Académique Documents
Professionnel Documents
Culture Documents
TL-POE150S
PoE Injector
Rev:2.0.0
7106503015
are
FCC STATEMENT
This equipment has been tested and found to comply with the
limits for a Class B digital device, pursuant to part 15 of the FCC
Rules. These limits are designed to provide reasonable
protection against harmful interference in a residential
installation. This equipment generates, uses and can radiate
radio frequency energy and, if not installed and used in
accordance with the instructions, may cause harmful
interference to radio communications. However, there is no
guarantee that interference will not occur in a particular
installation. If this equipment does cause harmful interference to
radio or television reception, which can be determined by turning
the equipment off and on, the user is encouraged to try to
correct the interference by one or more of the following
measures:
Reorient or relocate the receiving antenna.
Increase the separation between the equipment and
receiver.
Connect the equipment into an outlet on a circuit different
for help.
This device complies with part 15 of the FCC Rules. Operation is
subject to the following two conditions:
1) This device may not cause harmful interference.
2) This device must accept any interference received,
CE Mark Warning
CONTENTS
Package Contents.................................................................... 1
Chapter 1 Introduction .......................................................... 1
1.1
1.2
Package Contents
The following items should be found in your package.
) Note:
Make sure that the package contains the above items. If any of
the listed items are damaged or missing, please contact with
your distributor.
Chapter 1
Introduction
*PSE: A device (switch or hub for instance) that will provide power in a PoE
setup.
1.2 Features
Complies with IEEE 802.3, IEEE 802.3u, IEEE 802.3af
standards
Compatible with PoE compliant PDs and PoE Splitters
Transmits electrical power along with data in one single
cable
External 48V DC power supply
Supports
Plug-and-Play
configuration
for
the
devices,
without
any
Chapter 2
Chapter 3
Scheme 1
Scheme 2
) Note:
Do not mistake the power port of the TL-POE150S and
TL-POE10R when choosing the Scheme 2, or else it will
cause serious damage to your network device.
If you want to know more details about TL-POE10R Splitter,
please refer to TL-POE10R User Guide on our website
http://www.tp-link.com.
Appendix: Specifications
Normal
Standards
Ports
PoE Port
LAN Port
IEEE 802.3,
802.3af
IEEE
802.3u,
IEEE
Cabling Type
LED
Safety &
Emissions
FCC, CE