT THERE ARE NO UNAUTHORIZED PERSONS IN THE DANGER
AREAS.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

17 (92)

AXERA 5 126-126NV
SAFETY & ENVIRONMENTAL INSTRUCTIONS

Gloves

WARNING

WARNING: Danger of hot surface.


Hot surface can cause serious injuries.
Components as diesel engine, exhaust gas purifier, rod, shank or hydraulic
components can be hot and before starting a maintenance work, please let them cool
off.
WARNING: Service operations should be carried out only when the rig is stopped.
Replace or repair faulty tools and equipment.
Make sure that there are no unauthorized persons in the working area when you
carry out service and repair work.
The drilling equipment must always be kept clean of oil and dirt.
WARNING: Make sure that the boom is properly supported before servicing the
hydraulic system.

WARNING: Danger of high pressure air streams. The air streams can cause serious
personal injuries.
Release the pressure before opening filling caps or pneumatic connections.

WARNING

WARNING

WARNING: The lubricator, the compressor air/oil receiver and any air receiver are
pressure vessels and they are not allowed to be repaired without proper
authorization.
Check regularly the certification validity of those componnents.
At the end of validity period, you must make recertify the component by a
registered organization or replace it by a new one.
WARNING: Danger of high pressure oil jets.
High pressure oil jets can cause serious personal injuries.
Release the pressure in the hydraulic circuits before opening caps or connections.
(Accumulator,Cylinder and Hydraulic circuit)
WARNING: If the component must be live, a fellow worker must be standing by to cut
OFF voltage at the emergency or main switch in an emergency situation.

WARNING

WARNING: If you have to weld the rig, disconnect the alternator cables or open the
main switch before starting to weld. Consider also the fire and explosion risk caused
by welding. Make sure that the rig and its surroundings are clean and fire-safe.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

18 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
SAFETY & ENVIRONMENTAL INSTRUCTIONS

2.3

ENVIRONMENTAL PRECAUTIONS
WARNING: Please notice that the hydraulic oil, fuel, and battery liquid can cause
pollution. Please refer to your own environmental standars for the liquide processing
Before operating maintenance always plan your work in order to use adequate and
in good shape receptacles.
Do not use the diesel engine if it is not needed because of exhaust gas, think about
the people and the environment.
For decommissioning, scrapping and disposal of machines components (diesel
engine, tyres, batteries, etc...), you must always observe the law in force in your
country.
In case of no law or if you think its not suficient, you can contact the conponent
supplier.
Always have a fire extinguisher at hand and lurn of to use it.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

19 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
SAFETY & ENVIRONMENTAL INSTRUCTIONS

2.4

TYPE PLATE
8
2

1
3

4
AXERA 5

1FP D/E

1- Machine name and type


2- Serial number

3- Diesel engine power


4- Electric input power
5- Electric voltage
6- Electric frequency
7- Total weight of the machine
8- Manufacturing date

2.5

GRADIENT ANGLE

WARNING: The maximum gradient


angle is 15.
WARNING: The maximum side
slope angle is 5 .
WARNING: On slippery surfaces,
e.g. ice or smooth rock, safe
tramming and drilling gradients
are much smaller than on surfaces
with good grip.
NB: There are two inclination gauges at the
tramming compartment.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

20 (92)

AXERA 5 126-126NV
SAFETY & ENVIRONMENTAL INSTRUCTIONS

2.6

MACHINE IN TRAMMING POSITION AND PARKING

B26NV

Parking position

Tramming position

Parking position

B26F

Tramming position

Boom extension must be fully retracted


Boom must be in line with the machine axis.
Lower the drill feed and boom as far as possible
Machine on stabilizers in parking position
WARNING: While tramming NEVER SWING THE BOOM.
- If needed SWING THE DRILL FEED -

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

21 (92)

AXERA 5 126-126NV
SAFETY & ENVIRONMENTAL INSTRUCTIONS

2.7
2.7.1

DANGER AREAS
DANGER AREA WHEN TRAMMING

5m

Do not allow other personnel to stand in the area


shown beside.
DANGEROUS AREAS:
5m toward the front end of the drill feed and
5m backward the rear end of the carrier.
Area between the machine and the side wall
of the drift.
Never allow riders on any part of the machine.
Always sound the horn before starting the engine.
The operator must be attentive at any time and have
to stop the machine if a person is in the dangerous
area
Keep hands, arms, legs and head completely inside
the tramming compartment.

Ensure that the machine is in perfect operating


condition.
Complete in full, at each shift pre-start check list.

5m

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

22 (92)

AXERA 5 126-126NV
SAFETY & ENVIRONMENTAL INSTRUCTIONS
2.7.2

DANGER AREA WHEN DRILLING

NO PERSONNEL ALLOWED

NO PERSONNEL ALLOWED

DURING DRILLING OPERATION, NEVER ALLOW PERSONNEL TO


STAND IN THE AREA BETWEEN THE DRILLING COMPARTMENT
AND THE ZONE BEING DRILLED.
A MACHINE SHOULD NEVER BE IN AN AREA THAT HAS NOT BEEN
CAREFULLY SCALED.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

23 (92)

AXERA 5 126-126NV
SAFETY & ENVIRONMENTAL INSTRUCTIONS

2.8

MANNERS AND CONDITIONS IN WHICH THE RIG SHOULD NOT BE USED.


Risk factors for personnel:
Operator does not have sufficient training.
Unauthorized person are present in the working area.
Insufficient scaling of the working area.
Exposition to gases in the drift.
Safety systems are deficient or out of order.
The field is charged.
Transportation of persons.
Use of the rig for lifting purposes.
Inadequate ventilation.
Inadequate lightning.
Inadequate electric earthing.
Defective safety devices.

2.9

NOISE LEVEL AND NOISE EMISSION

Noise level
The measurement of the noise emission and the noise level at the operator compartment have been
measured in accordance of the European Standard Drill Rig safety 89/392/EEC and changes of 91/
368/EEC AND 93/44/EEC.
Noise emission:100 db(A) the rockdrill in operation.
Level at the operator compartment: 98 db(A) the rockdrill in operation.

2.10

ACCELERATION VALUE

The measurement of the acceleration value at the operators positions have been measured in
accordance of European Standard Drill Rigs - safety 89/392/EEC and changes of 91/368/EEC and 93/
44/EEC.
Acceleration value does not exceed 0.5 m/s2

2.11

SAFETY EQUIPMENT
WARNING: Check the emergency stop buttons and safety equipment for proper
operation and condition at the beginning of each shift and always after tramming.
Fire extinguisher(s)
Emergency stop buttons
Safety and protection devices
WARNING: Always check the emergency/park brake efficiency prior to move the
machine.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

24 (92)

AXERA 5 126-126NV
SAFETY & ENVIRONMENTAL INSTRUCTIONS

2.12

FIRE PREVENTION
Keep the machine clean at all times, especially from fuel, grease, oil rags and paper.
Wash the machine regularly.
Check fire extinguishers and/or fire prevention equipment daily to ensure that they are
in perfect working order.When avaible on the unit
Keep electric components and wiring in good condition.
The filling of tanks must be carried out in a well-ventilated area.
The control and recharging of batteries must be carried out in a well-ventilated area.

2.12.1

REFILLING FUEL

The following precautions must be observed when replenishing fuel:


Do not fill fuel tank when the engine is running.
Take care not to spill fuel on hot surfaces.
Fuel filling should be done in a well ventilated space.
Smoking, open flame and sparks are dangerous when the fuel tank is being filled.
Wipe off spilled fuel before starting the engine.
Keep the fuel replenishing pipe in contact with the fuel tank or arrange earthing to prevent sparking
caused by static electricity.
WARNING: Smoking during filling or control operations is forbidden.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

25 (92)

AXERA 5 126-126NV
SAFETY & ENVIRONMENTAL INSTRUCTIONS

2.13

FIRE EXTINGUISHER (OPTIONAL)


2

A
PUSH BUTTON

1
PIN

Fire extinguisher (optional)


The fire extinguisher actuators are located in A at the tramming compartment and in B at the rear of
the machine, as shown on the drawing.
To activate the fire extinguisher:
Step 1 : Pull out the lock pin.
Step 2 : Push the red button.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

26 (92)

AXERA 5 126-126NV
SAFETY & ENVIRONMENTAL INSTRUCTIONS

2.14

EMERGENCY STOPS, MAIN SWITCHES AND EMERGENCY BRAKES


WARNING: Always ensure free access to the emergency stops.
WARNING: check the operation of the emergency stops prior to use the machine.

When any emergency stop push button is depressed, the Diesel engine and the power pack stop at once.

EMERGENCY STOP BUTTONS


AT TRAMMING COMPARTMENT
AT DRILLING COMPARTMENT
EMERGENCY STOP
PUSH BUTTON

EMERGENCY STOP
PUSH BUTTON

AT REAR MACHINE
EMERGENCY STOP
PUSH BUTTON

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

27 (92)

AXERA 5 126-126NV
SAFETY & ENVIRONMENTAL INSTRUCTIONS

EMERGENCY/PARKING BRAKES

EMERGENCY / PARK BRAKE


PUSH BUTTON

When tramming in emergency situation:


Release the accelerator pedal
Depress the emergency/parking brakes red
button.
WARNING: The machine is featured
with a safety brake system that
applies the brakes automatically
when there is a sudden drop in the
pressure of the braking circuit.
As the machine may come to an
abrupt halt, the operator must be correctly
seated and attentive at all times.
TRANSPORTING PASSENGERS AND
STANDING UP WHILE TRAMMING IS STRICTLY
FORBIDEN.

BATTERY MASTER SWITCH

OFF

ON

CAUTION

CAUTION: So as to prevent the alternator to


be damaged, stop the engine prior to turn the
battery master switch to the OFF position.
NOTE: In drilling electric mode, switch off
the battery in order not to dischange the
battery

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

28 (92)

AXERA 5 126-126NV
SAFETY & ENVIRONMENTAL INSTRUCTIONS
ELECTRIC MAIN CIRCUIT-BREAKER
ON

WARNING: Switching off the main


circuit-breaker do not shut off the
power at the cable reel and in the
cable connected to the machine.
Consequently the cable is still live.
NEVER HANDLE A LIVE CABLE.
Never leave the machine while
motors are running.

RESET

OFF

CAUTION: Do not rotate the main


switch if a motor is running. Stop all
motors prior to use the main switch.
CAUTION

NOTE: if the electric main circuit-breaker


trip OFF automatically due to an electric
problem, move the handle fully to reset
position prior to place it back to ON position.

2.15

Electric cable
WARNING: Never use an electric cable unless it is firmly positioned on its
support. this will prevent unnecessary tension on the cable which may result in
the plug being pulled from its socket.
The cable must never be live before the machine is ready to drill and the cable
itself has been placed in its support and support hooks.
NEVER HANDLE A LIVE CABLE.
Never move the machine if the cable is live.
To ensure that no vehicle will drive over the cable, lay the cable in hooks which
have been placed in the sidewall along the length of the gallery being drilled.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

29 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS

CHECKS AND INSTRUCTIONS

3.1

ASSEMBLY AND CHECKING OF A NEW MACHINE

If the machine is delivered disassembled, please pay special attention to the following points:
The assembly site must be properly equipped (cleanliness, good lighting, lifting equipment, etc...).
The assembly operation must be done by qualified personnel.
Check that all components are delivered.
Fasten all bolts and connections properly.
Observe cleanliness when installing hydraulic hoses to prevent particles to enter in the hydraulic
circuit.
Lubricate all greasing points.
Wash the machine before using it.

VISUAL CHECKING OF A NEW MACHINE


CENTRAL ARTICULATION
LOCKING BAR

Check for:
Possible transportation damage.
Tyre pressure and condition.
All oil and fuel levels.
CAUTION:
Remove the central
articulation locking bar before moving
the machine.

LOCKED BAR
IN UNLOCKING POSITION

CAUTION

WARNING: All electric safety


devices must be thoroughly
checked prior to attempt to start
the machine.
WARNING:
The
rock
drill
accumulators must be inflated with
NITROGEN (N2).

Locking bar
in locking position

LOCKED BAR
IN LOCKING POSITION

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

30 (92)

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS

3.2

ROUTINE CHECKS BEFORE STARTING A SHIFT


WARNING: Report any damage or faulty components immediately and do not use the
machine.

PINS

2
TYPE A:

Lock plate 2 must be in contact to the


support 1.
Fastening screws in place and tighten.

1
TYPE B

Fastening bolt 1 in place and tighten.

TYPE C

Fastening bolt 1 in place and tighten.

HOSES, FITTINGS AND HYDRAULIC CONNECTIONS


When moving around the machine, look for
hydraulic damages

Hoses
Fittings and connections
Hydraulic leaks

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS
ENGINE

1
2
AIR FILTER

Make sure that the clogging indicator 1 is


in the green zone. An indicator located in
the red zone calls for filter element
replacement.
Expel dust from the pre-filter dust
collector 2.
Check the hose between the filter and the
engine intake manifold for fraying cracks
and damaged clamps.

ENGINE OIL LEVEL

Ensure that the engine oil is between the


minimum and the maximum level marks on
the dipstick.

ENGINE OIL LEVEL

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

31 (92)

7849 3697-N-16-02-2006 SR-RB-FL

32 (92)

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS

WATER SEPARATOR / FUEL HEATING FILTER (OPTIONAL)

Open the drain to evacuate contaminants


and water.
Close the drain.

Drain

WHEELS
1
3

Visualy check the tyres 1, look for


damages.
Make sure the nuts 2 are correctly tighten
(Wheel tightenning torque : 400 Nm).
2

Make sure the lock ring 3 is correctly in


place.
Check the pressure (tyre pressure : 8
bar).

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

33 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS
HYDRAULIC TANKS

TRAMMING HYDRAULIC TANK

Make sure that the hydraulic oil level is


above the minimum mark (1) of the sight
glass.

DRILLING HYDRAULIC TANK

Make sure that the hydraulic oil level is


above the minimum mark (1) of the sight
glass.

1
2A

If needed fill up the tank to the maximum


mark using the hand pump (2A).
OR
If needed fill up the tank to the maximum
mark using the electric filling pump (2B).
Push button A to fill drilling hydraulic tank

2B

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

34 (92)

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS
COMPRESSOR

The clogging indicator (1) should be in


the green zone.
A clogging indicator in the red zone, calls
for filter element (2) replacement.

Check air inlet components, and inlet


hoses for loose clamps and cracks in hose.

3 - Air circuit pressure


--> must stay between 3 bar and 8 bar (while
running)

4 - Compressor oil temperature


--> (must stay under 100 c)

WARNING: Do not open the


oil filling plug if the receiver
is pressurized.
Oil
is
hot
when
the
compressor has just been
stopped. Wait 20 minutes
before doing any operation
on the compressor
First stop the compressor, and make sure
that the receiver is pressureless. Blow-out
the air circuit after stopping; then wait 15
minutes.

Remove the level dipstick and check the


oil level in the compressor.

4
OIL LEVEL

Remove the oil filling plug and add oil up


to the top mark of dipstick.
Screw the filling plug and the dipstick in
their place.

Oil drain

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

Start the air compressor again and stop it


after a few time, then repeat the previously
described operation to adjust the oil level.

35 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS
ROCK DRILL OILER

Read the gauge 1 and be sure there is no


pressure remaining in the air circuit.

Open slowly the hand valve 3 to drain the


condensed water.

Open the cap 2, This cap includes a


dipstick. Pull it up, check the rock drill
lubrication oil level.
Once a week, drain all remaining oil, fill
up with new rock drill oil.

AIR/WATER CLEANER

- Every shift , bleed the air cleaner 1 and IP5 (optional) 2


First stop the air compressor.
Open the bleeding valve to remove the condensed water.
Close the bleeding valve before starting the compressor.
SANDVIK TAMROCK SECOMA S.A.S
19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

36 (92)

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS
DRILL FEED AND BOOM
TF500
3

Ensure that the rock drill cradle (1) guide


shoes are correctly positioned and tightly
in place.
Ensure that the feed rails (2) are in good
condition and free of dirt which could
obstruct the drilling and bolting movements
(wash them if necessary).

There must be no missing or loose nuts


and screws.
3

TTF500
3

Check condition of pulleys and cable.

Check condition of centralizers (3).


Check all the hoses for fraying or wear.
NOTE: The hoses must be kept under the
protection of their spiral sheath.

B26 F

Check and grease all pins and pulleys.


NOTE: Do not grease the rails.

B26 NV

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

37 (92)

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS

WATER SUPPLY
1b

Check the water supply


2

1a Correct water supply connection.


OR
1b Correct water hose reel connection.
2 No leaks in water circuit components.
The mine water supply pressure must stay
between 3 bar and 14 bar.

NOTE: A lack of water or a loss of pressure


stops all drilling operations (percussion,
rotation and feed halted).
CAUTION: If the temperature in the storing
place of the machine is lower than the
freezing point, the water circuit and the water
scrubber must be protected or drained.

1a

WATER PUMP
The water pump must be drained before
each start and after each maintenance work
on the water circuit.
Use the drain ball valve for this operation.
NOTE: Read the water pump maintenance
manual for this operation if the drain ball
valve is not mounted on your machine.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

38 (92)

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS

3.3

ELECTRIC PANEL
ELECRIC CABINET
Includes 220 VAC and 24 VDC power
supply devices and the control circuits.

F251 Fault current circuit breaker for cabin


heater and sockets.
F291 Fault current circuit breaker for 3
phase socket.
F311 Fault current circuit breaker for
internal 220V control voltage in main
switchgear.
F312 Circuit breaker for internal 220V
control voltage in main switchgear.
F450 Circuit breaker for internal 24V
control voltage in main switchgear.
F451.1 Circuit breakers for control system
and instruments.
F452.1 Circuit breakers for working lights.
F453.1 Circuit breakers for cabin optional.
GAUGES:

F454.1 Circuit breakers for hydraulic oil


filling pump, multi-timer unot and carrier.

P400: Compressor hour meter


1P100: Rock Drill percussion hour meter
P410: Supply Voltage meter

F454.5 TMS (optional)


F10.1: Circuit breaker for battery charger
F10.2: General circuit breaker

FAULT CURRENT TEST


2

1
Once a month, check the connections
condition by doing a current fault test.
To do the test, push the current fault test
button 1 at the electric box, the F311 circuit
breaker 2 must trip.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

39 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS

3.4

TRAMMING COMPARTMENT

EMERGENCY STOP
PUSH BUTTON

EMERGENCY/PARK BRAKES
PUSH BUTTON

Tramming control panel


Cable reel, stabilizers,
canopy and diesel boom supply
Fire extinguisher actuator
(optional)
Cable reel electric control
Engine accelerator pedal

Service brake pedal

EMERGENCY/ PARKING BRAKES

Pull = Brake released


Ensure that the red button of the brake valve is
in the "BRAKE APPLIED" position.

Push = Brake applied


To activate the brakes, push the red button.
WARNING: Memorize the location of this brake
valve in order to be able to activate it rapidly in
case of emergency.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

40 (92)

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS

TRAMMING CONTROLS
3
Main components:

4
1. Tramming control panel.

2. Steering wheel.
3. Emergency stop button.
4. Stabilizers, canopy diesel boom supply
control valve.

5. Cable reel,

TRAMMING CONTROL PANEL


2
1. Engine starter.
2. Horn.

3. Tramming Indicator Panel (dash board).

4. Front/Rear tramming lights.


5. Forward / reverse tramming direction.

6
S TO P

6. Slow/ fast tramming speed selector switch.


7. Emergency stop button.

ON

ERGENCY
EM

START

8. Cable reel by pass security

STOP

9. Tramming pressure gauge

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

41 (92)

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS
CABLE REEL, STABILIZERS, CANOPY & DIESEL BOOM SUPPLY
1. Front Left jack.

2. Front Right jack.

2
3

3. Rear Left jack.


4. Rear Right jack
5. Telescopic canopy.
6. Supplies oil pressure to boom valve (for
maintenance use only while diesel engine is
running).
Push the levers to bring the stabilizers in contact
to the ground.
Pull the levers to retract the stabilizers in tramming position.
NOTE: retract the rear stabilizers first when tramming is needed.
Extend the front stabilizers first for parking and
drilling.

PUSH
PULL

7. Cable reel and water hose reel electric


control (optional)
Push left the lever to reel electric cable
Push right the lever to reel water hose reel
Push the lever to reel electric cable.

FOOT PEDALS
Pedal A: Diesel accelerator.
Pedal B: Service brake pedal.

A
NOTE: To stop the machine or to reduce the
speed in a decline, release first the accelerator
pedal and, if needed, push the service brake
pedal.

NOTE: Use pedal A and pedal B with the RIGHT


FOOT.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

42 (92)

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS

3.5

BOOM MOVEMENTS
B26 F

Divergence

Boom extension

Feed extension

Boom lift

Feed roll over


Feed tilt
Boom swing

Feed swing
Feed extension

B26 NV

Divergence

Feed tilt

Boom lift

Feed
roll over

Feed angle
Feed swing

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

Boom extension

Boom swing

43 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS

3.6

DRILLING COMPARTMENT
DRILLING COMPARTMENT

B: Boom controls.
D: Drilling controls.
P: Pressure adjustment knobs.
G: Pressure gauges.
S: Switches.
L: Air-oil lubrication sight glass.

W: Warning light: indicates a lack of


air or water pressure.
I: Indicator Light Panel

O
S

P
Emergency stop

O: Optional lever for boom


movement (B26 NV or LC) or rod
clamp

BOOM CONTROLS

LEVER

PUSH the lever: boom down.

PULL the lever: boom up.


RIGHT: boom swings to the right.

PUSH

LEFT: boom swings to the left.

LEFT

RIGHT
PULL

LEVER

PUSH the lever: boom extended.

2
PUSH
LEFT

RIGHT

PULL the lever: boom retracted.


RIGHT: feed roll-over rotates to the
right.
LEFT: feed roll-over rotates to the
left.

PULL

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

44 (92)

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS

LEVER

PUSH the lever: drill feed tilts


downward.

PULL the lever: drill feed tilts


upward.

RIGHT: drill feed swings to the


right.

PUSH
LEFT

RIGHT

LEFT: drill feed swings to the left.

PULL

LEVER

PUSH the lever: drill feed extension


forward.

PUSH
LEFT

RIGHT

PULL the lever: drill feed extension


backwards.
RIGHT: drill feed divergence
downward (boom B26F) or drill feed
angle to the right (boom B26NV).
LEFT: drill feed divergence upward
(boom B26F) or drill feed angle to
the left (boom B26NV).

PULL

LEVER

5 (OPTIONAL)

PUSH the lever: drill feed


divergence downward (boom
B26NV).

PULL the lever: drill feed


divergence upward (boom B26NV).

OR

PUSH

PUSH the lever:


close rod clamp

PULL

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

PULL the lever:


open rod clamp

45 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS
DRILLING CONTROLS

PUSH

LEVER

PUSH the lever: Reverse feed.

PULL

PULL the lever: Feed forward.

LEVER

PUSH

PUSH the lever: Manual percussion


(thread and drill bit loosening).

PULL

PULL the lever: Normal drilling


percussion.

PUSH

LEVER
PULL

PUSH the lever: Reverse rotation.


PULL the lever: Drilling rotation.

PUSH

LEVER

PUSH the lever: Fast reverse feed.

PULL

PULL the lever: Fast feed forward.

PUSH

LEVER
PULL

PUSH the lever: Air flushing

PULL the lever: Water flushing

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

46 (92)

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS

ADJUSTMENT KNOBS

STANDARD DRILLING CONTROL

B
A: Feed pressure control knob. Turn
clockwise to increase pressure, counter
clockwise to decrease pressure.

A
DRILLING CONTROL WITH OPTION

B: Rotation speed control knob. Turn


clockwise to increase RPM, counter
clockwise to decrease RPM.

A
B
PRESSURE GAUGES

B C D E

A: Air pressure gauge.


B: Water pressure Gauge
C: Rotation pressure gauge.
D: Percussion pressure gauge.
E: Feed pressure gauge.

AIR MIST (OPTIONAL)

A
B

A: Air mist sight glass


B: Turn flow controler to ajust water flow

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

47 (92)

AXERA 5 126-126NV
CHECKS AND INSTRUCTIONS
SWITCHES & JOYSTICK
A: Power pack on/off
E

- Ensure that all the control levers for the


hydraulic control valves, particularly the drilling
control levers, are in the Neutral Position
- Turn switch A in position 2,the power pack
starts.Then the switch automatically return to
position 1.Turn to left (position 0) power pack
stops

F
G

01 2 10 2

10 2

10 2

B: Automatic feed return control.


- Switch to the left (1):Manual feed return
using control levers, all 3 drilling levers free.
- Switch in central position (0): Automatic
feed return at the end of drilling operation, all 3
drilling joystick levers hold in full drilling position
- Switch in central position (2):While drilling if
there is an need for stopping the drilling process, it moves the rockdrill backward immediatly
and resets the 3 drilling levers to neutral. From
this position the switch return position 0 when is
not maintained.

EMERGENCY STOP
E: Joystick TRS (Optional)
PUSH Right: Swing up TRS
PUSH Left: Swing down TRS
PUSH Up: Close TRS
PUSH Down: Open TRS

C: Compressor
- Switch in central position (0) auto start with
power pack
- Switch to the right (2) power pack starts.
- Switch to the left (1) power pack stops.

F: Joystick Rod Clamp TRR1 (Optional)


PUSH Right: Open rod clamp
PUSH Left : Close rod clamp
G: Automatic central greasing (Optional)

D: Water Pump on/off

Additional lubrication cycles can de triggered at any


time.

- Switch in central position (0) auto start with


power pack
- Switch to the right (2) power pack starts.
- Switch to the left (1) power pack stops.

SIGHT GLASS

Air-oil drill lubrication sight glass

The rock drill shank is lubricated with oil


mixed in pressurized air.
While drilling, air/oil mix must flow
through the sight glass. If the glass seems
dry, stop drilling operation and check the
oiler (see page 35).
NOTE: A loss of air pressure stops all drilling operations (percussion, rotation and
feed halted).

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

48 (92)

AXERA 5 126-126NV
TRAMMING

TRAMMING

4.1

STARTING THE ENGINE


WARNING: Always make sure before starting the engine that there is no unauthorized
persons in the danger areas around the machine and that no controls are in operating
position.

WARNING

WARNING

WARNING: Sound the horn to warn any person of your intention to start and move the
machine.
Make sure that all covers and protective hoods and doors are installed and properly
closed

ELECTRIC SWITCHES

Turn the batteries master switch to the ON


position (See: paragraph 2.14 page 26).

3
2

Make sure the tramming direction switch 2 is in


the center in neutral position and rotate the
speed selector 6 to the left in low speed position
(turtle)
Turn the tramming light switches 3 to the right
Sound the horn 4 to inform everybody of your
intention to start the engine

CAUTION

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

Turn key 1 to start diesel engine


Do not run the starter longer than
10 seconds at a time. Wait the
starter to cool down before new
starting attempt (10 seconds).

7849 3697-N-16-02-2006 SR-RB-FL

49 (92)

AXERA 5 126-126NV
TRAMMING
ELECTRIC PANEL

DISPLAY

Upper default display is fuel level, when carrier key switch S2 is turned
on.
Upper default display become diesel rpm reading when diesel is running.
Lower default display is diesel hours, when carrier key switch S2 is
turned on.

UPPER BUTTONS

When you push top line button you have on upper display that reading.
When you push top line button over 2 seconds there is again diesel rpm
reading.
Alarm came always on top and also button indicator light is then on.

LOWER BUTTONS
2. Engine coolant temperature.
The temperature should be under under 100 C. Indicator light
and display blinks and buzzer is
on if temperature is over113 C.
3. Fuel level. The indicator light
and display blinks if level is too
low.

When you push lower line button you have on lower display that reading.
Alarm came always on top and also button indicator light is then on.

ALL BUTTON
All button indicator light have indicator light test.
When carrier key switch S2 is turned on all button indicator light flash.

4. Engine oil pressure. Normal


pressure is over 1 bar. Indicator
light and display blinks and
buzzler is on if pressure is below
0,7 bar.
5. Voltmeter. The indicator light
and display blinks and buzzer is
on if voltage is under 20VDC.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

50 (92)

AXERA 5 126-126NV
TRAMMING
WARNING LIGHTS

H21

1. Service brake. The indicator light is on if front or rear


brake pressure is below 100
bar.
2. Park brake.
Indicator light is on if brake
pressure is below 5 bar.

H150

H19

3. Preheating indicator.
The engine can be started
when the indicator lights up. If
the engine is already warm,
preheating is not necessary.

H4

4. Charging.
The indicator lights up if the
alternator is not operational.
Switch off the engine and look
for the cause.

H18

5. Transmission oil tank level.


Indicator light is on if oil tank
level is too low.

1
2

6. Air filterIndicator light is on


if filter is clogged (optional).
H23

H7

7. Low engine coolant level.


Indicator light is on if coolant
level is too low.

8. Blinker (option). Indicator


light blink if left or right blinker
is on.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

51 (92)

AXERA 5 126-126NV
TRAMMING
TRAMMING CHARGE PRESSURE GAUGE

Let the engine in idle position and check the


tramming charge pressure gauge 1, it must show
a minimum of 12 bar.

4.2

EMERGENCY/PARKING BRAKE TEST


BRAKE TEST
2

Raise the machine on stabilizers, no contact


between tyres and ground.
Install a 600 bar gauge at the tramming test
point (1) to verify there is no problem on the
tramming circuit (Caution, high pressure).

3
4

Apply the parking brake by depressing the


emergency button (2).
Select one tramming direction and accelerate
slowly => The tramming pressure must increase
to 400 bar and no wheel must turn.
WARNING: USE ONLY 0-600 bar GAUGE
DUE TO THE HIGH PRESSURE.
WARNING: if the wheels turn, do not use
the machine and inform a responsible
person immediately.

Service brake test :


Raise the machine on stabilizers, no contact between tyres and ground.
Select one tramming direction and accelerate to put the wheels in rotation. Release the
accelerating pedal (3) and push on the braking pedal (4).
=> Wheel must rapidly stop turning.
In case that the brakes are faulty, do not use the machine and refit it.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

52 (92)

AXERA 5 126-126NV
TRAMMING

4.3

ELECTRIC CABLE
CABLE REEL CONTROL
CABLE REEL CONTROL

Position the cable reel control lever in the neutral


position N.
Ensure that the power supply from the mine
electric box to the machine is OFF.
Plug the cable into the mine electric box.
Secure the cable on the support provided by the
mine.

A
N

Tram to the face to be drilled.

Push button (1) to reel the cable


Push button (2) to unreel the cable

EMERGENCY
STOP

Warning : During the cable


unreeling , check the tension of
this one manually so that the
cable is tight and don't stick
himself inside of the carrier. If
the
cable
tension
of
is
inadequate , it can be damaged .

WARNING: Never use an electric cable unless it is firmly positioned on its support.
this will prevent unnecessary tension on the cable which may result in the plug
being pulled from its socket.
The cable must never be live before the machine is ready to drill and the cable
itself has been placed in its support and support hooks.
NEVER HANDLE A LIVE CABLE.
Never move the machine if the cable is live.
To ensure that no vehicle will drive over the cable, lay the cable in hooks which
have been placed in the sidewall along the length of the gallery being drilled.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

53 (92)

AXERA 5 126-126NV
TRAMMING

4.4

MOVING THE MACHINE


FORWARD / BACKWARD

2
Always refer to the maximum gradient angle
(See: paragraph 2.5 page 19).

Make sure the boom is in tramming


position(See: paragraph 2.6 page 20).
Retract the stabilizers (rear first then front).
Pull up the brake valve to release the brakes
Select the direction you want by turning the
switch 2 to the left to move forward, to the right to
move backward.
Press or Depress on the accelerator pedal A.
The speed depends on the Diesel engine RPM.

WARNING: sound the horn to warn


people before moving the machine.

WHERE USING LOW SPEED RANGE?

Turn the tramming speed selector 1 to the right


in low speed range (turtle symbol) in incline,
decline, in busy or crowded areas and in working
areas.
Drive slowly around corners, sound the horn
and warn people in areas you cannot see.
Observe mine speed limit regulation.

HOW TO STOP THE MACHINE?

B
In normal tramming conditions to stop the
machine you must:
Release the accelerator pedal the machine (will
reduce speed).
Slowly push with the right foot on the service
brake pedal B.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

54 (92)

AXERA 5 126-126NV
TRAMMING
EMERGENCY STOPPING

(O)

In case of emergency, push the red button (O) to


activate the emergency brake.

4.5

PARKING THE MACHINE

To park the machine safely, select an area clear of personnel and a location where the machine will not
obstruct passage of other equipment.
Bring the machine to a full stop. Release the accelerator pedal and press on tramming control pedal.
Apply the emergency/parking brakes.
Position the two (2) rear stabilizing jacks and the two (2) front jacks firmly on the ground. The distance
between the wheels and the ground must not be more than 7 mm (1/2").
The machine must be turned into a bank or rib to prevent it from running away. Place a stop block on
the wheels when parking a gradient.
Allow the diesel engine to idle several minutes to allow critical components to cool gradually.
Stop the engine by pressing the "OFF" button.
Turn the battery master switch to the "OFF" position.
WARNING: NEVER LEAVE THE MACHINE WHILE THE ENGINE IS RUNNING.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

55 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
DRILLING

DRILLING

5.1

SETTING-UP THE MACHINE IN THE DRIFT

Place the machine lengthways of the drift at an equal distance from the sidewalls.

For optimum stability, and perfectly parallel holes, the chassis must be on line with the gallery being
drilled.
Stop the machine so that the distance between the machine and the face to be drilled = the length of
the drill feed + 300 mm (1 foot).
This position will allow the drill feed to access the lifters which are directly aligned with the machine

Drill feed overall length


Position of
the lifter

Mini. clearance
Front of the
chassis

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

56 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
DRILLING

Place the stabilizers firmly on the ground, do not over lift the chassis for optimum stability.
When placing the stabilizers, pay attention that nobody is close to them.

Optimum stability

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

57 (92)

AXERA 5 126-126NV
DRILLING

5.2

ELECTRIC POWER

Check following points before switching the mine circuit-breaker ON.


Machine correctly installed
Water hose connected
Air hose connected (optional)
Electric cable carefully positioned along the sidewall

MACHINE CIRCUIT BREAKER


ON

RESET

OFF

NOTE: To be able to use the machine circuitbreaker you should turn first the battery master
switch ON (See: paragraph 2.14 page 26).
Rotate then the main circuit-breaker in position
ON.
After using of the emergency stop button the
main circuit breaker will be placed automatically
in TRIP position.
To reset the power to the machine
- Rotate the lever fully to RESET position.
- Then rotate clockwise in ON position.
NOTE: Do not use the emergency stop button in
normal process to stop any of the power pack,
use dedicated stop button.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

58 (92)

AXERA 5 126-126NV
DRILLING
INDICATOR LIGHT PANEL

H608

Overload of powerpack motor for boom 1 and 2. The indicator light


goes on if the motors protective switch (F100) is triggered or, if the
thermal protector alarms (motor temperature over 155 C). The protective
switch must be reset by turning its control switch first to 0 position
and then to 1 position. The thermistor protector is reset automatically as
the motor temperature drops. The indicator light goes on also if the
magnetic triggering of the protective switch comes activated when the
powerpack is started.

Powerpack of boom 1 and 2 running.

Compressor running.

Water booster pump running.

Highpressure water pump running (Optional).

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

59 (92)

AXERA 5 126-126NV
DRILLING

H608

Low water pressure. If the water pressure stays below 2.8 bar for longer
than 4 seconds (default setting), the pressure monitoring system stops drilling
and stops the water pump. The indicator light remains lit and it can be
turned off by pressing the bypass/acknowledgement button S505. After that,
water pump has to be started manually with switch S501.
Compressed air too hot. If the temperature of the output air from the compressor rises too high, the powerpack, the compressor, and the water
pumps stop and the indicator light goes on. The indicator light goes off automaticallyas the compressor cools down.
Compressor motor overloaded. The indicator light goes on and the powerpack,the compressor and the water pumps stop when the compressors protective switch F240 is triggered. The protective switch must be reset
manually. Turn the main switch to the 0 position before resetting the protective switch.
Water booster pump motor overloaded. The indicator light goes on and the
powerpack, the compressor and the water pumps stop when the water
pumps protective switch F230 is triggered. The protective switch must be
reset manually. Turn the main switch to the 0 position before resetting theprotective switch.
Low air pressure. If air pressure stays below 2.8 bar for longer than 10 secH609 onds (default setting), the pressure monitoring system stops drilling. The
indicatorlight remains lit and it can be turned off by pressing the reset/
acknowledgementbutton S505.
Highpressure water pump motor overloaded. The indicator light goes on
and the powerpack, the compressor, and the water pumps stop when the
highpressure water pumps protective switch F280 is triggered. The protectiveswitch must be reset manually (Optional equipment).

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

60 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
DRILLING

H608

Low oil level of hydraulic oil receiver or shank lubrication device. If the oil
level drops below the allowed minimum, the powerpack, the compressor
and the water pump stop and indicator light goes on. The level monitoring
system has a 3second time delay for preventing false alarms if the oil level
momentarily drops too low, for instance, when the rig rocks. The indicator
light goes off when a sufficient amount of oil is added.If the indicator light
blinks, the oil level in the shank lubrication is low.
Return filter clogged. When the indicator light goes on, the one of return filter
has come so dirty that it must be replaced. The filter monitoring device
does not stop drilling functions. When the oil is cold (below 30 C),
the monitoring system is bypassed to avoid alarms caused by thick oil.
Hydraulic oil too hot. If the temperature of the hydraulic oil rises over 75 C
the powerpack, the compressor and the water pumps stop and the indicator
light goes on. The indicator light goes off automatically when the oil temperature has dropped sufficiently.
Clogged pressure filter of powerpack for boom 1 and 2. When the indicator
light goes on, the pressure filter has come so dirty that it must be replaced.
The filter monitoring device does not stop drilling functions. When the oil is
cold (below 30 C), the monitoring system is bypassed to avoid alarms
caused by thick oil.
Emergencystopped. When any of the emergency stop buttons of the rig is
depressed the indicator light goes on, all motors stop and diesel stops. By
releasing the button(s), the indicator light can be turned off, but the motors
must be restarted separately.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

61 (92)

AXERA 5 126-126NV
DRILLING

H608

Incorrect phase sequence. When the main switch is turned ON, the relay
K120 checks the 3phase current for correct direction of rotation.
If the directionof rotation, i.e. the phase sequence, is incorrect, the indicator
light goes on and the motors are prevented from starting.

Overload of airconditioning compressor motor. The indicator light goes on


and the compressor stops when the protector switch F260 is triggered.
The switch must be reset manually (Optional equipment).

Electric current switched ON. The indicator light goes on when the main
switch is turned ON.
Electric motor of airconditioning compressor running (Optional).

External pump running (Optional).

Earth fault current (Optional).

External pump overflow. The indicator light goes on and the powerpack, the
compressor and the water pumps stop when the protector switch F290 is
triggered. The switch must be reset manually (Optional).

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

62 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
DRILLING
HYDRAULIC POWER PACK START UP
Ensure that all the control levers for the hydraulic
control valves, particularly the drilling control levers,
are in the NEUTRAL POSITION.

01 2

Turn the switch A to the right (1) power pack is


under tension, turn to the right (2) power pack starts
and automatically return to position 1. Turn to the left
(0) power pack stops.
CAUTION: Wait several seconds before
using any one of the control lever.

CAUTION

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

63 (92)

AXERA 5 126-126NV
DRILLING

5.3

PARALLELISM SETTING
INITIAL POSITION SETTING

The front frame of the machine should be levelled and in the axis of drilling direction.
Boom position:
Use the boom lift lever to bring the boom in horizontal position.
Use the boom swing lever to line up the boom with the front carrier axis.
Drill feed position:
Use the roll-over lever to bring the drill feed support cradle to the position shown below.
Use the feed swing and the drill feed tilt lever to line up the roll over axis with the front carrier axis.
Use the divergency lever to bring the drill feed to the horizontal position
NOTE: The boom is now set. If the last 3 movements are not used, the drill feed will remain in the
parallel drilling mode.
NOTE: For overall improved rigidity of the boom, it is recommended to use the boom extension when
approaching the drill feed to the face instead of the feed extension cylinder.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

64 (92)

AXERA 5 126-126NV
DRILLING

HOW TO REDUCE THE DEAD ANGLE?

B26 F

BOOM EXTENSION RETRACTED - DRILL FEED EXTENDED

Stinger

BOOM EXTENSION EXTENDED - DRILL FEED RETRACTED

BOOM EXTENSION EXTENDED - DRILL FEED RETRACTED

B26 NV

BOOM EXTENSION RETRACTED - DRILL FEED EXTENDED

BOOM EXTENSION EXTENDED - DRILL FEED RETRACTED

A dead angle zone, when the rear section of the drill feed interferes with the boom, can occur when
drilling the blast hole (burn cut).
Extend the feed extension movement cylinder to near maximum capacity.
Position the drill feed near the zone to be drilled, by using the boom extension, swing and lift
movements.
Anchor the stinger with the remaining feed extension travel.
NOTE: it is the only position where drilling is recommended using the feed extension fully extended.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
DRILLING

5.4

Setting drill feed TTF and TFX


1. Open the ball valves (1) and (2) fully.
2. Feed the rock drill forward until the whole system is as short as possible (refer to
Figure 2 Maximum and minimum length).
3. Close the ball valve (2) fully.
4. Feed the rock drill backward until it is facing the rear stopper.
5. Run the rock drill backward against the rear stopper for about 10 seconds.
6. Close the ball valve (1) fully.
7. Check that both ball valves (1) and (2) are fully closed. (Also see the shield on the
next page).

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

65 (92)

66 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
DRILLING

Setting TFX 500 to different lengths


by using an instruction as a
reminder.
For setting the length to minimum, follow
the steps (1 to 5) which are described on
the plates upper picture.
For setting the length to intermediate or
maximum, follow all the steps (1 to 11)
which are described on the plate.
The steps are read from left to right and
top to bottom.
STEPS:
1. Open the ball valves (1) and (2)
2. Feed the rock drill forward until the
whole system has the shortest
position.
3. Close the ball valve (2) fully.
4. Feed the rock drill until it is facing
the rear stopper for approximately
10 seconds.
5. Close the ball valves (1) and (2)
6. Open the ball valves (1) and (2).
7. Run the feeds inner tube into
desired length by running the rock
drill against the rear stopper.
8. Close the ball valve (2).
9. Feed the rock drill against the rear
stopper for approximately 10
seconds.
10. Close the ball valve (1) fully.
11. Open the ball valve (2) fully.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

20960108

7849 3697-N-16-02-2006 SR-RB-FL

67 (92)

AXERA 5 126-126NV
DRILLING

5.5

COLLARING A HOLE
DRILL FEED POSITIONING

Using lever 1 and 2 move the drill feed in the


position you need to drill a hole.
Push the lever 4 to bring the drill feed stinger in
firm contact with the rock.

4
Pull percussion lever 2 fully
For smooth collaring pull slowly rotation lever 3
and feed lever 1. Keep the levers 3 and 1 in the
position where the movements have started.
Let the bit penetrated the face until it reaches
solid rock.

PUSH

5.6

1 2

3
PULL

When the bit has reached solid rock, collaring process is achieved. Full drilling power can be used.

NORMAL DRILLING
DRILLING OPERATION

Pull levers 1, 2, 3 fully.

1 2 3

PUSH

PULL

NOTE: All levers will be maintained in full power position


during all drilling process.
If the switch B is placed in center position (0) the percussion
will stop automatically at the end of the feed travel and the
feed movement will be reverse in backward direction.
The reverse motion will stop automatically when the rock
drill reaches the end of the drill feed rear point.

Turn the switch B to the right position (2) to stop the drilling
process. All drilling levers 1, 2 and 3 will move back to neutral,
NOTE: Use the emergency stop button only in case of
emergency. In normal process use dedicated button to stop
any operation.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

68 (92)

AXERA 5 126-126NV
DRILLING
DRILLING ADJUSTMENT
While drilling the operator can adjust the rotation speed
(RPM) as well as the feed pressure.
NOTE: Always adjust both rotation and feed at the best level
acceptable according to your ground condition.
Rotation over-speed will result in a faster wear of the bit carbide inserts, mainly in abrasive rock.
Under-feeding will result in rapid wear of the rod, shank and
coupling threads. A smoking coupling indicates under feeding, increase the feed pressure when the coupling smokes.

Over-feeding will result in an increase in the rotation pressure which indicates an over-torque. That reduces the life
time of the rotation mechanism of the rock drill.

While drilling keep the rotation pressure to an average value


of 50 bar.
A: Feed pressure control knob. Turn clockwise to
increase pressure, counter clockwise to decrease
pressure.
B: Rotation speed control knob. Turn clockwise to
increase RPM, counter clockwise to decrease RPM.

DRILLING IMPERATIVES

CLEARANCE ANGLE

The following rules guarantee optimum drilling performance,


resulting in high productivity at low operating costs.
The bit:
A correct clearance angle and proper water pressure, evacuate the cutting as soon as they have been broken from the
face.
Drilling with a worn bit results in an increase in rotation
torque and loss of penetration rate.
To increase productivity a worn bit should be replaced with a
new or re-sharpened one.
Drill steel and shank adaptor
These tools are essential to productive drilling.
They transmit percussion and rotation energy to the bit if
kept correctly on line.
Correct alignment allows optimal energy transmission,
reduced wear of the drill steel against the guide shoes, perfect hole alignment, minimum drill steel torsion, and prevents premature breaking of the shanks and drill steels.
NOTE: Often control the guiding elements, the shank and
the flushing head and report immediately noticed anomalies
on every parts of the drill feed and rock drill.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

69 (92)

AXERA 5 126-126NV
DRILLING

5.7

ROD UNCOUPLING

Recommended procedure for uncoupling the bit or the shank adaptor.


Anchor the drill feed and then open the water circuit.
DO NOT USE THE ROTATION.
Using the Feed Lever, advance the rockdrill.
Move the Feed Lever to the "MAXIMUM feed" position. This allows the full percussion energy to be
activated for a better breaking capability.

5.8

ENDING A SHIFT

When you stop the drilling process at the end of the shift or for any other reason, carry on following
operations:
Tilt the front end of the drill feed downward, the stinger in contact to the ground.
Stop all powerpack.
Close the water supply valve at the mine line.
As to prevent the alternator to be damaged, stop the diesel engine prior to turn the battery master
switch to the "OFF" position.
Place the main circuit breaker to the "OFF" position.
Shut OFF the power at the mine electric box.
Wash the machine mainly the drill feed and the boom.
Fill-up the shift report form.
Report any defects that you have noticed.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

70 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
TRANSPORTATION

TRANSPORTATION

6.1

TRANSPORTATION ON A PLATFORM
WARNING: Before driving the machine onto a transport platform, move the
boom and the feed to the tramming position. never exceed the maximum side
and slope limitation.
While moving the machine NEVER SWING THE BOOM.
When driving the machine onto a transport platform, use ramps. this should always be
done on level ground.
Always use low speed and observe special caution when coming from the ramps to
the platform.
WARNING: Install the locking bar at the central articulation before moving the
platform.
Lower all stabilizers against the platform floor.
Move the boom as low as possible and fasten it to platform.
Fasten the machine chassis to the platform using proper straps or chains.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

71 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
TRANSPORTATION

6.2

TOWING THE MACHINE

DANGER

WARNING:THE MAXIMUM TOWING SPEED MUST BE 1 KM/H. This to prevent the


tramming component to be damaged and operator affect at drilling compartment.
THE USE OF CABLE OR CHAIN IS STRICTLY FORBIDEN. While towing, one
operator should be at the tramming compartment ready to apply the brake in a case
of emergency or operate the steering valve to allow the steering cylinder to move.

If it is necessary to tow the machine, comply


to the following procedure:
Ensure that the power supply from the
mine electric box to the machine is OFF.
Unplug the cable into the mine electric box.
Connect up the towing machine to the
towed machine with a RIGID BAR. Hook
the bar at the towing points located at the
rear of the machine (see the figure below).
CAUTION: Never try to tow the machine if
the multi-function HP valves, located on the
tramming pump (see figures below) are
tightened. The maximum towing distance
allowed is 1/2 km, over this distance the
hydraulic motor(s) could be damaged due
to lack in internal lubrication.

Towing point

RIGID TOWING BAR

Optional unbraking hand pump at tramming compartment

Untight the both valves and turn them four


revolutions counter-clockwise, to by-pass
the oil flow. The tramming motor can now turn without resistance.
Unscrew
multi-function HP valves
Unscrew

valve in towing position


Release the emergency/park brake valve by pulling, fully upward, the red knob.
Close the ball valve of the unbraking hand-pump.
WARNING: This ball valve must be always open in normal use of the machine. If not, the park
brake may not work, dont forget to reopen the ball valve after towing the machine.
SANDVIK TAMROCK SECOMA S.A.S
19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

72 (92)

AXERA 5 126-126NV
TRANSPORTATION
Use the unbraking hand pump to pressurize the brake cylinders. The pressure build up by the hand
pump is sufficient to release the brakes.

NOTE: The brake valve is always functionning. To apply the brakes push downward the red knob, as
you do in normal conditions.

WARNING: Never try to tow a machine which presents problems on tramming


components

WARNING: The valves should be retighten as soon as the towing process as been
completed. NEVER START THE ENGINE THE HP VALVES UNTIGHTEN IN

DANGER

DANGER

6.3

TOWING POSITION.

LIFTING THE MACHINE

LIFTING FRAME

LIFTING POINT

WARNING

WARNING

LIFTING POINT

WARNING

WARNING: Always respect the law and all the local safety regulations in lifting work.
Keep in mind the total weight of the rig, given in the technical data pages at the
end of this manual.
Move the boom and the drill feed to the tramming position (See: paragraph 2.6
page 20).
Install the locking bar at the central articulation. Install 4 hooks and chains or
cables at the front and rear lifting points.
WARNING: Do not stand under the machine during lifting process. Use proper lifting
devices as hooks, cables or chains for a safe work.
Use a lifting frame to maintain all 4 four chains or cables perfectly vertical and
parallel each other.
SANDVIK TAMROCK SECOMA S.A.S
19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

73 (92)

AXERA 5 126-126NV
TRANSPORTATION

The lifting device used must be of the correct type and have sufficient lifting capacity.
The rig or parts of it must not be lifted with any devices that are not specifically designed for lifting
purposes.
You must always know the exact weight of the load, and never exceed the lifting capacity specified by the
manufacturer of the lifting device.
Lifting routes should be planned so that the load is not moved over persons or such places where persons
may be present.
Make sure that the lifting equipment is in proper condition Wire ropes and chains used for lifting must be
checked regularly. Damaged wire ropes must be marked clearly and discarded at once.
Lift the load only a few centimetres at first to make sure that it is properly fastened and in balance. Do not
continue lifting until you are sure of proper fastening and balance.
The lifting wire ropes must be fastened according to the manufacturers instructions.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

74 (92)

AXERA 5 126-126NV
TRANSPORTATION

6.4

STORING THE MACHINE

The storing place temperature should be higher than the freezing point, and protected against direct
sunlight and rain.
CAUTION: If the temperature in the storing place of the machine is lower than the freezing point, the
water circuit, all the water components and the water scrubber must be protected or drained.
Wash the machine if it has been used or transported by sea using a high pressure steam washing
machine.
Drain and blow air through the water circuit. Blow some anti-freeze (rust inhibitor) through the circuit.
Lubricate all greasing points.
Bring the stabilizers in contact to the ground.
The drill feed stinger should be in contact to the ground.
The nitrogen rockdrill accumulator should be empty, PLACE A TAG TO REMIND THAT THE
ACCUMULATORS HAVE BEEN DISCHARGED.
Coat the cylinder rod with grease.
Drain the air reservoir(s).
Replace all fluids: engine, hydraulic axle and gear oil.
Spray a dust and corrosion inhibitor product on all electric devices.
As to prevent the alternator to be damaged, stop the engine prior to turn the battery master switch to
the "OFF" position.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

75 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
TECHNICAL DATA

TECHNICAL DATA
Technical Specification
6-232 S-A

AXERA 5-126

2004-05-14

APPLICATION

MAIN SPECIFICATIONS

The Tamrock Axera 5-126 is a single boom electro


hydraulic jumbo for mine development and tunneling in
cross sections up to 38 m.

Carrier
Safety canopy
Rock drill
Feed
Boom
Control system
Powerpack
Shank lubrication device
Air compressor
Water pump
Main switch
Cable reel
Length
Width
Height
Weight
Tramming speed
- Horizontal
- 14% = 1:7 = 8
Gradeability, max
Noise level

The robust universal boom have a large optimum


shaped coverage, 360 rotation and full automatic
parallelism for fast and easy face drilling. The boom can
also be used for cross-cutting and bolt-hole drilling.
The jumbo layout is designed for good visibility and
balance, this and the powerful four-wheel-drive
articulated carrier ensure fast and safe manoeuvering in
narrow drifts.
The high performance drilling system allows high drilling
performance with good drill steel economy and high
machine reliability.
The operator environment and added automatic
functions allow the operator to concentrate on safe, fast
and accurate drilling.
All the service points are well protected but easy to
access.

1 x TC 5
1 x FOPS / ROPS
1 x HLX5
1 x TF 500
1 x B 26 F
1 x THC 560
1 x HP 560 (55 kW)
1 x KVL 10-1
1 x CT 10
1 x WBP 1
1 x MSE 05
1 x TCR 1
10 855 mm
1 750 mm
2 100 / 3 100mm
12 000 kg
12 kph
5 kph
35 %
< 98 dB(A)

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

76 (92)

AXERA 5 126-126NV
TECHNICAL DATA

Technical Specification
6-232 S-A

AXERA 5-126

2004-05-14

GENERAL DIMENSIONS

3100

1980
1675

1600

160
2510

1500

1500

Overall Length
TF 500 x 10
TF 500 x 12
TF 500 x 14
TF 500 x 16

6350

10
11
11
12

855
180
195
250

All dimensions in mm

HLX5 ROCK DRILL

B 26 F BOOM

Weight
Length
Profile height
Power class
Max working pressure

Type
Weight (with hoses)
Feed roll-over
Boom extension
Feed extension

210 kg
955 mm
87 mm
20 kW
- Percussion
225 bar
- Rotation
175 bar
Max torque (80 ccm motor)
400 Nm
Hole size
43 - 64 mm
Recommended steel
T38- H35-R32
T38-H35-alpha 330
T38-R39-R35
Shank adapter
7304-7585-01 (T38)
Flushing water pressure
10 - 20 bar

Cylinder - wire rope


25 kN

TF 500

500x10 500x12

Total length (mm)

500x14

500x16

4660

5270

5880

6490

Drill steel length (mm)

3090

3700

4305

4915

Hole depth (mm)

2830

3440

4050

4660

Net weight (kg)

470

500

530

560

Parallel holding
1 900 kg
360
1 200 mm
1 600 mm

THC 560 CONTROL SYSTEM


Power control
Rotation control
Automatic functions

TF 500 FEED
Feed type
Feed force

(Technical specification 4-200 S)

Boom controls

Adjustable full power


Adjustable collaring power
Adjustable rotation speed
Reversible rotation
Collaring
Feed controlled percussion
Anti-jamming
Flushing
Stop-and-return
Fully proportional

HP 560 POWER PACK


Electrical motor

1 x 55 kW (75 hp)
3-phase motor

Pump types
- Percussion, feed & boom
Axial piston,
1 x 130 l/min variable displacement
- Rotation
1 x 60 l/min gear pump
Filtration
- Pressure
1 x 20 micron
- Return
1 x 10 micron
Hydraulic tank volume
180 liters

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

77 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
TECHNICAL DATA

Technical Specification
6-232 S-A

AXERA 5-126

2004-05-14

TRAMMING DIMENSIONS

2100
Overall Length
TF 500 x 10
TF 500 x 12
TF 500 x 14
TF 500 x 16

10
11
11
12

855
180
195
250

320

15

3000

2510
6350

TURNING RADIUS

CS
R2
R1
40
5550

TF
TF
TF
TF

500
500
500
500

x
x
x
x

10
12
14
16

R1
3260
3260
3260
3260

R2
5655
5800
5945
6070

CS
3290
3435
3580
3705

All dimensions in mm

CARRIER

WATER CIRCUIT

Model
TC 5
Diesel engine
Deutz BF4L 2011, 55 kW (74hp)
- Exhaust
Catalyser
Automotive hydrostatic transmission
Transfer case
Drop gear Clark-Hurth
Axles, Front & Rear
Case New Holland D45
- Oscillation
Rear axle, 2 x 10
- Tyres
12.00 x 20
Steering
Frame steering, 2 x 40
Brakes
- Service Hydrostatic transmission+positive braking
- Emergency & parking
Hydraulic oil immersed
multiple disc brakes on both axles
Stabilizers
2 hydraulic jacks, front
2 hydraulic jacks, rear
Safety canopy
Hydraulic, FOPS-ROPS
- Lowering capability
1 000 mm
Fuel tank
80 liters
Hydraulic tank
55 liters

Water booster pump


Centrifugal type
- Capacity
2000 l/h at 15 bar
- Electric motor
4 kW (5.5 hp)
Oil cooler
OW 30, water-actuated counterflow
- Cooling capacity
30 kW

AIR CIRCUIT

FULL DIESEL VERSION OPTIONAL

Compressor
- Capacity
Electric motor
Shank lubrication device
- Air consumption
- Oil consumption

C.T. 10, screw type


1.0 m/min at 7 bar
7.5 kW (10 hp)
1 x KVL 10-1
250-350 l/min
180-250 g/h

ELECTRICAL SYSTEM
Total installed power
Main switch
Voltage
Frequency
Starting method
Cable reel
- Capacity

73 kW
1 x MSE 05
380 - 660 V
50 or 60 Hz
Direct start
TCR 1 type
100 m of cable 32 mm O.D

Lighting
- Working lights
- Tramming lights

4 x 70 W, 24 V
4 x 70 W, 24 V

(the 2 front lights are also used as working lights)

Water-cooled engine
Deutz BF4M 2012
- Max. rating at 2300 rpm
93 kW (125 hp)
Fuel tank capacity
240 liters
Compressor & water pump driven by hydraulic motors
Total machine weight
10 500 kg

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

78 (92)

AXERA 5 126-126NV
TECHNICAL DATA

Technical Specification
6-232 S-A

AXERA 5-126

2004-05-14

COVERAGE AREA

Extra coverage with manual override


Auto-parallel coverage

5890

5190

Axera 5-126 on jacks.


All dimensions in mm.

1750
5510
6490

OPTIONAL EQUIPMENT
DRILLING SYSTEM

CARRIER

*) Telescopic feed TTF 500 series.


*) Rod retainer TRR 1.
*) B 26 NV boom.
Drill angle measuring instrument TMS D1.
Air flushing on rock drill return.
*) SLU 1 shank lubricating device.
*) Double flushing (air/water) with CT 10 compressor.
*) Air mist flushing kit for auxiliary water/air connection.
*) Full Diesel version available.

Fume diluter.
Complete spare wheel.
*) 4 Michelin X mine D2 instead of standard types.
Hand pump for manual brake release.

ELECTRICAL SYSTEM
*) 1 000 V electric power supply.
Ground fault detector
- not applicable to 1 000 V
Electric cable (Technical specifications 5-506 S and 5-507 S)
- 380-460 V, 4 x 35 mm, 36 mm, 80 m length
- 480-575 V, 4 x 25 mm, 32 mm, 100 m length
- 660-690 V, 4 x 25 mm, 32 mm, 100 m length
*) Allen Bradley electrics.
*) Star-Delta electric starting method.
*) 2 x 35 W High Intensity Discharge (HID) working lights.

OTHER OPTIONAL EQUIPMENT


Fire suppression system ANSUL, 6 nozzles.
*) EU, UL, CSA, AUS norms package + local standards and
regulations.
*) Electric oil filling pump.
Automatic lubrication system (Lincoln) for both boom and carrier.
Central lubrication system.
Hook up for mine air network (IP5 air cleaner included).
Manuals other than French/English language.

*) replaces standard component

www tamrock sandvik com


SANDVIK TAMROCK SECOMA S.A.S
19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

79 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
TECHNICAL DATA

Technical Specification
4-200 S-C

B 26 F Boom

2003-10-21

Boom Swing
Boom Extension
Divergence

Feed Swing

Feed Extension

Boom Lift

(main)

Feed Swing
(slave)

Feed Tilt

Feed Roll-over
Ensure horizontal //
Ensure vertical //

APPLICATION

DESCRIPTION

B 26 F boom is designed for Tamrock Axera D05, Axera


D06 and Axera LP jumbos.

The x-y coordinated boom movements together with


360 actuator roll-over make the use of the boom simple
and logical. Accurate automatic parallel holding both in
vertical and horizontal plane improves the drilling
performance and accuracy.

B 26 F boom is a hydraulic universal roll-over boom for


mechanized tunnelling, drifting, cross-cutting and bolthole drilling in medium sections. It can also be used for
production drilling with cut-and-fill and room-and-pillar
methods.
This parallel holding telescopic boom offer large true
rectangular face coverage area.

Large dimensioned rectangular profile,adjustable and


sealed boom extension wear-pieces, large diameter
bearings, sealed main joints, expanding pins in cylinder
joints and use of super strong cast pieces in most
stressed areas are some of the features that are
included to the boom design for improved reliability.

TECHNICAL DATA
Coverage with parallelism holding
Coverage with manual override
Weight, without hoses
Weight allowed
Boom telescopic extension
Boom lift, up and down
Boom swing, symmetric
Feed tilt, up and down
Feed swing, symmetric
Divergence, up and down
Feed extension
Feed roll-over

29,2 m
38,9 m
1 850 kg
1 050 kg
1 200 mm
45 and 16
45
25 and 50
50
3 and 90
1 600 mm
360
/
SANDVIK TAMROCK SECOMA S.A.S
19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

80 (92)

AXERA 5 126-126NV
TECHNICAL DATA

Technical Specification
4-200 S-C

B 26 F Boom

2003-10-21

COVERAGE AREA

6000

5300

1870

5510
6490

GENERAL DIMENSIONS

1253

2600

3
45

1600

90

356

360
572

16
25

50

1200

50

50

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

31
(45)

26
(45)

81 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
TECHNICAL DATA

Technical Specification
4-501 S-C

B 26 NV Boom

2003-10-21

Boom Swing
Boom Extension

Feed Roll-over

Feed Extension

Boom Lift

Feed Swing
(main)

Feed Swing
(slave)

Feed Tilt
Divergence
Feed Angle

Ensure horizontal //
Ensure vertical //

APPLICATION

DESCRIPTION

B 26 NV boom is designed for Tamrock Axera D05 and


Axera D06 jumbos.

The x-y coordinated boom movements together with


double rotation device allows a vertical positioning of the
feed on both side of the boom and the possibility to drill
extremely close to the hanging and foot walls, both to
the right and left, with the rock drill always in the
operators sight line. Accurate automatic parallel holding
both in vertical and horizontal plane improves the drilling
performance and accuracy.

B 26 NV boom is a multi-purpose hydraulic boom for


mechanized tunnelling, drifting, cross-cutting and bolthole drilling in medium sections. It can also be used for
production drilling with cut-and-fill and room-and-pillar
methods.
This parallel holding telescopic boom offer large true
rectangular face coverage area.

TECHNICAL DATA
Coverage with parallelism holding
Coverage with manual override
Weight, without hoses
Weight allowed
Boom telescopic extension
Boom lift, up and down
Boom swing, symmetric
Feed tilt, up and down
Feed swing, symmetric
Divergence, up and down
Feed extension
Feed roll-over
Feed angle

29,2 m
38,9 m
1 900 kg
850 kg
1 200 mm
45 and 16
45
25 and 50
50
20 and 90
1 400 mm
360
95

Large dimensioned rectangular profile,adjustable and


sealed boom extension wear-pieces, large diameter
bearings, sealed main joints, expanding pins in cylinder
joints and use of super strong cast pieces in most
stressed areas are some of the features that are
included to the boom design for improved reliability.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

82 (92)

AXERA 5 126-126NV
TECHNICAL DATA

Technical Specification
4-501 S-C

B 26 NV Boom

2003-10-21

COVERAGE AREA

3410

1870
5970
5270

1200

6250
1870
3630
5655
5500
6480

GENERAL DIMENSIONS

1030

1400

2600

20
360

90
95

45

16
25 50

1200

95

50

95

50

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

31
(45)

26
(45)

572

83 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
TECHNICAL DATA

& 

7)  )(('









7) 

7RWDO OHQJWK PP

+ROH OHQJWK PP

5RG OHQJWK PP

1HW :HLJKW NJ

[

 

 

 



[

 

 

 



[

 

 

 



[

 

 

 



[

 

 

 



;

 

 

 



SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

84 (92)

AXERA 5 126-126NV
TECHNICAL DATA

7)  +<'5$8/,& &</,1'(5 )(('


$SSOLFDWLRQ
7)  IHHGV DUH VWDQGDUG RQ 7DPURFN 6XSHUGULOOLQJ MXPERV ZLWK +/  6XSHU URFN GULOO DQG 3RZHU
&ODVV MXPERV ZLWK WKH +/  7 URFN GULOO

'HVFULSWLRQ
7KH 7) IHHGV DUH PDGH IURP KHDY\ GXW\ H[WUXGHG VSHFLDO DOXPLQLXP DOOR\ SURILOH %R[ VKDSHG ERW
WRP SDUW RI WKH SURILOH JLYHV KLJK UHVLVWDQFH DJDLQVW EHQGLQJ DQG WRUVLRQ 6WDLQOHVV VWHHO VWULSV SUR
YLGH JRRG JXLGDQFH DQG GXUDELOLW\ DJDLQVW ZHDULQJ RQ DOO VOLGLQJ VXUIDFHV
7KH FDUULDJHV IRU URFN GULOO WUDYHOOLQJ FHQWUDOL]HU DQG KRVH UHHO KDYH DGMXVWDEOH YVKDSHG VSHFLDO
SODVWLF ZHDU SLHFHV ZKLFK DUH IDVWHQHG ZLWK EROWV
7KH GULOO URG FHQWUDOL]HUV DUH HTXLSSHG ZLWK KDUGHQHG VWHHO ZHDU SLHFHV DQG DUH GHVLJQHG IRU RSWL
PXP YLVLELOLW\ DQG GXUDELOLW\
7KH KRVH VXSSRUW LV D WZR VLGHG FODPS WKDW DOORZV HDV\ LQGLYLGXDO WHQVLRQLQJ RI HDFK KRVH

&RPSRQHQWV
 )HHG UDLO
 )HHG DVVHPEO\
 IHHG F\OLQGHU
 IHHG ZLUH URSHV
 5RFN GULOO FDUULDJH
 3ODVWLF KRVH UHHO
 +RVH VXSSRUW
 ,PSXOVH F\OLQGHUV IRU VWRSDQGUHWXUQ DXWRPDWLFV
 )URQW GULOO URG FHQWUDOL]HU DQG EXIIHU
 7UDYHOOLQJ FHQWUDOL]HU
 :LUH URSH WHQVLRQLQJ DVVHPEO\

2SWLRQDO HTXLSPHQW
755  K\GUDXOLF GULOO URG UHWDLQHU IRU H[WHQVLRQ GULOOLQJ
1RWH 5HGXFH KROH GHSWK  PP
,QWHUQDO KRVLQJ
$VVHPEO\ NLW IRU 7% DQG =58 ERRPV ZLWKRXW IHHG H[WHQVLRQ F\OLQGHU
&HQWUDOL]HU ZHDU SLHFHV
)URQW FHQWUDOL]HU
7UDYHOOLQJ FHQWUDOL]HU

7HFKQLFDO GDWD
0D[ IHHG IRUFH
)UHH VSHHG

 N1EDU
 PV

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

85 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
TECHNICAL DATA

77)  7(/(6&23,&


&</,1'(5 )(('

$





7RWDO OHQJWK

77) 









7RWDO OHQJWK PP









)HHG WUDYHO PP









1HW :HLJKW NJ









:LWK RSWLRQDO
755
URG OHQJWKV IW

  

  

  

  

PD[  URG IW



:LWK IROORZLQJ
7%ERRPV

 

   

  


 

    
 

5HTXLUHV D VSHFLDO FUDGOH


:KLOH GULOOLQJ IORRU KROHV WKH ERRP ]RRP F\OLQGHU KDV WR EH H[WHQGHG RXW

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

86 (92)

AXERA 5 126-126NV
TECHNICAL DATA

77)  7(/(6&23,& &</,1'(5 )(('


$SSOLFDWLRQ
77)  WHOHVFRSLF IHHGV DUH GHVLJQHG IRU 7DPURFN 3RZHU &ODVV DQG 6XSHUGULOOLQJ MXPERV ZLWK +/
 7 DQG +/  6XSHU URFN GULOOV $ YHUVDWLOH IHHG IRU IDFH GULOOLQJ EROW KROH GULOOLQJ DQG FURVVFXW
WLQJV LQ D OLPLWHG VSDFH ZKHUH ERWK ORQJ DQG VKRUW URGV KDYH WR EH XVHG

'HVFULSWLRQ
7KH GHVLJQ RI WKH IHHG DLPV DW VLPSOLFLW\ RI VWUXFWXUH DQG HDVH RI PDLQWHQDQFH 7KH IHHG LV
FRQVWUXFWHG VR WKDW ZKHQ LW LV LQ PLQLPXP OHQJWK VKRUW KROHV FDQ EH GULOOHG DQG ZKLOH LQ PD[LPXP
OHQJWK ORQJ KROHV FDQ EH GULOOHG 7KH H[WHQVLRQ RI IHHG LV VWHSOHVV EHWZHHQ PLQLPXP DQG PD[LPXP
'XULQJ WKH GULOOLQJ WKH IURQW FHQWUDOL]HU  EXIIHU LV SXVKHG WR WKH URFN E\ IHHG H[WHQVLRQ F\OLQGHU ZKLFK
LV PRXQWHG WR WKH IURQW FHQWUDOL]HU DQG ERRP FUDGOH 7KH IHHG EHDP PRYHV RQ WKH ERRP FUDGOH E\
DQRWKHU K\GUDXOLF F\OLQGHU
7KH EHDP RI 77)  LV PDGH RI VWHHO SURILOH ZLWK VOLGLQJ VXUIDFHV IDFHG ZLWK VWDLQOHVV VWHHO VWULSV
7KH FDUULDJH RI WKH URFN GULOO KRVH UHHO DQG LGOLQJ ZKHHO FDUULDJH PRYH DORQJ WKH IHHG EHDP RQ VLPL
ODU DGMXVWDEOH YVKDSHG VOLGH SLHFHV
7KH GULOO URG FHQWUDOL]HUV DUH HTXLSSHG ZLWK KDUGHQHG VWHHO ZHDU SLHFHV DQG DUH GHVLJQHG IRU RSWL
PXP YLVLELOLW\ DQG GXUDELOLW\

0DLQ FRPSRQHQWV









)HHG UDLO ZLWK H[WHQGLEOH LQQHU WXEH


)HHG DVV\ ZLWK IHHG F\OLQGHUV DQG ZLUH URSHV
5RFN GULOO FDUULDJH
3ODVWLF KRVH UHHO
+RVH VXSSRUW
,PSXOVH F\OLQGHUV
'ULOO URG FHQWUDOL]HUV  SFV DQG D EXIIHU
:LUH URSH WHQVLRQLQJ DVVHPEO\

2SWLRQDO HTXLSPHQW
+\GUDXOLF GULOO URG UHWDLQHU 755  IRU H[WHQVLRQ GULOOLQJ WR EH PRXQWHG LQVWHDG RI PLGGOH FHQWUDOL]HU

7HFKQLFDO GDWD
0D[ IHHG IRUFH
)UHH VSHHG

 N1
 PV

1RWH 1R KROH GHSWK PHDVXUHPHQW LQ 7&$'  706 ZLWK 77)

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

87 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
TECHNICAL DATA

Technical Specification
3-1600
2005-02-15

TFX 500 TELESCOPIC CYLINDER FEED

1
2

7
6

11

10

12

APPLICATION

MAIN COMPONENTS

TFX 500 telescopic feeds are designed for Tamrock


face drilling jumbos with HLX5 series rock drills. A
versatile feed for face drilling, bolt hole drilling and
cross-cuttings in a limited space where both long and
short rods have to be used.

1. Hose reel
2. Feed cylinder
3. Impulse cylinders for stop-and-return
automatics
4. Hose support
5. Travelling centralizer
6. Feed wire ropes and rope tensioning
assembly
7. Feed beam
8. Lower feed cylinder
9. Bracket for feed extension cylinder
10. Lower feed beam
11. Front drill rod centralizer
12. Buffer

DESCRIPTION
The design of the feeds aims at simplicity of structure and ease of maintenance. The TFX feed consists of TF feed and TFX extension kit.
When the TFX 500 feed is in minimum length, short
holes can be drilled and while in maximum length,
long holes can be drilled. The extension of feed can
be adjusted stepless between minimum and maximum.
During drilling the buffer is pushed to the rock by
feed extension cylinder. The TF feed beam moves
on the lower beam by lower feed cylinder.
The beams are made of special aluminum profile
with sliding surfaces faced with stainless steel strips.
The drill rod centralizers are equipped with hardened
steel wear pieces and are designed for optimum
visibility and durability.

OPTIONAL EQUIPMENT
TRR 1 hydraulic drill rod retainer for extension drilling
Internal hosing
Connections parts for boom
Connections parts for rock drill
Centralizer wear pieces of different sizes

TECHNICAL DATA
Max feed force
Free speed

25 kN
0.5 m/s

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

88 (92)

AXERA 5 126-126NV
TECHNICAL DATA

Technical Specification
3-1600
2005-02-15

TFX 500 TELESCOPIC CYLINDER FEED

DIMENSIONS

Total length min / max

* The TFX feed doesnt include the rock drill

TFX 500

6/12

8/14

10/16

Total length (mm)

3480 / 5310

4090 / 5920

4700 / 6530

Feed travel (mm)

1610 / 3440

2220 / 4050

2830 / 4660

636

673

710

6, 8, 10, 12

6, 8, 10, 12

6, 8, 10, 12

With following TB booms

40, 60, 90, 120, 150

40, 60, 90, 120, 150

60, 90, 120, 150

With following B26 booms

F, XLF, NV, XLNV

F, XLF, NV, XLNV

F, XLF, NV, XLNV

Net Weight (kg)


With optional TRR1 rod retainer:
- 1. rod length (ft)

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

89 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
TECHNICAL DATA

HYDRAULIC ROCK DRILL


HLX5

2-1852
2003-06-04

1/2

1100
955

145

153

240

87

295

HYDRAULIC ROCK DRILL HLX5


Application
The HLX5 hydraulic rock drill is designed for tunneling and mine development drilling with Tamrock Axera jumbos. It
is also suitable for bolt hole, exploration and injection hole drilling.

Description
The HLX5 is a hydraulic percussive rock drill with independent reversible rotation and low profile height.

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

90 (92)

AXERA 5 126-126NV
TECHNICAL DATA

Technical data
Drill steels

R 39 or Hex 35 mm drifter rods,


MF-rods highly recommended
45 / T 38

Shank
Hole diameter
Tunneling
Cut hole drilling
Weight
Length
Profile height

43...64 mm
76...127 mm
210 kg
955 mm
87 mm

Percussion mechanism
Operating pressure
Percussion rate
Impact energy
Flow (at 220 bar)

120220 bar
67 Hz
320 Joule
97 l/min

Accumulator
Accumulator gas
High pressure (HP)
Low pressure (LP)
Filling valve

Nitrogen N2
50 bar
4 bar
Vg8 DIN 7756

Rotation mechanism
Motor
Motor type
Flow (at max. speed)
Pressure max.
Torque (at 175 bar)
Rotation speed

Orbit type
OMS 80
46 l/min
175 bar
400 Nm
0250 rpm

Flushing
Water flow (with one rod)
Water pressure
Shank lubrication
Air flow (at 6 bar)
Pressure
Oil consumption
Working temperature (water flushing)
Ambient temperature
Oil operating temperature
Hose fittings size
Percussion
Rotation
Lubrication
Flushing
Oil recommended

OMS 125
72 l/min
175 bar
625 Nm
0250 rpm

60 l/min (15 bar)


10...20 bar
250...350 Nl/min
4...7 bar
180...250 g/h

see SLU instructions

+0 ...+40 C
+40...+60 C
JIC 1 1/16 - 12
JIC 3/4 - 16
JIC 3/4 - 16
JIC 3/4 - 16
see a separate specification

Options
Special tools for HLX5, ID 55006507

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

OMS 160
74 l/min
175 bar
780 Nm
0200 rpm

91 (92)

7849 3697-N-16-02-2006 SR-RB-FL

AXERA 5 126-126NV
TECHNICAL DATA

04051-1

HYDRAULIC ROCK
DRILL HL 510

2004-09-28

1/2

197

1024

206

76

HL 510-38
HL 510-45

294

Application
The HL 510 hydraulic rock drill is designed for bench drilling with 32-45 mm (1 " - 1 ") diameter drill steels. It is
used on CHA 550, Dino 500 and Ranger 500 hydraulic crawler drills in drilling of 51-89 mm (2" - 3 ") diameter
blastholes in construction worksites, quarries and open pit mines.

Description
The HL 510 is a hydraulic percussive rock drill with independent reversible rotation and low profile height.
The HL 510 is equipped with separate flushing.

Drill steels
The HL 510 rock drill uses the following extension drill steels
Drill steel type
Diameter
mm
in
Rods
32
1
38
1
45
1
Shank adapters

Hole diameter range


mm
in
51-64
2-2
64-89
2-3
76-89
3-3

38mm: R32, R38, T38, lenght 550 mm


45mm: R32, T38, T45, lenght 550 mm

( HL 510-38 )
( HL 510-45 )

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

7849 3697-N-16-02-2006 SR-RB-FL

92 (92)

AXERA 5 126-126NV
TECHNICAL DATA

Technical data
Weight
Length
Height
Width
Number of side bolts

130 kg
1 024 mm
206 mm
294 mm
4 pcs

Percussion mechanism
Operating pressure
Percussion rate
Kinetic power
Percussion oil flow (170 bar)
High pressure accumulators
Accumulator pressure
Low pressure accumulators
Accumulator pressure
Accumulator gas

100-170 bar
59 Hz
15.5 kW
100 l/min
1 pc
50 bar
1 pc
4 bar
Nitrogen N2

Rotation mechanism
Rotation principle / motor type
Rotation rate
Rotation motor type
Max. torque (210 bar)
Rotation flow
Flushing housing

Fittings
Percussion
Rotation
Flushing
Shank lubrication

independent, orbit type


0-250 rpm
OMSU 80
OMSU 125
470 Nm
750 Nm
40 l/min/220 rpm
43 l/min/150 rpm
38 mm
38 mm
45 mm
45 mm

JIC 1 1/16 - 12
JIC 3/4 - 16
JIC 1 1/16 - 12
JIC 3/4 - 16

Options
Special tools for HL 510, field kit ID 880 817 19
Special tools for HL 510, complete ID 152 257 68

SANDVIK TAMROCK SECOMA S.A.S


19 avenue De Lattre-de-Tassigny - ZI
B.P. 46 - 69881 MEYZIEU Cedex
Tel : (33) 472 45 22 00 Fax : (33) 478 31 79 80

OMSU 200
945 Nm
55 l/min/150 rpm
38 mm
45 mm

Vous aimerez peut-être aussi