Académique Documents
Professionnel Documents
Culture Documents
TUTORIAL
Project Materials List:
Nylon sparkle organza or Nylon Iridescent Organza
Water soluble backing (dissolve-away / washaway)
Cut Away backing
For best results we recommend that you pre-wind your
bobbin to match bottom Organza color
Soldering Iron
Hair Dryer optional
Invisible Tape
Clothes Peg
Optional Clear non toxic adhesive glue
-
l
b
a
r
o
d
s
a
e
d
i
e
s
a
e
d
i
e
l
b
a
6) Remove leaves and petals from hoop and cut as closely as possible to
embroidered border without cutting into the stitching.
r
o
d
7) Once leaves and petals have been cut out take your hot soldering iron and gently trace the
outside edge of border without cutting the stitching. The leaves and petals have a circle of
stitching in the center. This will be your placement line for putting your flower together.
You must hollow out the center with the soldering iron. Beware the soldering iron is hot.
s
a
e
d
i
e
l
b
a
r
o
d
12) Place the first leaf you embroidered on your center line
using the hollowed section for placement . Use invisible tape
at edges of leaf to hold in place. Repeat process with next leaf
or petal (whichever is applicable to flower you are doing).
Remember that you must alternate placement of layers.
l
b
a
r
o
d
s
a
e
d
i
e
15) Remove from hoop and cut the cut away fabric from back of
flower you have created. Cut closely but do not cut into the
embroidery. If your leaves and petals are lying too flat, simply
take a small spray bottle filled with water and lightly mist the flower.
You can then shape it however suits you.
l
b
a
s
a
e
d
i
e
B. ASTER 102 We have supplied two files for the center of this design.
You can opt for regular embroidery or use foam embroidery which will add
dimension to the center of the flower. The foam option is done as follows:
Place hoop with assembled leaves and petals in machine and embroider
the first color gold. Cut out two small pieces of crafters foam, which you
will place over the center on top of each other. Carefully hold outside edges
in place for first few stitches and them finish embroidery. Remove from machine and gently peel away what is
left of the foam. We have included photos of the Aster center done with foam embroidery and embroidery only.
r
o
d
r
o
d
l
b
a
s
a
e
d
i
e
D. POPPY 105 This flower has fringe embroidery for the stamen in center of the flower. Follow instructions
shown in A for the fringe. The large petals of the poppy have a tendency to lay flat. To remedy this take your
spray bottle with water and mist the flower. Shape the flower and use a clothes peg at the bottom of the petals
to make them stand up. Allow to dry naturally and remove clothes peg.
r
o
d
l
b
a
s
a
e
d
i
e
F. SUNFLOWER 108 - Embroider your placement guide on the cutaway backing, line up your sunflower leaf and
tape down with the invisible tape. Place hoop back in machine and run second placement line on top of the leaf.
Remove hoop from machine and line up the top of the bottom petal. Tape down with invisible tape, and then line
up the bottom of the bottom petal. Tape down and return hoop to machine. Now you will run your third
placement line on top of the bottom layer of petals. Remove hoop from machine and line up top of the top petal.
Tape down with invisible tape. Line up the bottom of the top petal with placement line and tape down with
invisible tape. Return hoop to machine and finish the center embroidery for the sunflower.