Académique Documents
Professionnel Documents
Culture Documents
CNFE2MCPOE[/M]
INS_CNFE2MCPOE[/M]_REV
07/28/10
PAGE 1
CNFE2MCPOE[/M]
CAT5e/6
OPTICAL FIBER
DETERMINED BY
SELECTION OF
SFP MODULE
BLACK
BLACK WITH WHITE STRIPE
Power:
12VDC @ 3A, 24VDC@1.5A
NOTE: Remove Electrical
Connector for Rack Mount Units.
PoE is not supported when
mounted within ComNet rack.
REAR PANEL
INS_CNFE2MCPOE[/M]_REV
07/28/10
PAGE 2
CNFE2MCPOE[/M]
CAT5e/6
OPTICAL FIBER
DETERMINED BY
SELECTION OF
SFP MODULE
BLACK
BLACK WITH WHITE STRIPE
Power:
12VDC @ 3A, 24VDC@1.5A
REAR PANEL
INS_CNFE2MCPOE[/M]_REV
07/28/10
PAGE 3
CNFE2MCPOE[/M]
PSE1 or PSE2
POWER
GREEN
Unit powered up
OFF
SWITCH
ON
OFF
LINK
PSE1 / PSE2
ON
No (off)
OFF
ON
CAT5e/6 with
CAT5e/6 with
RJ45 Connections
RJ45 Connections
100m (328ft)
100m (328ft)
Network Element
Optical Fiber
Determined By
Selection Of SFP
Module
CNFE2MCPOEA
CNFE2MCPOEB
INS_CNFE2MCPOE[/M]_REV
07/28/10
PAGE 4
CNFE2MCPOE[/M]
INS_CNFE2MCPOE[/M]_REV
07/28/10
PAGE 5
CNFE2MCPOE[/M]
INSTALLATION CONSIDERATIONS
Th CNFE2MCPOE is supplied as a Rack Mount/Surface mount module. In the ComNet Rack, PoE operation is not supported. The CNFE2MCPOEM is
supplied as a Surface mount module. Units should be installed in dry locations protected from extremes of temperature and humidity.
WARNING: Unit is to be used with a Listed Class 2 power supply.
IMPORTANT SAFEGUARDS:
A) Elevated Operating Ambient - If installed in a closed or multi-unit rack assembly, the operating ambient temperature of the rack environment may be greater than
room ambient. Therefore, consideration should be given to installing the equipment in an environment compatible with the maximum ambient temperature (Tma)
specified by the manufacturer.
B) Reduced Air Flow - Installation of the equipment in a rack should be such that the amount of air flow required for safe operation of the equipment is not compromised.
FIGURE A
FIGURE B
INS_CNFE2MCPOE[/M]_REV
07/28/10
PAGE 6