Académique Documents
Professionnel Documents
Culture Documents
CNGE4US
10/100/1000 MBPS 4 PORT ETHERNET
UNMANAGED SWITCH
INS_CNGE4US_REV
07/22/09
PAGE 1
CNGE4US
UP TO 4
CONNECTIONS
AS DETERMINED
BY SELECTION OF
SFP MODULES
BLACK
BLACK WITH
WHITE STRIPE
Power Supply:
8-24 VDC @ 700 mA
FIGURE 2 CNGE4US
FRONT PANEL
REAR PANEL
PORT ACTIVITY
(1 4)
POWER
SOLID
No Activity
Unit powered up
BLINKING
Activity
OFF
No Link
INS_CNGE4US_REV
07/22/09
PAGE 2
FIGURE A
Dimensions are for a standard ComNet one slot module
2. Tighten the two thumb screws on the card until the front panel of
the card is seated against the front of the rack.
WARNING: Unit is to be used with a Listed Class 2 or LPS power supply rated
8-24 VDC @ 700mA.
IMPORTANT SAFEGUARDS:
A) Elevated Operating Ambient - If installed in a closed or multi-unit rack
assembly, the operating ambient temperature of the rack environment may
be greater than room ambient. Therefore, consideration should be given to
installing the equipment in an environment compatible with the maximum
ambient temperature (Tma) specified by the manufacturer.
B) Reduced Air Flow - Installation of the equipment in a rack should be such
that the amount of air flow required for safe operation of the equipment is
not compromised.