Académique Documents
Professionnel Documents
Culture Documents
MPLS v2.03-1
Outline
Overview
Configuration Tasks for MPLS on LC-ATM interfaces
Configuring an LC-ATM Interface on a Router
Configuring an LC-ATM Interface on a Catalyst
ATM Switch
Basic LC-ATM Configuration
Configuring Additional LC-ATM Parameters
Disabling VC Merge
Lesson Summary
2003, Cisco Systems, Inc. All rights reserved.
MPLS v2.03-3
MPLS v2.03-4
mpls ip
mpls label protocol [ldp | tdp | both]
MPLS v2.03-5
MPLS v2.03-6
MPLS v2.03-7
MPLS v2.03-8
MPLS v2.03-9
MPLS v2.03-10
Disabling VC Merge
MPLS v2.03-11
Summary
To run MPLS on an LC-ATM router a subinterface needs to
be created.
On LC-ATM routers use the mpls keyword to specify the
type of subinterface when you are entering interface
configuration mode. This command specifies that cellmode MPLS should be used.
Use the command interface atm number on a Cisco
Catalyst switch.
The default VPI/VCI value is 0/32.
Disabling VC merge (which is enabled by default) allows
cells to be interleaved.
2003, Cisco Systems, Inc. All rights reserved.
MPLS v2.03-12