Académique Documents
Professionnel Documents
Culture Documents
SECTION
AV
CONTENTS
SERVICE INFORMATION ............................ 2
PRECAUTIONS ................................................... 2
Precaution for Supplemental Restraint System
(SRS) "AIR BAG" and "SEAT BELT PRE-TENSIONER" ................................................................... 2
PREPARATION ................................................... 3
Commercial Service Tool .......................................... 3
AUDIO ................................................................. 4
Component Parts Location ........................................ 4
System Description ................................................... 4
Schematic ................................................................. 6
Wiring Diagram - AUDIO - ......................................... 8
Audio Unit (Base System) Harness Connector
Terminal Layout ...................................................... 16
Terminal and Reference Value for Audio Unit
(Base System) ......................................................... 16
Audio Unit (Mid Level and Premium System) Harness Connector Terminal Layout ............................ 17
Terminal and Reference Value for Audio Unit (Mid
Level and Premium System) ................................... 17
Subwoofer Harness Connector Terminal Layout
(Premium Audio System) ........................................ 20
Terminal and Reference Value for Subwoofer
(Premium Audio System) ........................................ 20
Satellite Radio Tuner Harness Connector Terminal Layout ................................................................ 20
Terminal and Reference Value for Satellite Radio
Tuner ....................................................................... 21
Trouble Diagnosis ................................................... 21
Noise Inspection ...................................................... 22
Power Supply Circuit Inspection ............................. 23
Satellite Radio Tuner (Factory Installed) Power
and Ground Supply Circuit Inspection ..................... 24
Satellite Radio Tuner (Factory Installed) Communication Circuit Inspection ....................................... 25
Satellite Radio Tuner (Factory Installed) Left
Channel Audio Signal Circuit Inspection ................. 27
AV
TELEPHONE ..................................................... 44
AV-1
2009 Versa
PRECAUTIONS
< SERVICE INFORMATION >
SERVICE INFORMATION
PRECAUTIONS
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT
PRE-TENSIONER"
INFOID:0000000004778188
The Supplemental Restraint System such as AIR BAG and SEAT BELT PRE-TENSIONER, used along
with a front seat belt, helps to reduce the risk or severity of injury to the driver and front passenger for certain
types of collision. This system includes seat belt switch inputs and dual stage front air bag modules. The SRS
system uses the seat belt switches to determine the front air bag deployment, and may only deploy one front
air bag, depending on the severity of a collision and whether the front occupants are belted or unbelted.
Information necessary to service the system safely is included in the SRS and SB section of this Service Manual.
WARNING:
To avoid rendering the SRS inoperative, which could increase the risk of personal injury or death in
the event of a collision which would result in air bag inflation, all maintenance must be performed by
an authorized NISSAN/INFINITI dealer.
Improper maintenance, including incorrect removal and installation of the SRS can lead to personal
injury caused by unintentional activation of the system. For removal of Spiral Cable and Air Bag
Module, see the SRS section.
Do not use electrical test equipment on any circuit related to the SRS unless instructed to in this
Service Manual. SRS wiring harnesses can be identified by yellow and/or orange harnesses or harness connectors.
AV-2
2009 Versa
PREPARATION
< SERVICE INFORMATION >
PREPARATION
INFOID:0000000004306953
Tool name
Description
Power tool
D
PBIC0191E
AV
AV-3
2009 Versa
AUDIO
< SERVICE INFORMATION >
AUDIO
Component Parts Location
INFOID:0000000004306954
WKIA5999E
1.
2.
4.
7.
3.
6.
Subwoofer B29 (premium system)
[view with luggage side lower finisher (LH) removed]
System Description
INFOID:0000000004306955
BASE SYSTEM
Refer to Owner's Manual for audio system operating instructions.
Power is supplied at all times
through 20A fuse (No. 27, located in the fuse and fusible link box)
to audio unit terminal 19.
With the ignition switch in the ACC or ON position, power is supplied
through 10A fuse (No. 20, located in the fuse and fusible link box)
to audio unit terminal 7.
Ground is supplied through the case of the audio unit.
Then audio signals are supplied
through audio unit terminals 2, 3, 4, 5, 11, 12, 13 and 14
to terminals + and - of front door speaker LH and RH and
to terminals + and - of rear door speaker LH and RH.
AV-4
2009 Versa
AUDIO
< SERVICE INFORMATION >
to audio unit terminal 21 (with premium system)
through body grounds M57 and M61 and
to subwoofer terminal 3 (with premium system)
through body grounds B7 and B19.
Then audio signals are supplied
through audio unit terminals 2, 3, 4, 5, 11, 12, 13, and 14
to terminals + and - of front door speaker LH and RH and
to terminals + and - of tweeter LH and RH and
to terminals + and - of rear door speaker LH and RH and
to terminals 2 and 6 of subwoofer (with premium system).
AV
AV-5
2009 Versa
AUDIO
< SERVICE INFORMATION >
Schematic
INFOID:0000000004306956
AANWA0065GB
AV-6
2009 Versa
AUDIO
< SERVICE INFORMATION >
PREMIUM SYSTEM
A
AV
O
AANWA0064GB
AV-7
2009 Versa
AUDIO
< SERVICE INFORMATION >
INFOID:0000000004306957
BASE SYSTEM
AANWA0039GB
AV-8
2009 Versa
AUDIO
< SERVICE INFORMATION >
MID LEVEL SYSTEM
A
AV
O
AANWA0040GB
AV-9
2009 Versa
AUDIO
< SERVICE INFORMATION >
WKWA4981E
AV-10
2009 Versa
AUDIO
< SERVICE INFORMATION >
PREMIUM SYSTEM
A
AV
O
AANWA0041GB
AV-11
2009 Versa
AUDIO
< SERVICE INFORMATION >
AANWA0057GB
AV-12
2009 Versa
AUDIO
< SERVICE INFORMATION >
A
AV
O
AANWA0066GB
AV-13
2009 Versa
AUDIO
< SERVICE INFORMATION >
AANWA0063GB
AV-14
2009 Versa
AUDIO
< SERVICE INFORMATION >
A
AV
O
AANWA0058GB
AV-15
2009 Versa
AUDIO
< SERVICE INFORMATION >
INFOID:0000000004306958
WKIA5439E
2 (W)
3 (BR)
Item
Signal
input/
output
Output
Condition
Ignition
switch
ON
Operation
INFOID:0000000004306959
Reference value
(Approx.)
SKIB3609E
4 (V)
5 (R)
Output
ON
SKIB3609E
7 (LG)
Ground
11 (G)
12 (SB)
Input
ACC
Output
ON
Battery voltage
SKIB3609E
13 (LG)
14 (GR)
Output
ON
SKIB3609E
19 (BR)
Ground
Input
OFF
AV-16
Battery voltage
2009 Versa
AUDIO
< SERVICE INFORMATION >
Audio Unit (Mid Level and Premium System) Harness Connector Terminal Layout
INFOID:0000000004306960
WKIA5440E
Terminal and Reference Value for Audio Unit (Mid Level and Premium System)
INFOID:0000000004306961
Terminal
(Wire color)
+
Item
Signal
input/
output
Condition
Ignition
switch
Operation
Reference value
(Approx.)
Example of symptom
2 (W)
3 (BR)
Audio sound
signal front
LH
Output
ON
No sound from
front door speaker
LH or tweeter LH.
Receive audio
signal
SKIA0177E
4 (V)
5 (R)
Audio sound
signal rear
LH
Output
ON
No sound from
rear door speaker
LH or subwoofer
LH.
Receive audio
signal
AV
SKIA0177E
6 (L)*2
7 (LG)
11 (G)
Ground
Ground
12 (SB)
Remote
control A
ACC signal
Audio sound
signal front
RH
Input
Input
Output
ON
ON
ON
Press Phone/
End switch
0V
Press SEEK UP
switch
1.7V
Press VOL UP
switch
3.3V
Except for
above
5.0V
Ignition switch
ACC or ON
L
Steering wheel audio controls do not
function
Battery voltage
No sound from
front door speaker
RH or tweeter RH.
Receive audio
signal
SKIA0177E
AV-17
2009 Versa
AUDIO
< SERVICE INFORMATION >
Terminal
(Wire color)
+
13 (LG)
Item
14 (GR)
Audio sound
signal rear
RH
Signal
input/
output
Output
Condition
Ignition
switch
ON
Operation
Reference value
(Approx.)
Example of symptom
No sound from
rear door speaker
RH or subwoofer
RH.
Receive audio
signal
SKIA0177E
15 (B)*2
16 (P)*2
18 (SB)
Ground
Ground
Remote
control
ground
Remote
control B
Vehicle
speed signal
(8pulse)
Input
Input
Input
ON
ON
Press Phone/
Send switch
0V
Press SEEK
DOWN switch
1.7V
Press VOL
DOWN switch
3.3V
Except for
above
5.0V
When vehicle
speed is approx.
40 km/h (25
MPH)
Speed sensitive
volume is inoperative.
PKIC0643E
19 (BR)
Ground
Battery power
21 (B)*2
Ground
22*1
26 (R)*1
24 (G)
28
(BR)*1
27 (O)*2
31
(LG)*2
Input
Battery voltage
EQ selection
ON
Wrong EQ will
cause sub woofer
to be inoperative
Shield
Input
Audio signal
Ground
Subwoofer
amp. ON
signal
Output
ON
12V
Bluetooth
ON
ON
Mute inoperative
ACC/
ON
33 (V)*2
Audio out
Output
Output
SKIB3609E
35*2
Shield
AV-18
2009 Versa
AUDIO
< SERVICE INFORMATION >
Terminal
(Wire color)
+
Item
Signal
input/
output
Condition
Ignition
switch
Operation
Reference value
(Approx.)
Example of symptom
42 (R)
41 (G)
Audio left
channel
sound signal
from satellite radio
tuner
Input
ON
Receive audio
signal
SKIA0177E
44 (B)
43 (W)
Audio right
channel
sound signal
from satellite radio
tuner
Input
ON
Receive audio
signal
F
SKIA0177E
45
Shield
ground (audio signal)
46
Shield
ground (data)
0V
Ground
Input
ON
5V
48 (B)
0V
J
49 (L)
Ground
Audio RX
Input
ON
Operate audio
volume
SKIA4403E
50 (Y)
Ground
Audio TX
Output
ON
L
Satellite radio tuner audio information does not
display properly.
Operate audio
volume
AV
N
SKIA4402E
AV-19
2009 Versa
AUDIO
< SERVICE INFORMATION >
INFOID:0000000004306962
WKIA5441E
Item
Signal
input/
output
Condition
Ignition
switch
Operation
1 (R)
Ground
Intput
OFF
2 (O/L)
6 (W/L)
Intput
ON
INFOID:0000000004306963
Reference value
(Approx.)
Battery voltage
SKIB3609E
3 (B)
Ground
Ground
4 (LG)
Ground
Subwoofer amp. ON
signal
Shield
ON
0V
Input
ON
Battery voltage
INFOID:0000000004306964
LKIA0735E
AV-20
2009 Versa
AUDIO
< SERVICE INFORMATION >
Item
Signal
input/
output
Condition
Ignition
switch
Operation
INFOID:0000000004306965
Voltage
(Approx.)
22 (R)
21 (G)
Audio signal LH
Output
ON
SKIB3609E
F
24 (B)
23 (W)
Audio signal RH
Output
ON
G
SKIB3609E
25
Shield
26
Data ground
Ground
REQ1
(SAT-AUDIO)
ON
0V
I
28 (B)
Output
ON
J
SKIB3825E
AV
29 (R/L)
Ground
Communication signal
(SAT-AUDIO)
Output
ON
SKIB3824E
30 (R/W)
Ground
Communication signal
(AUDIO-SAT)
Input
ON
O
SKIB3826E
32 (R)
36 (L)
37
Ground
OFF
Input
ACC
Trouble Diagnosis
Battery voltage
INFOID:0000000004306966
NOTE:
The subwoofer (premium system) may be inoperative if the audio unit harness connectors have not been connected in the proper sequence (when the battery remains connected). The proper sequence is to connect M44
Revision: October 2008
AV-21
2009 Versa
AUDIO
< SERVICE INFORMATION >
and M45 first followed by M43 last. If the subwoofer is inoperative, be sure to check this condition. Refer to AV35, "Sound Is Not Heard from Subwoofer (Premium System)" .
The majority of the audio malfunctions are the result of outside causes (damaged CD, electromagnetic interference, etc.). Check the symptoms below to diagnose the malfunction.
The vehicle itself can be a source of noise if noise prevention parts or electrical equipment is malfunctioning.
Check if noise is caused and/or changed by engine speed, ignition switch turned to each position, and operation of each piece of electrical equipment, and then determine the cause.
Symptom
Check item
Open or short in audio signal circuit between audio unit and front
speaker. Refer to AV-30, "Sound Is Not Heard from Front Door
Speaker (Base System)" or AV-32, "Sound Is Not Heard from
Front Door Speaker or Tweeter (Mid Level and Premium System)" .
Front speaker. Refer to AV-30, "Sound Is Not Heard from Front
Door Speaker (Base System)" or AV-32, "Sound Is Not Heard
from Front Door Speaker or Tweeter (Mid Level and Premium
System)" .
Open or short in audio signal circuit between audio unit and rear
speaker. Refer to AV-31, "Sound Is Not Heard from Rear Door
Speaker (Base System)" or AV-33, "Sound Is Not Heard from
Rear Door Speaker (Mid Level and Premium System)" .
Rear speaker. Refer to AV-31, "Sound Is Not Heard from Rear
Door Speaker (Base System)" or AV-33, "Sound Is Not Heard
from Rear Door Speaker (Mid Level and Premium System)" .
Tweeter (mid level and premium system) AV-32, "Sound Is Not
Heard from Front Door Speaker or Tweeter (Mid Level and Premium System)" or AV-33, "Sound Is Not Heard from Rear Door
Speaker (Mid Level and Premium System)" .
Subwoofer (premium system). Refer to AV-35, "Sound Is Not
Heard from Subwoofer (Premium System)" .
Audio unit. Refer to AV-23, "Power Supply Circuit Inspection" .
NOTE:
Noise resulting from variations in field strength, such as fading noise and multi-path noise, or external noise
from trains and other sources. It is not a malfunction.
Fading noise: This noise occurs because of variations in the field strength in a narrow range due to mountains or buildings blocking the signal.
Multi-path noise: This noise results from the waves sent directly from the broadcast station arriving at the
antenna at a different time from the waves that reflect off of mountains or buildings.
Noise Inspection
INFOID:0000000004306967
The vehicle itself can be a source of noise if noise prevention parts or electrical equipment is malfunctioning.
Check if noise is caused and/or changed by engine speed, ignition switch turned to each position, and operation of each piece of electrical equipment, and determine the cause.
NOTE:
The source of the noise can be found easily by listening to the noise while removing the fuses of electrical
components, one by one.
AV-22
2009 Versa
AUDIO
< SERVICE INFORMATION >
Occurrence condition
Possible cause
Ignition components
Generator
A cracking or snapping sound occurs while the vehicle is being driven, especially when
it is vibrating excessively.
INFOID:0000000004306968
1.CHECK FUSE
Check that the following fuses of the subwoofer (premium system) and audio unit are not blown.
Unit
Terminals
Audio unit
Subwoofer (with premium audio)
Signal name
Fuse No.
19
Battery power
27
20
27
OK or NG
OK
>> GO TO 2.
NG
>> If fuse is blown, be sure to eliminate cause of blown fuse before installing new fuse. Refer to PG3.
AV
Terminal No.
Unit
(+)
Connector
Audio unit
Terminal
(-)
OFF
ACC
ON
19
Ground
Battery
voltage
Battery
voltage
Battery
voltage
Ground
0V
Battery
voltage
Battery
voltage
M43
OK or NG
OK
>> With premium system, GO TO 3.
NG
>> Check connector housings for disconnected or loose
terminals.
Repair harness or connector.
N
WKIA5345E
AV-23
2009 Versa
AUDIO
< SERVICE INFORMATION >
2. Check voltage between subwoofer (premium system) and
ground.
Terminal No.
Unit
Subwoofer
(+)
Connector
Terminal
B29
(-)
Ground
OFF
ACC
ON
0V
Battery
voltage
Battery
voltage
OK or NG
OK
>> GO TO 4.
NG
>> Check connector housings for disconnected or loose
terminals.
Repair harness or connector.
WKIA5442E
Satellite Radio Tuner (Factory Installed) Power and Ground Supply Circuit Inspection
INFOID:0000000004306969
1.CHECK FUSES
Check that the following fuses are not blown.
Unit
Terminals
Signal name
Fuse No.
32
Battery power
27
36
20
OK or NG
OK
>> GO TO 2.
NG
>> If fuse is blown, be sure to eliminate cause of blown fuse before installing new fuse. Refer to PG3.
1.
2.
3.
(+)
Connector
Satellite
radio tuner
(factory installed)
Terminal
(-)
OFF
ACC
ON
32
Ground
Battery
voltage
Battery
voltage
Battery
voltage
36
Ground
0V
Battery
voltage
Battery
voltage
B30
OK or NG
OK
>> GO TO 3.
Revision: October 2008
WKIA4539E
AV-24
2009 Versa
AUDIO
< SERVICE INFORMATION >
NG
>> Check connector housings for disconnected or loose terminals.
Repair harness or connector.
C
Terminals
Satellite radio tuner
Connector
A: B30
Terminal
25
26
Audio unit
Connector
B: M45
Continuity
Terminal
45
Yes
46
OK or NG
OK
>> Inspection End.
NG
>> Check connector housings for disconnected or loose
terminals.
Repair harness, connector or satellite radio tuner (factory installed) case ground.
WKIA4540E
INFOID:0000000004306970
1.CHECK HARNESS - 1
1.
2.
3.
WKIA4541E
2.CHECK HARNESS - 2
1.
OK or NG
OK
>> GO TO 3.
NG
>> Repair harness or connector.
WKIA4542E
3.CHECK HARNESS - 3
AV-25
2009 Versa
AUDIO
< SERVICE INFORMATION >
1. Check continuity between satellite radio tuner (factory installed)
harness connector B30 (A) terminal 30 and audio unit harness
connector M45 (B) terminal 50
Continuity should exist.
2.
OK or NG
OK
>> GO TO 4.
NG
>> Repair harness or connector.
WKIA4543E
Connect satellite radio tuner (factory installed) connector and audio unit connector.
Turn ignition switch to ACC
Check signal between satellite radio tuner (factory installed) harness connector B30 terminal 28 and ground with CONSULT-llI
or oscilloscope.
28 - Ground
OK or NG
OK
>> GO TO 5.
NG
>> Replace audio unit. Refer to AV-37, "Removal and
Installation" .
WKIA4544E
OK or NG
OK
>> GO TO 6.
NG
>> Replace audio unit. Refer to AV-37, "Removal and
Installation" .
WKIA4545E
OK or NG
OK
>> Replace satellite radio tuner. Refer to AV-37, "Removal
and Installation" .
NG
>> Replace audio unit. Refer to AV-37, "Removal and
Installation" .
AV-26
WKIA4546E
2009 Versa
AUDIO
< SERVICE INFORMATION >
Satellite Radio Tuner (Factory Installed) Left Channel Audio Signal Circuit Inspection
INFOID:0000000004306971
1.CHECK HARNESS
1.
2.
3.
C
Terminals
Satellite radio tuner
Connector
Terminal
Connector
21
A: B30
4.
Audio unit
Continuity
41
B: M45
22
Terminal
Yes
42
Terminals
Satellite radio tuner
Connector
A: B30
Continuity
Terminal
21
Ground
22
No
OK or NG
OK
>> GO TO 2.
NG
>> Repair harness or connector.
1.
2.
3.
AV
OK or NG
OK
>> Replace audio unit. Refer to AV-37, "Removal and
Installation" .
NG
>> Replace satellite radio tuner. Refer to AV-37, "Removal
and Installation" .
M
WKIA4548E
Satellite Radio Tuner (Factory Installed) Right Channel Audio Signal Circuit Inspection
INFOID:0000000004306972
1.CHECK HARNESS
1.
2.
3.
AV-27
2009 Versa
AUDIO
< SERVICE INFORMATION >
Terminals
Satellite radio tuner
Connector
Terminal
Connector
23
A: B30
4.
Audio unit
Terminal
43
B: M45
24
Continuity
Yes
44
Terminals
Satellite radio tuner
Connector
23
A: B30
Continuity
Terminal
Ground
24
No
OK or NG
OK
>> GO TO 2.
NG
>> Repair harness or connector.
OK or NG
OK
>> Replace audio unit. Refer to AV-37, "Removal and
Installation" .
NG
>> Replace satellite radio tuner. Refer to AV-37, "Removal
and Installation" .
WKIA4550E
INFOID:0000000004306973
1.CHECK HARNESS
1.
2.
3.
Connector
B
Terminal
Connector
12
B121
13
14
4.
Continuity
Terminal
24
M30
32
Yes
31
AV-28
2009 Versa
AUDIO
< SERVICE INFORMATION >
A
Terminals
(+)
Connector
Continuity
()
Terminal
12
B121
13
Ground
No
14
OK or NG
OK
>> GO TO 3.
NG
>> Repair harness.
2.CHECK HARNESS
1.
2.
Terminals
(A)
Connector
(B)
Terminal
Connector
6
M43
Continuity
Terminal
17
15
B121
16
19
Yes
18
OK or NG
OK
>> GO TO 4.
NG
>> Repair harness.
WKIA5349E
AV
OK or NG
OK
>> GO TO 4.
NG
>> Replace spiral cable. Refer to SRS-37, "Removal and
Installation" .
M
WKIA4424E
Terminal
16
20
17
17
Signal name
Resistance
()
(Approx.)
Condition
Seek (down)
165
Phone/Send
Volume (down)
487
Seek (up)
165
Phone/End
Volume (up)
487
LKIA0191E
OK or NG
Revision: October 2008
AV-29
2009 Versa
AUDIO
< SERVICE INFORMATION >
OK
>> Inspection End.
NG
>> Replace steering switch. Refer to AV-37, "Removal and Installation" .
INFOID:0000000004306974
1.HARNESS CHECK
1.
2.
Disconnect audio unit connector and front door speaker connector (LH or RH).
Check continuity between audio unit connector M43 (A) terminal
and suspect speaker connector (B) terminal.
Terminals
A
Connector
B
Terminal
Connector
2
M43
Terminal
D12
3
11
D112
12
3.
Continuity
+
-
Yes
+
-
Terminal
Continuity
2
M43
3
11
Ground
No
WKIA5444E
12
OK or NG
OK
>> GO TO 2.
NG
>> Check connector housings for disconnected or loose terminals.
Repair harness or connector.
1.
2.
3.
AV-30
2009 Versa
AUDIO
< SERVICE INFORMATION >
4. Check the signal between audio unit harness connector terminals with CONSULT-III or oscilloscope.
Terminals
(+)
Connector
(-)
Terminal
Connector
Terminal
M43
11
Condition
Reference
signal
M43
Receive
audio
signal
12
E
SKIA0177E
OK or NG
OK
>> Replace speaker. Refer to AV-37, "Removal and Installation" or AV-37, "Removal and Installation" .
NG
>> Replace audio unit. Refer to AV-37, "Removal and
Installation" .
G
WKIA5352E
INFOID:0000000004306975
1.HARNESS CHECK
1.
2.
Terminals
A
Connector
B
Terminal
Connector
5
M43
Terminal
D207
4
14
D307
13
3.
Continuity
AV
Yes
Terminals
Audio unit
Connector
Terminal
Continuity
5
M43
4
14
Ground
No
WKIA5353E
13
OK or NG
OK
>> GO TO 2.
NG
>> Check connector housings for disconnected or loose terminals.
Repair harness or connector.
AV-31
2009 Versa
AUDIO
< SERVICE INFORMATION >
1. Connect audio unit connector and rear speaker connector.
2. Turn ignition switch to ACC.
3. Push POWER switch.
4. Check the signal between audio unit harness connector terminals with CONSULT-III or oscilloscope.
Terminals
(+)
Connector
(-)
Terminal
Connector
Terminal
M43
13
Condition
Reference
signal
M43
Receive
audio
signal
14
SKIA0177E
OK or NG
OK
>> Replace speaker. Refer to AV-37, "Removal and Installation" .
NG
>> Replace audio unit. Refer to AV-37, "Removal and
Installation" .
WKIA5354E
Sound Is Not Heard from Front Door Speaker or Tweeter (Mid Level and Premium System)
INFOID:0000000004306976
1.HARNESS CHECK
1.
2.
Disconnect audio unit connector and front door speaker and tweeter connector (LH or RH).
Check continuity between audio unit harness connector terminal
and front door speaker and tweeter harness connector terminal.
Terminals
Audio unit.
Connector
Speaker or tweeter
Terminal
2
3
11
M43
12
2
3
11
12
3.
Connector
M46
M47
D12
D112
Continuity
Terminal
+
+
+
Yes
+
-
WKIA5351E
AV-32
2009 Versa
AUDIO
< SERVICE INFORMATION >
A
Terminals
Audio unit
Connector
Terminal
Continuity
2
3
M43
Ground
11
No
12
OK or NG
OK
>> GO TO 2.
NG
>> Check connector housings for disconnected or loose terminals.
Repair harness or connector.
1.
2.
3.
4.
Connect audio unit connector, front door speaker connector and tweeter connector.
Turn ignition switch to ACC.
Push POWER switch.
Check the signal between audio unit connector terminals with
CONSULT-III or oscilloscope.
Terminals
(+)
Connector
(-)
Terminal
Connector
M51
11
Terminal
Condition
Reference
signal
M51
12
I
Receive
audio
signal
AV
SKIA0177E
OK or NG
OK
>> Replace front speaker. Refer to AV-37, "Removal and
Installation" .
NG
>> Replace audio unit. Refer to AV-37, "Removal and
Installation" .
WKIA5352E
Sound Is Not Heard from Rear Door Speaker (Mid Level and Premium System)
INFOID:0000000004306977
1.HARNESS CHECK
1.
AV-33
2009 Versa
AUDIO
< SERVICE INFORMATION >
2. Check continuity between audio unit harness connector terminal
and speaker harness connector terminal.
Terminals
Audio unit
Connector
Speaker
Terminal
Connector
D207
M43
13
D307
14
3.
Continuity
Terminal
+
+
Yes
Terminal
Continuity
4
5
M43
Ground
13
No
WKIA5353E
14
OK or NG
OK
>> GO TO 2.
NG
>> Check connector housings for disconnected or loose terminals.
Repair harness or connector.
Connector
(-)
Terminal
Connector
M43
14
Terminal
Condition
Reference
signal
M43
13
Receive
audio
signal
SKIA0177E
OK or NG
OK
>> Replace speaker. Refer to AV-37, "Removal and Installation" .
NG
>> Replace audio unit. Refer to AV-37, "Removal and
Installation" .
WKIA5354E
AV-34
2009 Versa
AUDIO
< SERVICE INFORMATION >
INFOID:0000000004306978
1.CHECK FUSE
Check that the following fuse is not blown.
Unit
Terminals
Subwoofer
Signal name
Battery power
Fuse No.
27
OK or NG
OK
>> GO TO 2.
NG
>> If fuse is blown, be sure to eliminate cause of blown fuse before installing new fuse. Refer to PG3.
Ensure that subwoofer amp. connector B29 and audio unit harness connectors M43, M44 and M45 are
securely connected.
2. Turn the ignition switch to the ACC position.
3. Press the "AUDIO", "AUX", and "TUNE DOWN" switches simultaneously, the current EQ Setting will be
displayed.
Is "Woofer On" displayed?
YES >> GO TO 3.
NO
>> Disconnect all audio unit harness connectors and wait for 2 minutes in order to reset the audio
unit. Reconnect audio unit connectors M44 and M45 first followed by M43 last. Repeat Steps 1
through 3 to confirm that "Woofer On" is now displayed.
(+)
Subwoofer
Connector
Terminal
B29
(-)
Ground
ACC
ON
Battery
voltage
Battery
voltage
Battery
voltage
L
WKIA5445E
WKIA5446E
AV
1.
J
OFF
OK or NG
OK
>> GO TO 4.
NG
>> Check connector housings for disconnected or loose
terminals.
Repair harness or connector.
1.
2.
Terminal No.
Unit
AV-35
2009 Versa
AUDIO
< SERVICE INFORMATION >
2. Operate system and check voltage between subwoofer harness
connector B29 terminal 4 and ground.
Voltage
: Approx. 11.3V
OK or NG
OK
>> GO TO 6.
NG
>> Check connector housings for disconnected or loose
terminals.
Repair harness or connector.
WKIA5447E
6.HARNESS CHECK
1.
2.
3.
Connector
24
M44
4.
Subwoofer
Terminal
B29
26
Continuity
Terminal
6
Yes
WKIA5448E
Terminals
Audio unit
Connector
Terminal
24
M44
Continuity
Ground
26
No
OK or NG
OK
>> GO TO 7.
NG
>> Check connector housings for disconnected or loose terminals.
Repair harness or connector.
1.
2.
3.
Connector
(-)
Terminal
Connector
Terminal
Condition
Reference
signal
WKIA5449E
M44
26
M44
24
Receive
audio
signal
SKIA0177E
AV-36
2009 Versa
AUDIO
< SERVICE INFORMATION >
OK or NG
OK
>> Replace subwoofer. Refer to AV-37, "Removal and Installation" .
NG
>> Replace audio unit. Refer to AV-37, "Removal and Installation" .
INFOID:0000000004306979
AUDIO UNIT
Removal
1.
2.
3.
F
SKIB4726E
Installation
Installation is in the reverse order of removal.
Removal
1.
2.
AV
L
SKIB4728E
Installation
Installation is in the reverse order of removal.
1.
2.
SKIB4729E
Installation
Revision: October 2008
AV-37
2009 Versa
AUDIO
< SERVICE INFORMATION >
Installation is in the reverse order of removal.
TWEETER
Removal
1.
2.
SKIB4730E
Installation
Installation is in the reverse order of removal.
LKIA0767E
1.
Bracket (upper)
2.
3.
Bracket (lower)
A.
Screws
B.
Connector
C.
Front
AV-38
2009 Versa
AUDIO
< SERVICE INFORMATION >
Sedan
A
H
LKIA0935E
1.
Bracket (upper)
2.
3.
Bracket (lower)
A.
B.
C.
Front
Removal
1.
2.
3.
4.
5.
6.
For hatchback, remove the luggage side lower finisher (LH) (hatchback only). Refer to EI-53.
For sedan, remove the trunk side finisher (LH). Refer to EI-55, "Removal and Installation".
For hatchback remove the subwoofer. Refer to AV-37, "Removal and Installation".
Remove the satellite radio tuner bolts.
Disconnect the connectors and remove the satellite radio tuner.
If necessary, remove the upper bracket (2) and the lower
bracket (1).
AV
O
LKIA0768E
Installation
Installation is in the reverse order of removal.
1.
AV-39
2009 Versa
AUDIO
< SERVICE INFORMATION >
2. Disconnect the satellite radio antenna connectors.
3. Detach the satellite radio antenna feeder harness clips.
4. Remove the satellite radio antenna nut and remove the satellite
radio antenna from the roof.
LKIA0679E
Installation
Installation is in the reverse order of removal.
LKIA0769E
1.
A.
Screws
2.
Steering wheel
3.
Removal
1.
2.
3.
Installation
Installation is in the reverse order of removal.
SUBWOOFER
Revision: October 2008
AV-40
2009 Versa
AUDIO
< SERVICE INFORMATION >
A
I
LKIA0770E
1.
Subwoofer
A.
Subwoofer bolts
B.
Connector
Removal
1.
2.
3.
AV
Installation
Installation is in the reverse order of removal.
AV-41
2009 Versa
AUDIO ANTENNA
< SERVICE INFORMATION >
AUDIO ANTENNA
Location of Antenna
INFOID:0000000004306980
LKIA0934E
1.
Roof antenna
2.
3.
Audio unit
A.
B.
Harness clips
C.
INFOID:0000000004306981
REMOVAL
1.
2.
3.
4.
5.
6.
For hatchback, remove the luggage side upper finisher (LH). Refer to EI-53.
For sedan, remove the rear pillar finisher. Refer to EI-51, "Removal and Installation - Sedan".
Remove rear assist grip (LH). Refer to EI-47.
Remove three clips of headlining (rear side). Pull down headlining (rear side) and obtain space for work
between vehicle and headlining.
Disconnect the roof antenna harness connectors.
Remove nut (A) and clips (B).
AV-42
2009 Versa
AUDIO ANTENNA
< SERVICE INFORMATION >
: Vehicle front
C
SKIB4772E
7.
INSTALLATION
AV
AV-43
2009 Versa
TELEPHONE
< SERVICE INFORMATION >
TELEPHONE
Component Parts and Harness Connector Location
INFOID:0000000004306982
WKIA6000E
1.
2.
3.
4.
5.
6.
Bluetooth control unit B121, B122 (hatchback) [view with luggage side lower finisher (RH) removed]
7.
8.
System Description
INFOID:0000000004306983
AV-44
2009 Versa
TELEPHONE
< SERVICE INFORMATION >
tooth cellular telephones may not be recognized by the Bluetooth control unit. When a cellular telephone or
the Bluetooth control unit is replaced, the telephone must be paired with the Bluetooth control unit. Different
cellular telephones may have different pairing procedures. Refer to the cellular telephone operating manual.
WKIA6001E
Bluetooth Microphone
The Bluetooth microphone is located in the roof console assembly. The Bluetooth microphone sends a signal
to the Bluetooth control unit. The Bluetooth microphone can be actively tested during self-diagnosis. For Bluetooth microphone location, refer to AV-44, "Component Parts and Harness Connector Location".
Bluetooth ON Indicator
The Bluetooth ON indicator is located in the overhead console. The indicator will flash during power up while
the Bluetooth control unit is initializing. This process may take up to 10 seconds. If a phone is present in the
vehicle and paired with the Bluetooth control unit, the indicator will remain on to indicate that the system is
ready for voice commands. The indicator flashes during self-diagnosis. For Bluetooth ON indicator location,
refer to AV-44, "Component Parts and Harness Connector Location".
Audio Unit
The audio unit receives signals from the Bluetooth control unit and sends audio signals to the speakers.
AV-45
2009 Versa
TELEPHONE
< SERVICE INFORMATION >
INFOID:0000000004306984
WKWA4987E
AV-46
2009 Versa
TELEPHONE
< SERVICE INFORMATION >
A
AV
O
WKWA4988E
AV-47
2009 Versa
TELEPHONE
< SERVICE INFORMATION >
INFOID:0000000004306985
LKIA0753E
Item
Signal
input/
output
Condition
Ignition
switch
Operation
INFOID:0000000004306986
Reference value
(Approx.)
Example of symptom
1 (R)
Ground
Battery power
Input
Battery voltage
2 (L)
Ground
ACC power
Input
ACC/
ON
Battery voltage
3 (LG)
Ground
IGN power
Input
ON/
START
Battery voltage
4 (B)
Ground
Shield
7 (R/W)
8 (R/L)
Mic-in signal
Input
9 (LG)
10 (V)
Audio out
Output
ACC/
ON
Bluetooth control
unit sends audio
signal
SKIB3609E
11(O)
Mute
Output
Press MODE
switch
12 (W)
13 (L)
14 (B)
Ground
Ground
Remote
control
switch 1
Remote
control
switch 2
Remote
control
ground
Input
Input
Input
ACC/
ON
ACC/
ON
Press SEEK UP
switch
5V
0V
0.75V
Press VOL UP
switch
2V
5V
Press POWER
switch
0V
Press SEEK
DOWN switch
0.75V
Press VOL
DOWN switch
2V
5V
AV-48
Mute inoperative.
2009 Versa
TELEPHONE
< SERVICE INFORMATION >
Terminal
(Wire color)
+
15 (G)
17 (GR)
18 (P)
Item
Ground
Ground
Ground
19 (B)
Ground
20 (B)
21 (B)
23 (B)
Bluetooth
ON indicator
LED
Audio unit
switch 1
Audio unit
switch 2
Audio unit
switch
ground
Signal
input/
output
Output
Output
Output
Condition
Reference value
(Approx.)
Ignition
switch
Operation
Bluetooth control
unit initialized
and paired with
phone
Battery voltage
Press Phone/End
switch
0V
Press SEEK UP
switch
0.75V
ACC/
ON
ACC/
ON
Example of symptom
B
Bluetooth ON indicator inoperative.
Press VOL UP
switch
2V
5V
Press Phone/
Send switch
0V
Press SEEK
DOWN switch
0.75V
Press VOL
DOWN switch
2V
5V
Output
Cont-1
Cont-2
Cont-4
28 (O)
Ground
Vehicle
speed signal
(8pulse)
Input
ON
When vehicle
speed is approx.
40 km/h (25
MPH)
PKIC0643E
29 (B)
33
Ground
Bluetooth
Microphone
power
Output
Bluetooth
antenna signal
Input
5V
AV
INFOID:0000000004306987
The Bluetooth control unit has two diagnostic checks. The first diagnostic check is performed automatically
every ignition cycle during control unit initialization. The second diagnostic check is performed by the technician using the steering wheel audio control switches prior to trouble diagnosis.
SELF-DIAGNOSIS MODE
Revision: October 2008
AV-49
2009 Versa
TELEPHONE
< SERVICE INFORMATION >
1. Turn ignition switch to ACC or ON.
2. Wait for the Bluetooth system to complete initialization and the Bluetooth ON indicator to stop flashing.
This may take up to 10 seconds.
3. Press and hold the steering wheel audio control switch SEND
button for at least 5 seconds. The Bluetooth system will begin to
play a verbal prompt.
WKIA6003E
4.
5.
6.
7.
8.
9.
Workflow
INFOID:0000000004306988
Flashing Pattern
(Bluetooth ON indicator)
Failure Message
Action
Replace Bluetooth control unit. Refer to AV55, "Removal and Installation".
"Internal failure"
1.
2.
Check steering wheel audio control switches. Refer to AV-28, "Steering Switch Check
(With Bluetooth)".
1.
2.
Power Supply and Ground Circuit Inspection for Bluetooth Control Unit
INFOID:0000000004306989
1.CHECK FUSES
Make sure the following fuses for the Bluetooth control unit are not blown.
AV-50
2009 Versa
TELEPHONE
< SERVICE INFORMATION >
Terminals
Connector
Ignition Switch
Fuse No.
All positions
27
ACC/ON
20
ON/START
Terminal
B121
OK or NG
OK
>> GO TO 2.
NG
>> If fuse is blown, be sure to eliminate cause of malfunction before installing new fuse. Refer to PG3.
Terminal
1
B121
ACC
ON
Battery
voltage
Battery
voltage
Battery
voltage
0V
Battery
voltage
Battery
voltage
0V
Battery
voltage
0V
WKIA4389E
Terminal
OK or NG
OK
>> GO TO 3.
NG
>> Check harness for open between Bluetooth control unit and fuse.
1.
2.
OFF
Ground
AV
Continuity
4
B121
20
21
Ground
Yes
23
LKIA0794E
OK or NG
OK
>> Inspection End.
NG
>> Repair or replace harness.
INFOID:0000000004306990
AV-51
2009 Versa
TELEPHONE
< SERVICE INFORMATION >
1. Press the SEND switch.
2. Check the indicator is blinking.
OK or NG
OK
>> INSPECTION END
NG
>> Check steering wheel audio control switch circuit.
: Approx. 12 V
OK or NO
OK
>> Replace Bluetooth indicator. Refer to AV-55, "Removal
and Installation".
NG
>> GO TO 4.
LKIA0774E
OK or NO
OK
>> Replace Bluetooth control unit. Refer to AV-55,
"Removal and Installation".
NG
>> Repair or replace harness.
LKIA0775E
INFOID:0000000004306991
1.
2.
: Approx. 5 V
: Approx. 5 V
OK or NG
OK
>> Replace audio unit. Refer to AV-37, "Removal and
Installation".
NG
>> GO TO 5.
LKIA0776E
AV-52
2009 Versa
TELEPHONE
< SERVICE INFORMATION >
: Approx. 5 V
: Approx. 5 V
OK or NG
OK
>> Repair or replace harness.
NG
>> Replace Bluetooth control unit. AV-55, "Removal and
Installation".
D
LKIA0777E
INFOID:0000000004306992
NOTE:
Even under the normal condition, Bluetooth voice guidance may not occur when pressing steering wheel
audio control switch.
BLUETOOTH VOICE GUIDANCE IS HEARD WHEN PRESSING STEERING WHEEL AUDIO CONTROL SWITCH
Connector
Terminal
Connector
Terminal
6
A: B121
Continuity
B: R15
Yes
AV
LKIA0778E
Check continuity between Bluetooth control unit harness connector B121 and ground.
Terminals
Connector
29
4.
Terminal
Continuity
No
7
A: B121
Ground
29
OK or NG
OK
>> GO TO 2.
NG
>> Repair harness or connector.
AV-53
2009 Versa
TELEPHONE
< SERVICE INFORMATION >
3. Check voltage between Bluetooth microphone connector R15
terminal 5 and ground.
5 - Ground
: Approx. 5 V
YES or NO
YES >> GO TO 3.
NO
>> Replace Bluetooth control unit. Refer to AV-55,
"Removal and Installation".
LKIA0779E
7 8:
PKIB5037J
LKIA0780E
OK or NG
OK
>> Replace Bluetooth control unit. Refer to AV-55, "Removal and Installation".
NG
>> Replace Bluetooth microphone. Refer to AV-55, "Removal and Installation".
BLUETOOTH VOICE GUIDANCE IS NOT HEARD WHEN PRESSING STEERING WHEEL AUDIO
CONTROL SWITCH
1.
2.
3.
Connector
Terminal
Connector
9
A: B121
10
11
4.
Terminal
Continuity
31
B: M44
33
Yes
27
Check continuity between Bluetooth control unit harness connector B121 (A) and ground.
AV-54
LKIA0781E
2009 Versa
TELEPHONE
< SERVICE INFORMATION >
A
Terminals
Connector
Terminal
Continuity
9
A: B121
10
Ground
No
11
OK or NG
OK
>> GO TO 3.
NG
>> Repair harness or connector.
: Approx. 5 V
OK or NG
OK
>> GO TO 4.
NG
>> Replace audio unit. Refer toAV-37, "Removal and Installation".
H
LKIA0782E
9 10:
AV
SKIB3609E
LKIA0783E
OK or NG
OK
>> Replace audio unit. Refer to AV-37, "Removal and Installation".
NG
>> Replace Bluetooth control unit. Refer to AV-55, "Removal and Installation".
M
INFOID:0000000004306993
AV-55
2009 Versa
TELEPHONE
< SERVICE INFORMATION >
Hatchback
LKIA0762E
1.
B.
2.
E.
A.
D.
Front
Sedan
LKIA0936E
AV-56
2009 Versa
TELEPHONE
< SERVICE INFORMATION >
1.
2.
3.
A.
B.
Front
Removal
1.
2.
3.
4.
5.
6.
For hatchback, remove luggage side lower finish (RH). Refer to EI-53, "Removal and Installation".
Disconnect Bluetooth antenna harness clip.
For sedan, remove the trunk room side finisher (RH). Refer to EI-55, "Removal and Installation".
Disconnect the Bluetooth antenna harness connector.
Disconnect the Bluetooth control unit harness connector.
Remove the Bluetooth control unit upper and lower bracket bolts.
Unhook the Bluetooth control unit upper and lower brackets and remove Bluetooth control unit.
Remove Bluetooth control unit bracket screws and remove the upper and lower brackets from unit.
Installation
Installation is in the reverse order of removal.
F
BLUETOOTH ANTENNA
Hatchback
AV
LKIA0763E
1.
2.
Bluetooth antenna
B.
C.
A.
AV-57
2009 Versa
TELEPHONE
< SERVICE INFORMATION >
Sedan
LKIA0937E
1.
2.
Bluetooth antenna
A.
B.
C.
Front
Removal
1.
2.
3.
4.
5.
6.
For hatchback, remove luggage side lower finisher (RH). Refer to EI-53, "Removal and Installation".
For sedan, fold the rear seat back down, remove the seat back finisher (RH). Refer to EI-55, "Removal
and Installation".
Disconnect the Bluetooth antenna feeder harness clips.
Disconnect the Bluetooth antenna feeder harness connector.
Remove the Bluetooth antenna bracket bolt(s) and remove antenna.
Remove the Bluetooth antenna screws and remove bracket.
Installation
Installation is in the reverse order of removal.
BLUETOOTH MICROPHONE
Removal
1.
2.
Installation
Installation is in the reverse order of removal.
AV-58
2009 Versa