Académique Documents
Professionnel Documents
Culture Documents
Release History
EDITION
01
DATE OF ISSUE
7. 2012
Prepare by
Inter Discipline
Check
Prasoon Saxena,
Ajay Shinde
Review by
Approved by
Details of
Amendments/
Revisions
WonJoon Lee,
Anurag
Chaturvedi
Vikas Bonde
2|Page
INDEX
Table of Contents
1
4.1
4.2
5
5.1
5.2
6.1
Placement Guidelines for RTP (Single Pole & H Pole Structure) ............................................................................................. 9
RF Layout for Typical for RTP .............................................................................................................................................................. 10
Signages Board placement position for Wall Mount & Parapet ............................................................................................11
Placement Guidelines for Wall Mount & Parapet Structure .................................................................................................... 11
6.2
7.1
8.1
8.2
3|Page
1 Introduction to EMF
Base Transceiver Stations (BTS) of Mobile Communication Network produce electromagnetic fields & can be
viewed as the combination of an electric field and a magnetic field,
EMF Radiations measurement Measured in the form of Power Density whose unit is W/m2 and
is dependent on the frequency band at which it is being radiated,
DOT has release the guidelines for EMF Regulation,
The main aim of the measurement is to confirm the compliance of base station installation as per
The limits prescribed by the Department of Telecommunications and ensure in terms of that will not effect to
Public health
RJIL LTE Threshold Power Density <1 W/m2 valid for 2300 Mhz Band
4|Page
2.Warning
3.Caution
Board Material
Board shall be of fiber/ tin/Flex & shall be placed wherever it is applicable for RTT, RTP, Wallmount, GBM, GBT
Some signage should make in form of plastic/ flex sticker with high adhesive
5|Page
Warning
Caution
Placement - To be
provided only where
exclusion zone is formed
in any area
Placement - At entry
point of roof of the
building of BTS in case of
RTT or at the entrance of
BTS compound in case of
GBT
6|Page
Danger To placed on height of 4meter from the base of Antenna on RTT Structure , with the help of clamp as
shown in the picture , can be place on any one leg of RTT (square/ delta structure),
Case 1 if a site is in form of RTT + RTP , means two antenna place on RTT and one is on RTP, then 2 boards
require
Case 2- if a site is in form of RTT+RTP, means one antenna is on RTT and two are on Pole, then 3 signages board
require, one for RTT, Two are for the poles
Caution To be place on main entrance door of terrace, signages board to be place in form of plastic sticker high
adhesive or can be hang on mail entrance
Warning To be place on door of eNB room on ODC or on shelter room, signages board to be place in form of
plastic sticker high adhesive or can be hang on main door
e.g)for RTT, RTT+RTP
Danger
Caution
Warning
7|Page
8|Page
Case 2- If three pole are place together on same location in area of 5sqmeter, one danger signage to be place on
any one leg
Case 3 Incase for H type Pole, one danger to be place on each H Pole Structure
Caution To be place on main entrance door of terrace, signages board to be place in form of plastic sticker high
adhesive or can be hang on mail entrance
Warning To be place on door of eNB room on ODC or on shelter room, signages board to be place in form of
plastic sticker high adhesive or can be hang on main door
e.g)for RTP single pole & H Type Structure
Danger
Caution
Warning
9|Page
All are same except for H Pole, For H Pole need to place the danger board on H Pole Structure , if two H Pole located
on terrace , two danger board need to place
10 | P a g e
Caution To be place on main entrance door of terrace, signages board to be place in form of plastic sticker high
adhesive or can be hang on mail entrance
Warning To be place on door of eNB room on ODC or on shelter room, signages board to be place in form of
plastic sticker high adhesive or can be hang on main door
e.g) for wall mount & parapet structure
Danger
Caution
Warning
12 | P a g e
Parapet
For Parapet pole location , danger to be place on height of 4meter on all pole locations
13 | P a g e
Caution To be place on main door of eNB , signages board to be place in form of plastic sticker high adhesive or
in form of tin/fiber board can be hang on main entrance
Warning To be place on door of eNB room, signages board to be place in form of plastic sticker high adhesive or
or in form of tin/fiber board can be hang on main entrance
e.g) For GBM site
Typical GBM site location , warning & caution board to be installed on door of eNB & danger to be place on height
of 5 mtrs from the base
14 | P a g e
Caution To be place on main entrance , main gate entering to GBT sites , to be fix with help of clamp
Warning To be place on door of eNB room, signages board to be place in form of plastic sticker high adhesive
Caution
Warning
15 | P a g e
16 | P a g e
DOT Obligations:
Penalty of INR 5000 to be imposed on per signage's board of first verification, if the compliance is not received
With in 1 month from the inspection date, a penalty of INR 5000 per week shall be imposed there after, Subject to
limit of INR 50,000 per site per instance
Signage's board picture must require in EMF report mentioning their location
Signage's board & Colour should be as per the standard format & as per DOT guidelines
As during DoT audit, inspection person will check with the help of measuring tape for height, width & the location
if vary, site will be non-compliance and penalty to be imposed on operator
17 | P a g e
The End
18 | P a g e