Académique Documents
Professionnel Documents
Culture Documents
Website:
www.INXdigital.com
www.greenINX.com
PHYSICAL PROPERTIES
VOC:
COVERAGE: [average]
ClearFlex ME
D320 is a premium,
extremely durable,
waterborne, clear coating. Containing both
ultraviolet absorbers and
hindered amine light
stabilizers for the maximum in UV light protection.
UV PERFORMANCE
50F
60F
70F
85F
Touch
2 hrs
1 hr
30 mins 15 mins
Recoat
2 hrs
1 hr
30 mins 15 mins
Hard Cure
8 hrs
4 hrs
2 hrs
1 hr
This information has been carefully studied from experience gained in the laboratory and under commercial situations. It is subject to
change without notice. All sales are subject to our standard terms and conditions of sale. Since applications vary tremendously, the user
assumes the obligation to test this product in their specific situation to determine its suitability an assumes all risk and liability related to
such use. INX Digital International Co. makes no warranty, express or implied, for the use of the product for any particular application. In
no event shall INX Digital International Co. be liable for damages in excess of the original cost of the product nor shall INX Digital
International Co. be liable for any special or consequential damages. The Triangle logo is a registered trademark of Triangle Coatings, Inc.
used under license.
PACKAGING:
Six each 1 liter bottle per case........... 15lbs
4 each 5 liter jugs per case.............. 595 lbs
1 each 20 liter jug per case............... 49 lbs
APPLICATION DATA
SURFACE PREPARATION
Clean surface thoroughly of foreign
contaminants.
Vinyl: apply one or two coats to provide
1 mil dry film thickness.*+
THINNING:
This is a water soluble product. Thinning
is not recommended as it will reduce the
effectiveness of the product.
APPLICATION METHODS:
Hand Application: Use a 1/4 inch close
nap roller for the best performance on
large surfaces. For small pictorial areas or
digital prints, brushing is better using a 4
inch foam brush or foam paint pad.
Always load the applicator with the
maximum amount of coating as possible and
apply with light pressure. This will prevent
bubbling. Vigorous rolling and high pressure
may produce a frothy surface.
Spray Application: Do not use Wagner or
airless spray equipment. This type of
equipment puts too much material on
the surface. Use conventional air atomization equipment. Fluid tip size should be
0.045 - 0.060 at 30 pounds atomizing
pressure at 9 - 12 cfm.
*Since applications for this product vary tremendously, the user assumes the obligation to test this
product in their specific application to determine
the suitability for reach application and assumes all
risk and liability related to such use.
AUTOMATIC APPLICATION
Not required
IMDG Stowage:
Not regulated
Class III-A
120 F max
1 year
H - 1; F - 1; R - 0, PP - B
This information has been carefully studied from experience gained in the laboratory and under commercial situations. It is subject to
change without notice. All sales are subject to our standard terms and conditions of sale. Since applications vary tremendously, the user
assumes the obligation to test this product in their specific situation to determine its suitability an assumes all risk and liability related to
such use. INX Digital International Co. makes no warranty, express or implied, for the use of the product for any particular application. In
no event shall INX Digital International Co. be liable for damages in excess of the original cost of the product nor shall INX Digital
International Co. be liable for any special or consequential damages. The Triangle logo is a registered trademark of Triangle Coatings, Inc.
used under license.
www.INXdigital.com