Académique Documents
Professionnel Documents
Culture Documents
QUICK GUIDE
Input
Analogue port 1
Analogue port 2
(Analogue port 3)
Note 1: Terminal 1, common, is used for input DIMM, REF, HV1+ and HV2+.
Note 2: Only one measurement (voltage or current) range from each analog port can
be selected.
The menu is divided into 2 panes. The left pane shows information for the
selected menu or settings. In the right pane, the current menu is shown with
a highlighted blue arrow.
To navigate through the menus, the two physical buttons up and down is
used. Press the OK physical button to select a menu or value.
CANopen
Button 1
Button 2
Button 3
Button 4
For more information on the addresses used to set up data to and from the
XDi, please refer to the User Reference Manual or the XDi-Net/CANopen
Reference Manual.
Wiring of XDi
Type
Connector 1
Dill switch 1
Dill switch 2
Connector 2
Terminal
no.
1
2
3
4
5
6
7
8
9
10
Signal
Marking
Remark
CAN 1
CAN 1 GND
CAN 1 LOW
CAN 1 HIGH
+24V DC
0V
CAN 1 Term.
CAN 2 Term.
CAN 2 GND
CAN 2 LOW
CAN 2 HIGH
+24 V DC
0V
Supply
Voltage
ON/OFF
On/OFF
CAN 2
Supply
Voltage
By default, the termination is set to OFF. Both ends of the CANbus cable
should be terminated,
Please note, that only 2 terminations must be activated (set ON) at a
time on a CANbus network.
When the cables and connectors are mounted on the XDi, the cables should
be relieved using a cable tie which is easily inserted in the two small slots
above the connectors.
Picture can be seen on next page.