Académique Documents
Professionnel Documents
Culture Documents
(15 minutes)
Layer3 Messages
Signaling Layer3
The flow of layer3 messages in TEMS can be seen in Layer3 messages widows
from menu PresentationSignalingLayer 3 Messages.
Messages which can not be decoded are shown in Error Report.
In TEMS version lower than TEMS8, detail of layer3 message can be locked and
open more than 1 message at the same time.
Radio Network Planning and Optimization
Layer3 Messages
Layer 3 Control
In TEMS version5 or lower, Layer 3 message can be manipulate and ask mobile to
send, delay or discard specific layer messages.
From the windows, we can see the available messages in DL and UL, unfortunately
not all messages that we can modify.
Layer3 Messages
Practice
1.
2.
There are some layer 3 messages that can not use in the
operation sequence, please mention them.
Answer :
Layer3 Messages
Layer3 Messages
Layer3 Messages
Answer: 15 seconds
Layer3 Messages
Please find the value of T3105 and T3124 and How many PHYSICAL INFORMATION
send from BSC before T3124 expired.
Layer3 Messages
Answer:
T3105 = 7 ms
T3124 = 320 ms
Number of PHY INFO = 3-4
Layer3 Messages
Please find the following parameter of foreign cell from layer 3 messages.
CGI
Cell Reselection Hysteresis
RXLEV-ACCESS-MIN
BA List
Maximum Retransmission
T3212
SDCCH TS
Average TA
Layer3 Messages
Find from
value
CGI
418-05-7412-64090
6 dB
RXLEV-ACCESS-MIN
1 dB
BA List
none
Maximum Retransmission
7 times
T3212
1 deci-hour
Immediate Assignment
TS 1-6
TA
Immediate Assignment
Layer3 Messages
Please find the following parameter of foreign cell from layer 3 messages.
CGI
MS-TXPWR-MAX-CCH
RXLEV-ACCESS-MIN
BS-PA-MFRMS
TX-Integer
CRO
ATT flag
RADIO-LINK-TIMEOUT
Layer3 Messages
Find from
value
CGI
418-05-7421-777
MS-TXPWR-MAX-CCH
RXLEV-ACCESS-MIN
37/38 dB
BS-PA-MFRMS
TX-Integer
32
CRO
126
ATT flag
YES
RADIO-LINK-TIMEOUT
36 SACCH
Layer3 Messages
Layer3 Messages
Solution:
1.Look from Synch Channel Information for see that which place is the last time
that MS can decode 86(44)
-If near 86(11) you should tilt down 86(44) because it overshoot coverage
-If far from 86(11) you should so this case MS remember old BSIC !!
-Neighboring Optimization
-Change BCCH pattern
Radio Network Planning and Optimization
Layer3 Messages
Layer3 Messages
Solution:
-Add Measurement frequency and neighbor from 75(47) to 94(75)
-Change BCCH of either 81(75) or 81(72)
-Change BCCH of 86(72) or 86(47)
Radio Network Planning and Optimization