Académique Documents
Professionnel Documents
Culture Documents
Instructions for estimating body composition using the Valhalla Bioimpedance Body
Composition Analyzer (BIA-1990B).
1.
Record pertinent identification data on the top section of the data sheet. Give the
name of the measurer and time and date of the measurement.
2.
Record the subjects height and body weight (these measurements should be
obtained during the same test session as the impedance measurements).
The subject must remove only the right shoe and sock. The dorsal surface of the
right hand and the anterior surface of the right ankle must be exposed and dry.
4.
The subject must be lying supine for approximately five minutes before the
impedance measurement is made. The legs should be extended (knees straight)
and spread so that the thighs do not touch. The arms should be extended, next to
the body, relaxed, but not touching the body. The entire body should be relaxed.
Breathe normally.
6.
Prior to attachment cut the electrodes in half, bisecting the protruding tab. The
cut edge of the electrode, when placed on the ankle and wrist, should face toward
the shoulder and thigh. Electrode gel is not needed.
7.
Put H-1 (red cable, black tip) on an imaginary line between the styloid
processes of the radius and ulna.
b)
Put H-2 (red cable, black tip) on an imaginary line just above the
metacarpal-phalangeal joint line.
c)
8.
H-1 and H-2 should be placed parallel and directly across from each other.
Put F-1 (black cable, red tip) on an imaginary line bisecting the medial and
lateral malleoli.
b)
9.
The orientation of the cable clips in relation to the right thumb and right lateral
malleolus is important. The clips on the right hand should be connected adjacent
to the thumb, and the clips on the right ankle are adjacent to the lateral malleolus.
11.
To operate the analyzer with the battery charger, plug the male end of the power
cord into a 110-volt AC wall outlet (the charger and analyzer should be off).
Plug the female end of the power cord into the connector located in the upper
right hand corner of the BIA-190B. Turn the battery charger and BIA-1990B
switch on.
12.
The electrode cables should be plugged into the connector located in the lower
right hand corner of the front of the BIA-1990B analyzer.
13.
Two switches are located on the front of the analyzer. The leftmost switch is a
range selector and should be set at 0-1000. The right switch, when in the up
position (Res), allows the resistance measurement to be displayed, and when in
the down position (Reac), reactance is displayed.
14.
Obtain the resistance and reactance readings. Allow a few seconds for the reading
to stabilize before recording the result.
15.
16.
Wait an additional minute and repeat Step 14. Use the average of the three
readings for the representative resistance and reactance measurement.