Académique Documents
Professionnel Documents
Culture Documents
DBS3900/3800 NODEB
Hardware Overview
www.huawei.com
DBS3900 Abbreviations
WMPT
WBBPbD
UBFA
UELP
UFLP
UPEU
CPRI
APM
Page 2
DBS3900 Overview
DBS3900 system consists of:
RRU
3804 /3808/3801c
RF jumper
Feeder
-48V DC
power
Grounding cable
RF jumper
Power cable
BBU3900
-48V/ 24V
DC power
Grounding cable
Power cable
RNC
Page 3
BBU3900 Module
Full configuration
Typical configuration
BBU3806 Module
UPEU
The optional boards are the UELP, UFLP, UTRP, and UEIU.
Page 4
Page 5
Page 6
LED
Color
RUN
Green
ALM
ACT
LIU0 to LIU7
CPRI 0 to
CPRI 2
Red
Green
Yellow
Yellow
Status
ON
Description
OFF
ON
OFF
Blinking
ON
OFF
ON
OFF
ON
OFF
ON for 1s and OFF for 1s
Page 7
Appearance
The -48 V DC cable has a 7W2 female connector at one end and two bare power wires at the other end,
as shown in Figure 1. OT terminals or cord end terminals must be added to the two wires on site.
Color
Blue
-48 V
A2
Black
GND
Description
The two wires are used to transmit -48 V power signals.
Page 8
Page 9
(2) OT terminal
Page 10
Slot
SLOT0
SLOT4
16
SLOT1
SLOT5
SLOT2
SLOT6
SLOT3
SLOT7
Slot 18
Slot 19
WBBP
UTRP
PEU/
WBBP
UTRP
EIU
WBBP
WMPT
PEU/
WBBP
WMPT
EIU
Page 11
Loading
Testing:USB
LEDs
Commissioning:RJ45
Board number
IP transmission
Optical signals: SFP
4E1:DB26
Main Functions
Providing OM functions
mandatory board
Providing OM channels
HUAWEI TECHNOLOGIES CO., LTD.
Page 12
Label
Color
Status
Description
RUN
Green
ON
OFF
1s ON, 1s OFF
ON
OFF
Blinking
ON
OFF
ALM
ACT
Red
Green
Page 13
LED
Color
Status
Description
Green
ON
OFF
Blinking
OFF
ON
OFF
Blinking
OFF
Yellow
Green
Yellow
Page 14
T1 Mode
120-ohm E1
Balanced
Mode
75-ohm E1
Unbalanced
Mode
ON
OFF
ON
ON
OFF
ON
OFF
ON
ON
OFF
ON
ON
Settings of SW2
Bit
75-ohm E1
Unbalanced
Mode
Description
ON
ON
ON
ON
Page 15
Page 16
Page 17
Page 18
Page 19
Color
Status
Description
RUN
Green
ON
OFF
1s ON, 1s OFF
0.125s ON/OFF
ON
OFF
OFF
ON
The board has alarms on hardware and it should be replaced with a new one.
Blinking
The external ports of the board are faulty and should be handled.
OFF
normal
ON
Blinking at 2 Hz
Blinking at 0.5 Hz
The RRU on the CPRI link is faulty in the antenna system connection.
ACT
ALM
CPRI0
CPRI1
CPRI2
Green
Red
Red
Green
Page 20
Board
WBBPa
128
256
WBBPb1
64
64
WBBPb2
128
128
WBBPb3
256
256
WBBPb4
384
384
WBBPd1
192
192
WBBPd2
384
384
WBBPd3
256
256
Page 21
Color
Status
Description
STATE
Green
0.125s ON,
0.125s OFF
alarm is reported.
1s ON, 1s OFF
ON
Red
Page 22
+24V to +12V
-48V to +12V
Main Functions
Converting -48 V or +24 V DC power input to +12 V DC power that is supported by boards
Page 23
Label
Color
Status
Description
RUN
Green
ON
OFF
Socket and Port: The UPEU has one socket and four ports.
Page 24
Page 25
Thank You
www.huawei.com