Académique Documents
Professionnel Documents
Culture Documents
Table of Contents
Multi-Zone
System Lineup . . . . . . . . . . . . . . . . . . . . . . . . . . . . 08
Single-Zone
9,000-36,000 Btu/h
18
LINE-HIDE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Qualified systems include the following products: coolingonly, heat pump, H2i Hyper-Heating INVERTER heat-pump,
2-to-1, and 3-to-1 multi-zone heat pump systems.
For details on tax credit requirements, visit
www.mitsubishicomfort.com/taxcredit, and for information
on available local rebate opportunities from state or utility
companies, visit www.dsireusa.org, which is a
U.S. Department of Energy information service.
Features
Benefits
INVERTER-driven
compressors
Easy installation
COmplete Zone
control
advanced
microprocessor
technology
Personal comfort
control
washable, long-life
anti-allergen filters
auto cool/heat
changeover
environmentally
friendly refrigerant
Sophisticated electronic control systems detect any changes in room or zone temperature andlike a cars cruise controlautomatically adjust the speed of the outdoor units
INVERTER-driven compressor and electronic linear expansion valve (LEV) position for
precise capacity control. The INVERTER-driven compressor is unlike those found in other
systems which only start and stop repetitively. Special components within the INVERTER
compressor such as high density windings in the motor that increase the magnetic flux,
and artificial magnets in the rotor to reduce its weight, allowi it to operate at higher energy
efficiencies with better performance than ever before, while producing low sound levels
both during start-up and operation.
MUZ-FE12NA
MUZ-FE12NA
MUZ-FE18NA
UNITARY
i-see Sensor
The i-see Sensor detects temperature variations in hardto-control ceiling and floor areas, and controls the airflow
up to a wide lateral angle for ultimate comfort (90 angle
in cooling mode).
By scanning the room and adjusting airflow based on
ambient temperature readings, MSZ-FE systems achieve
superior cooling/heating performance with extremely
efficient operation.
*Low Ambien t temper atu r e con dition s may r equ ir e base pan h eader (GE and F E 1:1 s y s tem s )
Superior Operation
Advanced Control Technology
Through Mitsubishi Electrics advanced controls technology,
the indoor unit is powered by the outdoor unit. Three
polarity sensitive wires plus a ground conductor run from
the outdoor to the indoor unit, providing both power and
data communication. An advanced wireless remote
control is standard on all ductless models. An optional
wired on-the-wall controller is available for wallmounted/floor-standing indoor units on INVERTER
systems (also requires MAC-397 If adapter). while
standard on SEZ-KD ducted units.
Quiet Operation
System Control
Police siren
118 decibels
Circular saw
107 decibels
Vacuum cleaner
74 decibels
Whisper-tone voice
35 decibels
Library reading room 33 decibels
Our Indoor Units
19 - 34 decibels
(at low speed)
whisper quiet
comfort
Easy to Maintain
healthier air
Total Comfort
Smart Set, featured on MSZ-GE
systems provides the option to
program multiple settings into one
quick-press feature, providing an
additional level of comfort control.
150
Front Panel
Hybrid Catechin
pre-filters
Blue Enzyme
anti-allergen filter
Front Panel
Hybrid Catechin
pre-filters
Platinum Catalyst
Deodorizing filter
Blue Enzyme
anti-allergen filter
Programmable Comfort
System Lineup
RESIDENTIAL AND LIGHT COMMERCIAL system models and controllers
S IN GL E - R OO M , WALL -M OU NT E D A / C
(cooling only)
MS Y /MU Y
A i r C ond i t i oners
3,800 t o 34,600 Bt u/h
C ap aci t y Range
15.1 - 21 S EER
MS/MU
Air Co ndit io ne r s
9,500 t o 12, 000 B t u /h
13 S E E R
Cooling-only system
INVERTER-driven compressor
WIDE VANE for a wider angle of airflow, 150 from
left to right (on GE24/D30/D36 models)
Ideal for spaces such as bedrooms, garages, large open
rooms and bonus rooms
Up to 26 SEER!
MS Z/MU Z- FE09/12N A
H i gh- Eff i ci ency H eat P ump s
28,00 t o 25,200 Bt u/H cap aci t y range
20.2 - 26 S EER
10 - 10.6 HSPF
INVERTER-driven compressor
Quiet operation as low as 19dB(A)
i-see Sensor technology
Enhanced filtration system
H2i high-heat capabilities (see page 12 &13)
MSZ-FE09 is 100 percent at 5 F
MSZ-FE12 is 92 percent at 5 F
MSZ-FE18 is 100 percent at 5 F
If your customer is looking for discrete zoned comfort, then a short-run ducted unit
is the right solution. As a stand-alone system or connected to a MXZ multi-room
system, the SEZ ducted units provide energy efficiency, quiet operation, and a
compact design for quick, easy installation hidden either in the ceiling or beneath
the floor.
All of the 1:1 systems are ENERGY STAR certified, and two systems qualify for
the federal tax credit. These systems provide customers with an environmentally
friendly indoor unit with a similar installation and familiar style.
These SEZ indoor units also connect to MXZ multi-zone systems, providing a wide
array of installation options to best fit any application.
SI N GLE- R OO M , C E IL IN G - R E C E S S E D CAS S E T T E U NI T
SLZ/SUZ
Heat Pumps
The SLZ-KA ceiling-recessed units casette offer a wide
3,100 to 22,200 Btu/H air-flow pattern for better air distribution in a less obtrusive
Ca pa c it y R a n g e
15 - 16 SEER
9.6 HSPF
W IR E L E S S a nd W I R E D R E M O T E CONT R OLL E R S
Wireless remote controller
for wall-mounted and
floor-standing indoor units
Operation
Select
(Heat, Cool,
Auto, Dry)
Fan Speed
Timer
Vane
Control
HR./MIN.
(Time Set)
Econo
Cool
SetTemperature
PAR-21MAA
On/Off
TimerMenu
FanSpeed
Mode
Filter
Test Run
SetTime
Check
Airflow Up/Down
TimerOn/Off
Louver
Smart Set
Button
Ventilation
Reset
TM
* SEZ and SLZ 1:1 systems with SUZ outdoor unit only
MR CH1
MIFH1
SEZ/SUZ
He a t P um p s
3, 800 t o 19, 0 0 0 B t u /H
Ca pa c it y R a n g e
15 SEER
17.5 - 10 HSPF
ms COOLING-ONLY
Non-inverter
Indoor Unit
Outdoor Unit
Model Name
Cooling *1
Power Supply
Voltage
MS-A12WA
MU-A12WA
12,000
Rated Capacity
Btu/h
9,500
Capacity Range
Btu/h
Total Input
870
1,070
Energy Efficiency
Moisture Removal
Sensible Heat Factor
Phase, Cycle, Voltage
Indoor - Outdoor L1-N
Indoor - Outdoor N-2
Indoor - Remote Controller
MCA
Fan Motor
SEER
Pints/h
Airflow (Lo-Med-Hi
Powerful)
Indoor Unit
MS-A09WA
MU-A09WA
A
F.L.A.
DRY (CFM)
WET (CFM)
dB(A)
13
2.7
3.2
0.68
0.70
1 Phase, 60Hz, 115V *2
AC 115V
AC 115V
Wireless Type
1.2
0.95
183-261-335-367
222-286-406-446
162-233-300-328
198-254-363-399
26-32-40-42
W: In.
D: In.
H: In.
11-3/4
Weight Unit
Field Drainpipe Size O.D.
Lbs.
In.
23
5/8
MCA
14
16
MOCP
(Time Delay) A
15
20
Fan Motor
F.L.A.
0.63
Model (Type)
Compressor
Outdoor Unit
Airflow
R.L.A.
9.3
L.R.A.
47
56
CFM
1,083
1,327
Weight
dB(A)
47
D: In.
11-1/4
11-7/16
H: In.
21-5/8
23-13/16
Lbs.
78
Type
Refrigerant
Type
Charge
Oil
Lbs., Oz.
Type (Fl. Oz.)
2, 5
In.
3/8
Connection Method
52
W: In.
Remote Controller
10.82
Capillary Tube
0.93
Single Rotary
Refrigerant Control
Sound Pressure Level
(Cooling) *1
Refrigerant Pipe
33-38-45
96
Wireless Remote
R410A
Ft.
3, 1
NE022 (10.8)
1/2
1/4
35
Length (Max.)
65
Indoor/Outdoor
Flared/Flared
10
Indoor Unit
Outdoor Unit
Model Name
Cooling *1
Power Supply
Voltage
9,000
12,000
14,000
17,200
22,500
30,700
34,600
3,800-12,200
3,800-13,600
8,200-31,400
1,800 (5703,580)
9,800-34,600
3,700-18,700
1,640 (2402,070)
9,800-30,700
Total Input
3,100-18,200
1,080 (1602,000)
Energy Efficiency
SEER
21
19.2
19
Moisture Removal
Sensible Heat Factor
Phase, Cycle, Voltage
Indoor - Outdoor S1 - S2
Indoor - Outdoor S2 - S3
Indoor - Remote Controller
MCA
Fan Motor
Pints/h
A
F.L.A.
DRY
(CFM)
WET
(CFM)
dB(A)
20.5
1.5
0.82
2.5
0.74
Charge
Oil
Connection
Method
2.7
4.6
0.75
0.71
1-phase, 60Hz, 208 / 230V *2
AC 208 / 230V
DC12-24V
Wireless Type (Optional Wired Controller: DC 12V)
1.0
0.76
205-272-335230-275-339388-469-628-738
420-533
420-533
170-237-300194-240-304347-420-562-661
385-498
385-498
109-134-201-286-364
16
15.1
9.9
0.64
11.9
0.62
389-639-848
350-576-763
34-41-49-53
32-42-49
Airflow (Cooling)
Refrigerant Control
Sound Pressure Level at Cooling *1 dB(A)
External Finish Color
W: In.
D: In.
Dimensions
Weight
Remote Controller Type
Type
2.7
0.80
145-170-237-321-399
31-7/16
9-1/8
11-5/8
22
Lbs.
Lbs.,
Oz.
Type
(fl. oz.)
In.
In.
Ft.
Ft.
43-5/16
9-3/8
12-13/16
37
46-1/16
11-5/8
14-3/8
40
17.1
20
21
25
5/8
14
12
15
0.50
0.93
DC INVERTER-driven
4.9
6.1
1,151
6.8
8.5
1,243
1,229
46
49
H: In.
Refrigerant Pipe
Length
MSY-D36NA
MUY-D36NA
Btu/h
Compressor
Refrigerant Pipe
MSY-D30NA
MUY-D30NA
MSY-GE24NA
MUY-GE24NA
Btu/h
Weight Unit
Field Drainpipe Size O.D.
MCA
MOCP
Fan Motor
Refrigerant
MSY-GE18NA
MUY-GE18NA
Rated Capacity
Dimension Unit
Outdoor Unit
Capacity Range
Airflow at Cooling
(Quiet-Lo-Med-Hi-Super Hi) *1
Indoor Unit
Tax
Credit
10.0
12.9
12.5
16.1
1,730
1,769
Linear Expansion Valve
54
Munsell No. 3Y 7.8 / 1.1
16
20
1,941
55
56
31-1/2
11-1/4
13
13
13
21-5/8
33-7/16
34-5/8
33-7/16
66
33-1/16
77
1, 12
80
119
Wireless Remote (Optional Wired Controller)
R410A
2, 9
3, 7
NEO22 (10.8)
NEO22 (15.2)
3/8
1/4
1/2
1/4
4, 3
FV50S (0.40)
NE022 (29.5)
5/8
3/8
40
65
Indoor/Outdoor
126
50
100
Flared/Flared
11
Tax
Credit
Indoor Unit
Outdoor Unit
Model Name
Cooling *1
Heating at 47 F *2
Heating at 17 F *3
Heating at 5 F
Power Supply
Voltage
Indoor Unit
MSZ-GE09NA
MUZ-GE09NA
Tax
Credit
MSZ-FE09NA
MUZ-FE09NA
Btu/h
9,000
9,000
12,000
12,000
14,000
Btu/h
3,800-12,200
2,800-9,000
3,800-13,600
2,800-12,000
3,100-18,200
Total Input
660 (205-1,200)
580 (160-650)
960 (205-1,300)
930 (160-960)
1,080 (160-2,000)
Energy Efficiency
SEER
21
26
20.5
23
21
Moisture Removal
Sensible Heat Factor
Rated Capacity
Capacity Range
Total Input
HSPF (IV)
Rated Capacity
Rated Total Input
Maximum Capacity
Maximum Capacity
Phase, Cycle, Voltage
Indoor - Outdoor S1 - S2
Indoor - Outdoor S2 - S3
Indoor - Remote Controller
MCA
Fan Motor
Pints/h
1.5
0.82
10,900
4,500-14,100
760 (255-1,200)
2.1
0.76
10,900
3,000-18,000
710 (150-2,250)
10
6,700
650
12,500
10,900
2.5
0.74
14,400
5,500-18,100
1,170 (340-1,660)
2.9
0.73
13,600
3,000-21,000
950 (150-2,250)
10.6
8,300
800
13,600
12,500
2.7
0.80
18,000
4,800-20,900
1,600 (270-2,010)
10
11,300
1,150
15,900
13,022
Btu/h
Btu/h
W
Btu/h/W
Btu/h
W
Btu/h
Btu/h
A
F.L.A.
Airflow at Cooling (Lo-Med-Hi-Super DRY (CFM)
HI-Powerful) *1
WET (CFM)
Airflow at Heating (Lo-Med-Hi-Super
WET (CFM)
HI-Powerful) *2
Sound Pressure Level at Cooling (LodB(A)
Med-Hi-Super HI-Powerful) *1
Sound Pressure Level at Heating
dB(A)
(Lo-Med-Hi-Super HI-Powerful) *2
6,600
700
8,700
7,061
145-170-237-321-399
109-134-201-286-364
8,800
900
11,200
9,194
1-phase, 60Hz, 208 / 230V *4
AC 208 / 230V
DC12-24V
Wireless Type (Optional Wired Controller: DC 12V)
1.0
0.76
162-226-339-381
145-170-237-321-399
162-226-381-410
144-202-307-343
109-134-201-286-364
144-202-350-367
145-170-237-321-406
166-240-367-381
145-170-237-321-406
166-240-399-420
205-247-304-367-463
19-22-30-37-43
22-31-39-42
19-22-30-37-45
22-33-43-45
26-32-38-44-49
19-22-30-37-43
22-31-40-42
19-22-30-37-43
22-33-43-44
26-30-35-40-46
31-3/8
10-1/8
31-7/16
9-1/8
27
22
0.56
0.50
Airflow (Cooling/Heating)
Refrigerant Control
Defrost Method
Sound Pressure Level at Cooling *1
Sound Pressure Level at Heating *2
External Finish Color
Dimensions
Weight
W: In.
D: In.
H: In.
Lbs.
In.
A
A
F.L.A.
31-7/16
9-1/8
31-3/8
10-1/8
22
27
0.50
R.L.A.
L.R.A.
CFM
6.6
8.2
1,151 / 1,225
0.56
DC INVERTER-driven Twin
Rotary
8.6
10.8
1,102 / 1,187
dB(A)
dB(A)
46
50
48
49
W: In.
D: In.
H: In.
Lbs.
66
80
DC INVERTER-driven
Type
Type
Charge
Oil
Gas Side O.D.
Liquid Side O.D.
Height Difference (Max.)
Length (Max.)
Indoor/Outdoor
205-272-335-420-533
170-237-300-385-498
Model (Type)
Compressor
Refrigerant Pipe
MSZ-GE15NA
MUZ-GE15NA
Capacity Range
Weight Unit
Field Drainpipe Size O.D.
MCA
MOCP
Fan Motor
Refrigerant
MSZ-FE12NA
MUZ-FE12NA
Rated Capacity
Dimension Unit
Remote Controller
Tax
Credit
Tax
Credit
MSZ-GE12NA
MUZ-GE12NA
Outdoor Unit
Tax
Credit
31-7/16
9-1/8
11-5/8
22
5/8
12
15
0.50
DC INVERTER-driven
6.6
8.2
1,229 / 1,172
Linear Expansion Valve
Reverse Cycle
8.6
10.8
1,102 / 1,187
7.4
9.3
1,243 / 1,229
49
51
Munsell No. 3Y 7.8 / 1.1
31-1/2
11-1/4
21-5/8
77
48
49
49
51
80
1, 12
2, 9
NEO22 (10.8)
3/8
1/4
NE022 (15.2)
1/2
1/4
40
65
Flared/Flared
(cont.)
Tax
Credit
Indoor Unit
Outdoor Unit
Model Name
Cooling *1
MSZ-GE18NA
MUZ-GE18NA
Power Supply
Voltage
17,200
18,000
22,500
30,700
33,200
8,200-25,200
8,200-31,400
9,800-30,700
9,800-33,200
Total Input
1,640 (240-2,070)
1,270 (570-2,280)
Energy Efficiency
SEER
19.2
20.2
19.0
Moisture Removal
Pints/h
4.6
2.7
2.7
9.9
11.3
0.71
0.84
0.75
0.64
0.62
14.5
Btu/h
21,600
21,600
27,600
32,600
35,200
Capacity Range
Btu/h
3,500-25,200
7,500-29,700
7,500-36,900
8,700-34,000
8,700-36,000
1,900 (230-2,680)
1,540 (520-2,240)
10
10.3
10
Total Input
Btu/h/W
Rated Capacity
Btu/h
13,400
11,700
16,000
19,500
1,450
2,180
3,290
2,400
2,820
Maximum Capacity
Btu/h
17,200
19,300
24,600
20,800
22,800
Maximum Capacity
Btu/h
13,562
21,600
21,160
16,305
19,090
A
F.L.A.
DRY (CFM)
230-275-339-420-533
388-469-628-738
388-469-628-738
389-639-848
WET (CFM)
194-240-304-385-498
347-420-562-661
347-420-562-661
350-576-763
230-275-339-431-512
388-469-628-738
388-469-628-738
445-639-848
28-33-38-44-49
34-41-49-53
34-41-49-53
32-42-49
28-33-38-43-48
32-41-49-52
32-41-49-52
34-42-49-49
W: In.
31-7/16
43-5/16
46-1/16
D: In.
9-1/8
9-3/8
11-5/8
H: In.
11-5/8
12-13/16
14-3/8
Weight Unit
Field Drainpipe Size O.D.
MCA
Lbs.
In.
A
22
37
14
17.1
21
MOCP
Fan Motor
A
F.L.A.
Model (Type)
15
20
25
Compressor
R.L.A.
10.0
12.9
L.R.A.
12.5
16.1
20
CFM
1,730 / 1,659
1,769 / 1,701
1,941
Refrigerant Control
Defrost Method
Sound Pressure Level at Cooling *1
Sound Pressure Level at Heating *2
External Finish Color
dB(A)
dB(A)
0.93
DC INVERTER-driven Twin Rotary
Weight
54
56
Lbs.
34-5/8
141
Type
R410A
Lbs., Oz.
Oil
33-7/16
119
Wireless Remote (Optional Wired Controller)
Charge
Gas Side O.D.
56
57
13
33-7/16
16
D: In.
H: In.
40
5/8
W: In.
Connection
Method
Rated Capacity
Dimensions
Refrigerant Pipe
MSZ-D36NA
MUZ-D36NA
3,700-18,700
Airflow
Refrigerant
MSZ-D30NA
MUZ-D30NA
Btu/h
Dimension Unit
Outdoor Unit
MSZ-GE24NA
MUZ-GE24NA
Btu/h
Indoor Unit
MSZ-FE18NA
MUZ-FE18NA
Capacity Range
Tax
Credit
Rated Capacity
Heating at 47 F *2
Tax
Credit
In.
Ft.
3, 7
4, 3
4, 10
NE022 (15.2)
FV50S (13.5)
NE022 (29)
1/2
5/8
1/4
3/8
50
100
Flared/Flared
13
Indoor Unit
Outdoor Unit
Model Name
Cooling *1
8,100
11,500
14,100
17,200
Btu/h
3,800-10,900
3,800-13,300
3,800-17,000
3,800-19,000
670
920
1,170
1,380
Total Input
Weight Unit
Field Drainpipe Size O.D.
MCA
MOCP
Fan Motor
Compressor
Airflow (Cooling/Heating)
Refrigerant Control
Defrost Method
Sound Pressure Level at Cooling *1
Sound Pressure Level at Heating *2
External Finish Color
Dimensions
W
SEER
Pints/h
Btu/h
Btu/h
W
Btu/h/W
Btu/h
W
Btu/h
A
F.L.A.
DRY (CFM)
WET (CFM)
In. W.G.
dB(A)
W: In.
D: In.
H: In.
Lbs.
In.
A
A
F.L.A.
Model
(Type)
R.L.A.
L.R.A.
CFM
dB(A)
dB(A)
15
1.5
0.80
10,900
4,800-14,100
1,020
16
15.5
17.5
2.4
2.6
3.4
0.76
0.80
0.79
13,600
18,000
21,600
4,800-16,400
4,800-21,100
4,800-24,900
1,140
1,500
1,700
10.0
6,700
9,000
11,900
13,100
810
920
1,200
1,350
7,300
9,800
13,700
15,000
1 Phase, 60Hz, 208 / 230V *4
AC 208-230V
DC 12-24V
See optional accessories chart (pg 26 and 27)
1
0.51
0.57
0.74
194-247-317
247-317-388
353-441-529
423-529-635
174-222-285
222-285-349
317-396-476
381-476-572
0.02-0.06-0.14-0.20
23-26-30
23-28-33
30-34-37
30-34-38
Galvanized-Steel Sheets
31-1/8
39
46-7/8
27-9/16
7-7/8
42
50
54
62
1-1/4
12
14
15
0.50
0.93
DC Inverter
6.6
8.2
1,151/1,225
46
50
W: In.
D: In.
H: In.
Weight
Remote Controller Type
Type
Charge
Refrigerant
Oil
Refrigerant Pipe
Length
Connection
Method
Lbs.
Lbs., Oz.
Type (fl.
oz.)
In.
In.
Ft.
Ft.
7.4
9.3
1,229/1,172
1,243/1,229
Linear Expansion Valve
Reverse Cycle
49
51
Munsell No. 3Y 7.8/1.1
31-1/2
11-1/4
10
12.5
1,730/1,659
54
56
33-1/6
13
21-5/8
33-7/16
66
77
80
119
See optional accessories chart (pg 26 and 27)
R410A
1, 16
2, 9
3, 16
Indoor/Outdoor
NEO22 (10.8)
NEO22 (15.2)
3/8
1/2
1/4
40
65
50
100
Flared/Flared
14
SEZ-KD18NA4
SUZ-KA18NA
Btu/h
Dimension Unit
Refrigerant Pipe
SEZ-KD15NA4
SUZ-KA15NA
Capacity Range
Airflow (Lo-Med-Hi)
Outdoor Unit
SEZ-KD12NA4
SUZ-KA12NA
Rated Capacity
Energy Efficiency
Moisture Removal
Sensible Heat Factor
Rated Capacity
Capacity Range
Heating at 47 F *2
Total Input
HSPF (IV)
Rated Capacity
Heating at 17 F *3 Rated Total Input
Maximum Capacity
Power Supply
Phase, Cycle, Voltage
Indoor - Outdoor S1 - S2
Voltage
Indoor - Outdoor S2 - S3
Indoor - Remote Controller
MCA
Fan Motor
Indoor Unit
SEZ-KD09NA4
SUZ-KA09NA
Tax
Credit
Middle
[0.04] [0.04]
Low Low
RatedRated
point point
0
0
[141] [141] [176] [176] [212] [212] [247] [247] [282] [282] [318] [318] [353] [353]
rate [CFM]
AirflowAirflow
rate [CFM]
Limit
Rated point
[212]
[247]
[282]
Airflow rate [CFM]
[318]
SEZ-KD15NA4
SEZ-KD15NA4
(External
(External
static static
pressure
pressure
0.02[in.WG])
0.02[in.WG])
208/230V
208/230V
60Hz 60Hz
SEZ-KD12NA4
SEZ-KD12NA4
208/230V 60Hz
Rated point
High
Middle
Middle
Rated point
Low
[0.08]
[0.04]
0
0
[212]
[141]
[318]
[353]
[282]
[212] Airflow[247]
rate [CFM][282]
Airflow rate [CFM]
[247]
[176]
[388]
[318]
[0.16]
[0.28]
[0.24]
[0.12]
High
[0.20]
Rated point
Middle
Low
[0.12]
0
[212]
[424]
V 60Hz
V 60Hz
[318]
[353]
[388]
[424]
[459]
Airflow rate [CFM]
[247]
ted point
Rated point
0V 60Hz
[494]
[282]
[318]
[353]
Airflow rate [CFM]
[530]
[388]
208/230V 60Hz
(External
50 static pressure 0.20[in.WG]) 208/230V 60Hz
High
High
Rated point
Middle
Middle
Low
Low
2010
[0.08]
[0.04]
Low
Rated point
Rated point
Low
Low
Low
[0.04]
[0.04]0
0
[282] [282]
[318] [318]
[353] [353]
[388] [388]
[424] [424]
[459] [459]
[494] [494]
[530] [530]
[565] [565]
0
0
Airflow Airflow
rate [CFM]
rate [CFM]
[212]
[247]
[282]
[318]
[353]
[388]
[424]
[318]
[353]
[388]
[424]
[212]
[247]
[282]
Airflow rateAirflow
[CFM]rate [CFM]
SEZ-KD18NA4
SEZ-KD18NA4
SEZ-KD15NA4
SEZ-KD15NA4
(External
(External
staticstatic
pressure
pressure
0.06[in.WG])
0.06[in.WG])
208/230V
208/230V
60Hz60Hz
(External
(External
static static
pressure
pressure
0.20[in.WG])
0.20[in.WG])
208/230V
208/230V
60Hz 60Hz
50 50
Limit
Limit Limit
Limit
70
70
[0.28]
40 [0.28]
40
[0.16][0.16]
High High
High High
Low
30
5030 50
[0.20]
[0.20]
[0.12][0.12]
40
40
[0.16] [0.16]
20 20
[0.08][0.08]
30
30
[0.12] [0.12]
2010 20
10
[0.08]
[0.08]
[0.04][0.04]
Low
RatedRated
pointpoint
Rated point
Rated point
Middle
Middle
Middle
Middle
Low Low
Low Low
RatedRated
pointpoint
10
10
[0.04] [0.04]
0
0
0 [318] [318]
0 [353] [353]
[388] [388]
[424] [424]
[459] [459]
[494] [494]
[530] [530]
[565] [565]
[600] [600]
[636] [636]
[671] [671]
[282] [282]
[318] [318]
[353] [353]
[388]
[388]
[424]
[424]
[459]
[459]
[494] [494]
[530] [530]
[565] [565]
Airflow
Airflow
rate [CFM]
rate
[CFM]
Airflow Airflow
rate [CFM]
rate [CFM]
[565]
[0.12]
[0.04] [0.04]
[0.08]
[0.08]
0
0
0 [318] 0
[318]
[353] [353]
[388] [388]
[424] [424]
[459] [459]
[494] [494]
[530] [530]
[565] [565]
[600] [600]
[636] [636]
[671] [671]
[282] [282]
[318] [318]
[353] [353]
[388]
[388]
[424]
[424]
[459]
[459]
[494] [494]
[530] [530]
[565] [565]
Airflow
Airflow
rate [CFM]
rate
[CFM]
Airflow Airflow
rate [CFM]
rate [CFM]
[424]
SEZ-KD18NA4
SEZ-KD18NA4
SEZ-KD18NA4
SEZ-KD18NA4
(External
(External
staticstatic
pressure
pressure
0.14[in.WG])
0.14[in.WG])
208/230V
208/230V
60Hz60Hz
(External
(External
staticstatic
pressure
pressure
0.20[in.WG])
0.20[in.WG])
208/230V
208/230V
60Hz60Hz
[0.32][0.32]
LimitLimit
LimitLimit
[0.28][0.28]
5030
[0.12]
[0.20]
[353] [388] [424] [459] [494] [530] [565] [600] [636] [671]
[318]
[353]
[388]
[459]
[494]
[530]
[565]
Airflow[424]
rate [CFM]
Airflow rate [CFM]
[0.28][0.28]
[0.24][0.24]
High High
[0.20][0.20]
[0.16][0.16]
Middle
Middle
RatedRated
pointpoint
[0.12][0.12]
Rated point
10
[0.04]
0
0 [318]
[282]
Middle
Middle
LimitLimit
70
[0.28]
40
[0.16]
40
[0.16]
20
[0.08]
30
[0.12]
[0.12]
Low Low
[0.20][0.20]
Middle
Middle
RatedRated
pointpoint
[0.16][0.16]
[0.12][0.12]
[0.08][0.08]
[0.08][0.08]
[0.04][0.04]
[0.04][0.04]
0
0
[318] [318]
[353] [353]
[388] [388]
[424] [424]
[459] [459]
[494] [494]
[530] [530]
[565] [565]
[600] [600]
[636] [636]
[671] [671]
High High
[0.24][0.24]
Low Low
0
0
[318] [318]
[353] [353]
[388] [388]
[424] [424]
[459] [459]
[494] [494]
[530] [530]
[565] [565]
[600] [600]
[636] [636]
[671] [671]
Airflow
Airflow
rate [CFM]
rate [CFM]
Airflow
Airflow
rate [CFM]
rate [CFM]
Note: ESP @ 208/230V, 60 Hz. See manual for Static Performance Curve, including @ 0.02 in W.G.
SEZ-KD18NA4
(External static pressure 0.20[in.WG]) 208/230V 60Hz
[0.32]
High
MiddleMiddle
Middle Middle
[0.16]
[0.16]
[0.08] [0.08]
[0.32][0.32]
60
[0.24]
High
Rated point
Rated point
MiddleMiddle
Low Low
SEZ-KD18NA4
SEZ-KD15NA4
(External static pressure 0.06[in.WG])
Limit
High High
[0.04] [0.04]
[0.20]
80
[0.32]
Limit
High High
[0.04][0.04]
[0.08] [0.08]
[0.04]
High High
Rated point
Rated point
High
60
60
[0.24] [0.24]
[0.12] [0.12]
Rated point
[0.24]
[0.12] [0.12]
[0.20]
[0.20]
Limit Limit
[0.08][0.08]
[0.16] [0.16]
High
Middle
[0.08]
[0.16]
0
[0.04]
[282]
[0.24]
[0.20]
80 [0.20]
80
[0.32] [0.32]
[0.20] [0.20]
[388]
[565]
Rated point
Rated point
Low
[0.12][0.12]
[0.24] [0.24]
[530]
Low
Limit
[0.28]
[0.16] [0.16]
[0.28]
LimitLimit
Low
494]
Low
Middle
[0.28] [0.28]
External static pressure [in.WG]
External static pressure [in.WG]
External
static pressure
[in.WG]
External
static pressure
[in.WG]
[0.08]
Middle
High
[0.16][0.16]
[0.32] [0.32]
Limit
[0.08]
ed point
Rated point
High
Rated point
MiddleMiddle
(External
(External
static static
pressure
pressure
0.14[in.WG])
0.14[in.WG])
208/230V
208/230V
60Hz 60Hz
Limit
High
point
High High
[0.16]
[0.12]
[0.12]
[0.04] [0.04]
[0.32]
High
[0.20]
SEZ-KD18NA4
SEZ-KD18NA4
SEZ-KD15NA4
SEZ-KD15NA4
(External
(External
staticstatic
pressure
pressure
0.02[in.WG])
0.02[in.WG])
208/230V
208/230V
60Hz60Hz
[0.20]
(External
static pressure 0.20[in.WG]) 208/230V 60Hz
Limit
Limit
[0.08] [0.08]
[0.16]
SEZ-KD12NA4
Limit
Limit
[0.04] 0 [0.04]
0
[282] [282]
[318] [318]
[353] [353]
[388] [388]
[424] [424]
[459] [459]
[494] [494]
[530] [530]
[565] [565]
0
0
Airflow Airflow
rate [CFM]
rate [CFM]
[424]
[212]
[247]
[282]
[318]
[353]
[388]
[424]
[212]
[247]
[282]
[318]
[353]
[388]
[424]
[353]
Airflow rateAirflow
[CFM]rate [CFM]
60Hz
[0.24]
Low
SEZ-KD15NA4
60Hz
[0.20]
[0.08]
[0.04]
[424]
[353]
[0.24]
Low
oint
[388]
[318]
[0.28]
[0.12] [0.12]
Limit
[0.12]
Limit
External
Externalstatic
staticpressure
pressure[in.WG]
[in.WG]
High
[0.16]
[0.08]
Low
Low
[0.32]
[0.32]
oint
High
Rated point
Rated point
Limit Limit
[0.32]
[0.28]
[0.24]
[0.12]
[0.20]
Middle
Low Low
[0.04] 0
[0.04]
0
[212]
[247]
[282]
[318]
[353]
[388]
[424]
[212]
[247]
[282]
[318]
[353]
[388]
[424]
0
0
Airflow rateAirflow
[CFM]rate [CFM]
[141] [141] [176] [176] [212] [212] [247] [247] [282] [282] [318] [318] [353] [353]
rate [CFM]
AirflowAirflow
rate [CFM]
High
Limit
External
static
pressure
[in.WG]
External
static
pressure
[in.WG]
Limit
Middle
[0.12] [0.12]
Limit Limit
[0.28]
[0.16]
High
High
Middle
Middle
[0.16] [0.16]
[0.08]
[0.08]
[0.32]
RatedRated
point point
[0.20] [0.20]
[0.04]
[0.04]
[0.08] [0.08]
Limit
Limit
(External
static pressure
0.20[in.WG])
208/230V
(External
static pressure
0.20[in.WG])
208/230V
60Hz 60Hz
[0.20] [0.20]
[0.16] [0.16]
[0.32]
High High
[0.24] [0.24]
[0.12]
[0.12]
SEZ-KD15NA4
SEZ-KD15NA4
(External
(External
static static
pressure
pressure
0.06[in.WG])
0.06[in.WG])
208/230V
208/230V
60Hz 60Hz
SEZ-KD12NA4
SEZ-KD12NA4
static pressure
0.14[in.WG])
208/230V
(External(External
static pressure
0.14[in.WG])
208/230V
60Hz 60Hz
(External
[0.20] static pressure 0.20[in.WG]) 208/230V 60Hz
External
Externalstatic
staticpressure
pressure[in.WG]
[in.WG]
60Hz
60Hz
RatedRated
point pointHigh
High
Middle
Middle
Middle Middle
Limit Limit
[0.16]
[0.16]
[0.28] [0.28]
SEZ-KD12NA4
(External static pressure 0.06[in.WG])
SEZ-KD09NA4
40
40
[0.16] [0.16]
External
static
pressure
[in.WG]
External
static
pressure
[in.WG]
[176]
Limit
Limit
High High
Rated point
Rated point
LowLow Low
Low
10
10
[0.04]
0
0[0.04]
[212]
[247]
[282]
[318]
[353]
[388]
[424]
[212]
[247]
[282]
[318]
[353]
[388]
[424]
0
0
Airflow rateAirflow
[CFM]rate [CFM]
[353]
[141] [141] [176] [176] [212] [212] [247] [247] [282] [282] [318] [318] [353] [353]
rate [CFM]
AirflowAirflow
rate [CFM]
point
0
[141]
60
60
[0.24] [0.24]
30
30
[0.12] [0.12]
[0.04]
[0.04]
20
20
[0.08] [0.08]
Middle
Low
[0.08]
[353]
[0.32] [0.32]
Limit Limit
50
50
[0.20] [0.20]
[0.08]
[0.08]
High
[0.12]
[0.04]
[318]
[0.20]
(External
pressure
0.20[in.WG])
208/230V
(External
staticstatic
pressure
0.20[in.WG])
208/230V
60Hz60Hz
70
70
[0.28] [0.28]
[0.12]
[0.12]
[0.16]
igh
80
80
[0.32] [0.32]
Limit
[0.16]
(External
pressure
0.14[in.WG])
208/230V
(External
staticstatic
pressure
0.14[in.WG])
208/230V
60Hz60Hz
[0.20]
SEZ-KD09NA4
SEZ-KD09NA4
[0.20]
static pressure
0.06[in.WG])
208/230V
(External(External
static pressure
0.06[in.WG])
208/230V
60Hz 60Hz
SEZ-KD09NA4
SEZ-KD09NA4
[0.16]
External
static pressure
[in.WG]
External
static pressure
[in.WG]
SEZ-KD09NA4
0Hz
SEZ-KD12NA4
SEZ-KD12NA4
static pressure
0.02[in.WG])
208/230V
(External(External
static pressure
0.02[in.WG])
208/230V
60Hz 60Hz
0
0
[141] [141] [176] [176] [212] [212] [247] [247] [282] [282] [318] [318] [353] [353]
rate [CFM]
AirflowAirflow
rate [CFM]
15
Indoor Unit
Outdoor Unit
Model Name
Rated Capacity
Capacity Range
Cooling *1
Heating at 47 F *2
Heating at 17 F *3
Power Supply
Voltage
Total Input
Energy Efficiency
Moisture Removal
Sensible Heat Factor
Rated Capacity
Capacity Range
Total Input
HSPF (IV)
Rated Capacity
Rated Total Input
Maximum Capacity
Phase, Cycle, Voltage
Indoor - Outdoor S1 - S2
Indoor - Outdoor S2 - S3
Indoor - Remote Controller
MCA
Fan Motor
SEER
Pints/h
Airflow (Lo-Med-Hi)
Indoor Unit
Btu/h
Btu/h
Btu/h
Btu/h
W
Btu/h/W
Btu/h
W
Btu/h
A
F.L.A.
DRY (CFM)
WET (CFM)
dB(A)
W: In.
D: In.
H: In.
Lbs.
In.
A
A
F.L.A.
Model (Type)
Compressor
Outdoor Unit
Airflow (Cooling/Heating)
Refrigerant Control
Defrost Method
Sound Pressure Level at Cooling *1
Sound Pressure Level at Heating *2
External Finish Color
Dimensions
R.L.A.
L.R.A.
CFM
dB(A)
dB(A)
W: In.
D: In.
SLZ-KA09NA
SUZ-KA09NA
SLZ-KA12NA
SUZ-KA12NA
SLZ-KA15NA
SUZ-KA15NA
8,400
3,100-10,900
11,100
3,100-13,300
15,000
3,100-22,200
700
920
1,460
15
1.2
0.80
10,900
3,100-14,100
930
15.4
16
2.3
4.5
0.76
0.80
13,600
18,000
3,100-17,100
3,100-17,100
1,180
1,950
9.6
6,200
8,300
10,200
740
930
1,310
8,300
10,200
12,000
1 Phase, 60Hz, 208 / 230V *4
AC 208-230V
DC 12-24V
See optional accessories chart (pg 26 and 27)
1
0.23
0.28
0.28
280-320-350
280-320-390
280-320-390
250-290-320
250-290-350
250-290-350
29-32-38
30-34-39
31-35-40
Galvanized-Steel Sheets; Grille: Munsell 6.4Y 8.9/0.4
22-7/16 (25-5/8)
22-7/16 (25-5/8)
8-3/16 (13/16)
36 (7)
1-1/4
12
15
0.50
DC INVERTER-driven
DC INVERTER-driven
Twin Rotary
6.6
7.4
8.2
9.3
1,151/1,225
1,229/1,172
1,243/1,229
Linear Expansion Valve
Reverse Cycle
46
49
50
51
Munsell No. 3Y 7.8/1.1
31-1/2
11-1/4
H: In.
Refrigerant
Refrigerant Pipe
Refrigerant Pipe Length
Connection Method
Weight
Type
Charge
Oil
Gas Side O.D.
Liquid Side O.D.
Height Difference (Max.)
Length (Max.)
Indoor/Outdoor
Lbs.
Lbs., Oz.
Type (fl. oz.)
In.
In.
Ft.
Ft.
21-5/8
66
77
R410A
1, 16
2, 9
NEO22 (10.8)
3/8
1/4
40
65
Flared/Flared
16
80
NEO22 (15.2)
1/2
Installs Anywhere
Function
Description
ON/OFF
Operation Mode
Temperature Setting
2-8F
Schedule Operation
5-2, 5-1-1
Hi/Mid-2/Mid-1/Low/Auto
Available fan speed settings dependant on connected system.
Permit/Prohibit Function
Space Temperature
Error Indication
Dimensions - (W x D x H)
Power Supply
2 AA batteries
SEZ IndoorUnit
18
Multi-Zone Overview
MSZ IndoorUnit
M UZ O utdoor Unit
19
Efficiency and performance ratings depend on the number, style, and capacity of the indoor units installed with
each Multi-Zone System.
MX Z- 2 B 2 0 N A - 1 (2 :1 )
M XZ- 3B 24N A ( 2: 1, 3: 1)
O u t d o o rU n i t
O u t door Un i t
SEZ-K D 1 2 NA
In d oor Un it
M SZ -GE09NA
I n d oor Units
MSZ-GE06NA
Indoor Unit
MSZ-GE06NA
Indoor Unit
M X Z -3 B 3 0 N A (2 :1 , 3 :1 )
O u t d o o r U n i t
MX Z - 4 B 3 6 N A
( 2 :1 , 4 :1 )
O u td o o rU n i t
M F Z - KD0 9 NA
In d o o r Un i ts
S E Z -K D 1 2 N A
I n d o or U n i t
M S Z - GE 0 9 NA
In d o o r Un i ts
(At least two indoor units
must be installed.)
M S Z- G E 0 6 N A
I nd o o r U n it
M F Z- KD12NA
I n do or Unit
S E Z - KD1 2 NA
In d o o r Un i t
M X Z- 8 B 4 8 N A ( 2 :1 - 8:1)
O u t d oorU n i t
Branch Box; Minimum of
one required with MXZ8B
(At least two
indoor units
must be
installed)
PEAD Horizontal-DUCTED
INDOOR UNIT
PEAD-A24AA
SEZ Horizontal-DUCTED
INDOOR UNIT
SEZ-KD18NA
20
MSZ-FE18NA
Outdoor Unit
MXZ-2B20NA-1 *5
MXZ-3B24NA *6
MXZ-3B30NA
Btu/h
18,000/20,000
22,000/23,600
28,400/27,400
35,400/34,400
Btu/h
W
Btu/h
Btu/h
7,800-20,000
2,190 (630-2,190)
22,000/22,000
8,500-25,500
12,600-25,500
2,460 (1,000-2,950)
25,000/24,600
11,400-30,600
12,600-28,400
3,330 (1,000-3,330)
28,600/27,600
11,400-36,000
12,600-36,400
3,940 (1,000-4,020)
36,000/34,400
11,400-43,000
2,620 (520-2,620)
1,900 (740-2,600)
2,220 (740-2,820)
3,100 (740-3,940)
Btu/h
W
Btu/h
W
A
A
F.L.A.
Model
(Type)
Compressor
R.L.A.
L.R.A.
Airflow (Cooling/Heating) CFM
Refrigerant Control
Defrost Method
Sound Pressure Level at
dB(A)
Cooling *1
Sound Pressure Level at
dB(A)
Heating *2
External Finish Color
W: In.
Dimensions
D: In.
H: In.
Weight
Lbs.
No. of Units
Type
Type
Charge
Lbs., Oz.
Type (fl.
Oil
oz.)
Gas Side O.D.
In.
Liquid Side O.D.
In.
Height Difference (Max.) Ft.
Length (Max.)
Ft.
Indoor/Outdoor
Outdoor Unit *4
Indoor Unit
Remote Controller
Refrigerant
Refrigerant Pipe
Refrigerant Pipe Length
Connection Method
12,500/12,500
1,350/1,430
14,500/14,500
1,500/1,590
0.96
14,000/14,000
16,000/15,100
1,380/1,570
2,120/2,140
18,800/17,000
18,800/18,000
2,120/2,230
2,120/2,140
1-phase, 60Hz, 208 / 230V *8
AC 208 / 230V
DC12-24V
15
20
0.93
MXZ-4B36NA *7
22,200/20,300
2,430/2,340
24,600/25,400
3,340/3,450
Multi-Zone Specifications
Rated Capacity
Cooling *1
Non-ducted/ Capacity Range
Ducted
Total Input
Heating at
Rated Capacity
47 F *2
Capacity Range
Indoor Unit
Non-ducted/
Total Input
Ducted
Rated Capacity
Heating at
Rated Total Input
17 F *3
Non-ducted/ Maximum Capacity
Ducted
Maximum Total Input
Power Supply
Phase, Cycle, Voltage
Indoor - Outdoor S1 - S2
Voltage
Indoor - Outdoor S2 - S3
MCA
MOCP
Fan Motor
19
11
15
14.4
1,485/1,640
2,068/1,605
1,365/1,605
Linear Expansion Valve
Reverse Cycle
2,068/2,068
49
54
49
51
54
49
57
33-1/16
13
27-15/16
130
2
5, 15
NEO22 (23.7)
153
2, 3, 4
8, 13
NEO22 (29.4)
A,B: 3/8
164 (A+B)
230 (A+B+C+D)
*Compatible with the MSZ-A, MSZ-GA, MSZ-FD, MSZ-FE, MSZ-GE, MFZ-KA and SEZ-KD series indoor units (PLA-18 & PCA-24 on the MXZ-MXZ-3B / PLA-24 & PCA-24 on the MXZ-4B)
NOTES: Test conditions are based on AHRI 210/240. One indoor unit is turned off during low-speed testing under the new test conditions. Systems actually exhibit higher energy efficiencies
during normal operation.
*1. Rating conditions (cooling)-Indoor: D.B. 80 F (27 C), W.B. 67 F (19 C); Outdoor: D.B. 95 F (35 C), W.B. 75 F (24 C).
*2. Rating conditions (heating)-Indoor: D.B. 70 F (21 C), W.B. 60 F (16 C); Outdoor: D.B. 47 F (8 C), W.B. 43 F (6 C).
*3. Rating conditions (heating)-Indoor: D.B. 70 F (21 C), W.B. 60 F (16 C); Outdoor: D.B. 17 F (-8 C), W.B. 15 F (-9 C).
*4. Refer to pages 12 and 13 for Indoor Unit specifications.
*5. Data from combination of two Indoor Units 9,000 Btu/h (non-ducted) or one 9,000 Btu/h and one 12,000 Btu/h (ducted).
*6. Data from combination of two Indoor Units 6,000 Btu/h and one 9,000 Btu/h (non-ducted) or three 9,000 Btu/h (ducted).
*7. Data from combination of four Indoor Units 9,000 Btu/h (non-ducted and ducted).
*8. Indoor units receive power from outdoor units through field-supplied interconnected wiring.
*9. 49 Applies to installations where the outdoor unit is installed below the indoor unit.
Power factor equals 97 percent.
Specifications are subject to change without notice.
Multi- zone EN E R GY S TA R
and Tax C redit S ystems
Mode l
SE E R
HSPF
MXZ-2B 20NA-1
2 x MSZ-GE09 N A
18
8.9
MXZ-3B 24NA
2 x MSZ-GE06N A
1 x MSZ-GE09N A
17.5
9.3
MXZ-3B 24NA
2 x MSZ-GE06 N A
1 x MSZ-GE12 N A
17.5
9.3
21
M XZ- 8B 48N A ( 2: 1 - 8: 1)
O ut door Un i t
The MXZ-8B48NA has only one port on the outdoor unit for two
insulated refrigerant lines, which run into the home or business
to connect to a branch box or boxes. From the, branch box(es),
gas, and liquid refrigerant piping run to each of the indoor units.
The LEV in the branch box(es) controls the refrigerant flow as the
load of each zone changes.
Through the branch box(es) (the PAC-AKA31BC three-port and/or
the PAC-AKA51BC five-port), the system can connect from two
indoor units up to eight indoor units, depending on application
requirements.
The flexibility of the system doesnt stop there. The MXZ-8B48NA
has rated capacities of 48,000 Btu/h for cooling and 54,000
Btu/h for heating. System operation, however, can range from a
minimum 12,000 Btu/h to a maximum 54,000 Btu/h in cooling and
a maximum of 60,000 Btu/h in heating. This type of performance
supports a large variety of applications.
The MXZ-8B48NA allows for further flexibility because it supports
a connected indoor unit capacity from 22% to 130% or 12,000
Btu/h to a maximum 70,200 Btu/h, depending on diversity.
22
Indoor Unit
Heating at
47 F *2 Nonducted/Ducted
Power Supply
Rated Capacity
Btu/h
48,000 / 48,000
Maximum Capacity
Btu/h
54,000
Rated Capacity
Btu/h
54,000 / 54,000
Maximum Capacity
Btu/h
60,000
Rated Capacity
Btu/h
33,000 / 34,700
Maximum Capacity
Btu/h
4,820 / 5,270
2,950 / 3,390
36,600 / 36,550
1 Phase, 60Hz, 208 / 230V
Indoor - Outdoor S1 - S2
AC 208-230V
Indoor - Outdoor S2 - S3
MCA
Recommended Fuse/Breaker
Size
Fan Motor
Compressor
Airflow (Cooling/Heating)
Refrigerant Control
Sound Pressure Level at
Cooling *1
Outdoor Unit
DC12-24V
A
32
40
Type x Quantity
Propeller x 2
0.086 + 0.086
Model (Type)
Motor Output (kW)
CFM
54
dB(A)
55
Munsell No. 3Y 7.8 / 1.1
37-7/16
D: In.
13+1-3/16
Weight
Total Capacity 22-130%
H: In.
Lbs.
Btu/h
53-3/16
278
12,000 - 70,200
Type
Type
Refrigerant
Refrigerant Pipe
Charge
Lbs., Oz.
Oil
In.
5/8
In.
3/8
Ft.
66/98 *4
Ft.
230
Ft.
49
Ft.
197*
18, 11.2
FV50S (73)
Dimensions
Model / Quantity
2.9
3,530
W: In.
Remote Controller
*1.
*2.
*3.
*4.
DC INVERTER-driven Scroll
Indoor Unit
5,780 / 6,470
Voltage
MXZ-8B48NA
Multi-Zone Specifications
Heating at
17 F *3 Nonducted/Ducted
Outdoor Unit
Ft.
377
Indoor/Outdoor
Flared/Flared
Branch Boxes:
Model Name
Connectable No. of Indoor Units
Power Supply
PAC-AKA51BC
Power Input
Current
0.05
External Finish
PAC-AKA31BC
Dimensions
Galvanized-Steel Sheets
Width
In.
Depth
In.
11
Height
In.
7-3/4
Net Weight
Refrigerant Pipe
Dimensions
Lbs.
17-3/4
19
21
5/8
3/8
Gas (In.)
A,B,C: 3/8
Liquid (In.)
A,B,C: 1/4
In.
23
Model Name
Indoor Unit
Cooling *1
Rated Capacity
Btu/h
Heating at 47
Rated Capacity
Btu/h
F *2
Power Supply Phase, Cycle, Voltage
Indoor - Outdoor S1 - S2
Indoor - Outdoor S2 - S3
Voltage
Indoor - Remote Controller
MCA
A
Fan Motor
F.L.A.
Airflow at Cooling
(Quiet-Lo-Med-HiSuper Hi or Lo-MedHi-Powerful)*1
Fan
Airflow at Heating
(Quiet-Lo-Med-HiSuper Hi or Lo-MedHi-Powerful) *2
Sound Pressure Level at Cooling
(Quiet-Lo-Med-Hi-Super Hi or LoMed-Hi-Powerful) *1
Sound Pressure Level at Heating
(Quiet-Lo-Med-Hi-Super Hi or LoMed-Hi-Powerful) *2
External Finish Color
Dimension Unit
Weight Unit
Field Drainpipe Size O.D.
Remote ConType
troller
Refrigerant
Type
Gas Side O.D.
Refrigerant
Pipe
Liquid Side O.D.
Connection
Method
6,000
9,000
9,000
12,000
12,000
14,000
17,200
18,000
22,500
7,200
10,900
10,900
14,400
13,600
18,000
21,600
21,600
27,600
388-469628-738
388-469628-738
347-420562-661
347-420562-661
388-469628-738
388-469628-738
DRY
(CFM)
145-170-237-321-399
WET
(CFM)
109-134-201-286-364
WET
(CFM)
145-170233-321406
145-170237-321406
145-170237-321406
166-240399-420
205-247304-367463
230-275339-431512
dB(A)
19-22-30-37-43
22-31-39-42
19-22-3037-45
22-33-43-45
26-32-3844-49
28-33-3844-49
34-41-49-53 34-41-49-53
dB(A)
19-22-30-37-43
22-31-40-42
19-22-3037-43
22-23-43-44
26-30-3540-46
28-33-3843-48
32-41-49-52 32-41-49-52
W: In.
D: In.
H: In.
Lbs.
In.
9-1/8
10-1/8
22
27
43-5/16
9-3/8
12-13/16
37
9-1/8
22
3/8
1/2
5/8
3/8
1/4
Indoor/Outdoor
Flared/Flared
*MXZ-2B20NA is also compatible with the MSZ-A and MSZ-FD series indoor units.
NOTES: Test conditions are based on AHRI 210/240.
*1. Rating conditions (cooling)-Indoor: D.B. 80 F (27 C), W.B. 67 F (19 C); Outdoor: D.B. 95 F (35 C), W.B. 75 F (24 C).
*2. Rating conditions (heating)-Indoor: D.B. 70 F (21 C), W.B. 60 F (16 C); Outdoor: D.B. 47 F (8 C), W.B. 43 F (6 C).
*3. Indoor units receive power from outdoor units through field-supplied wiring.
Specifications are subject to change without notice.
LIMITEDWARRANTY Seven-year warranty on compressor. Five-year warranty on parts. For data on specific indoor unit combinations, see page 21.
Model Name
Cooling *1
Rated Capacity
Heating at 47 F *2
Power Supply
Rated Capacity
Phase, Cycle, Voltage
Indoor - Outdoor S1-S2
Voltage
Indoor - Outdoor S2-S3
MCA *4
Fan Motor Output
Fan
Airflow (Lo-Med-Hi)
External Static Pressure *3
Sound Pressure Levels (Lo-Med-Hi)
External Finish
Dimension
Weight
Drain Lift Mechanism (Included)
Field Drainpipe Size
Remote Controller
Type
Refrigerant
Type
Gas Side O.D.
Refrigerant Pipe
Liquid Side O.D.
Connection Method
24
9,000
Btu/h
10,900
A
W
CFM
In. W.G.
dB(A)
W: In.
D: In.
H: In.
Lbs.
H: In.
In.
In.
12,000
15,000
17,200
13,600
18,000
1-Phase, 60Hz, 208 / 230V *4
AC 208-230V
DC24V
1.0
96
247-317-388
353-441-529
0.02-0.06-0.14-0.20
23-28-33
30-34-37
Galvanized-steel Sheets
39
27-9/16
7-7/8
46
51
21-11/16
O.D.: 1-1/4
Wired Controller (PAR-21MAA)
R410A
194-247-317
23-26-30
31-1/8
40
3/8
21,600
Notes:
*1. Cooling-Indoor: D.B. 80 F (26.7 C),
W.B. 67 F (19.4 C); Outdoor: D.B. 95 F
(35 C), W.B. 75 F (23.9 C).
*2. Heating-Indoor: D.B. 70 F (21.1 C),
W.B. 60 F (15.6 C); Outdoor: D.B. 47 F
(8.3 C), W.B. 43 F (6.1 C).
423-529-635
30-34-38
46-7/8
60
LIMITEDWARRANTY Seven-year
warranty on compressor. Five-year
warranty on parts.
**For data on specific indoor unit
combinations, see page 21 - 23.
1/2
1/4
Flared/Flared
SEZ-KD18NA4
Model Name
MFZ-KA09NA
MFZ-KA12NA
MFZ-KA18NA
12,000
18,000
Cooling *1
Rated Capacity
Btu/h
9,000
Heating at 47 F *2
Power Supply
Rated Capacity
Phase, Cycle, Voltage
Indoor - Outdoor S1 - S2
Indoor - Outdoor S2 - S3
Indoor - Remote Controller
MCA
Btu/h
10,900
Voltage
Fan
Airflow at Heating
(Lo-Med-Hi-Super Hi) *2
Sound Pressure Level at Cooling
(Lo-Med-Hi-Super Hi) *1
Sound Pressure Level at Heating
(Lo-Med-Hi-Super Hi) *2
External Finish Color
Weight Unit
Field Drainpipe Size O.D.
Remote Controller
Type
Refrigerant
Type
Gas Side O.D.
Refrigerant Pipe
Liquid Side O.D.
Connection Method Indoor/Outdoor
177-215-261-321
251-279-325-394
163-197-241-303
170-207-252-309
241-269-313-379
(CFM)
177-198-219-332
184-201-219-335
261-275-297-434
dB(A)
25-30-35-40
26-31-36-41
35-38-42-46
dB(A)
25-30-35-40
28-31-36-41
35-38-42-47
In.
In.
sLZ Ceiling-recessed
INDOOR UNIT
Model Name
Heating at 47
F *2
Power Supply
Indoor Unit
Rated Capacity
Btu/h
8,400
11,100
15,000
Rated Capacity
Btu/h
10,900
13,600
18,000
Efficiency Ratings
Notes:
*1. Cooling-Indoor: D.B. 80 F (26.7 C),
W.B. 67 F (19.4 C); Outdoor: D.B. 95 F
(35 C), W.B. 75 F (23.9 C).
*2. Heating-Indoor: D.B. 70 F (21.1 C),
W.B. 60 F (15.6 C); Outdoor: D.B. 47 F
(8.3 C), W.B. 43 F (6.1 C).
169-205-251-314
W: In.
D: In.
H: In.
Lbs.
In.
Dimension Unit
21,600
Mode l
Indoor Unit Ty pe
M XZ-2B20N A-1
M XZ-2B20N A-1
EN ERGY STAR &
TAX C REDIT
M XZ-3B24N A
SEER
HS P F
N o n-ducted
18
8.9
16.75
8.7
Ducted
15.5
8.5
2 x M SZ-GE09N A
18
8.9
N o n-ducted
17.5
9.3
16.25
8.9
Ducted
15.0
8.5
M XZ-3B24N A
EN ERGY STAR &
TAX C REDIT
2 x M SZ-GE06N A
1 x M SZ-GE09N A
17.5
9.3
M XZ-3B24N A
EN ERGY STAR &
TAX C REDIT
2 x M SZ-GE06N A
1 x M SZ-GE12N A
17.5
9.3
N o n-ducted
17.5
10.5
M XZ-3B30N A
16
10.0
Ducted
14.5
9.5
M XZ-4B36N A
M XZ-8B48N A
N o n-ducted
18
9.3
16.5
9.2
Ducted
15.0
9.0
N o n-ducted
15
8.7
14.8
8.8
Ducted
14.7
8.9
25
Multi-Zone Specifications
Airflow at Cooling
(Lo-Med-Hi-Super Hi)*1
A
DRY
(CFM)
WET
(CFM)
14,400
1-phase, 60Hz, 208 / 230V *3
AC 208 / 230V
DC12-24V
Wireless Type
1
M-Series RATINGCONDITIONS
Outdoor Intake
Air Temperature
Maximum
Minimum
Maximum
Cooling
Heating
Minimum
* MU units operate at intake air temperature down to 10 F with the addition of an ICM-326HM-1 low temperature control.
REFRIGERANTTUBINGSETS
Lineset
Model Number
Tube Length
Insul.
Size (In.) Ft.
MLS143812T-15
1/4 x 3/8
15
1/2"
MLS143812T-30
1/4 x 3/8
30
1/2"
MLS143812T-50
1/4 x 3/8
50
1/2"
MLS143812T-65
1/4 x 3/8
65
1/2"
MLS141212T-15
1/4 x 1/2
15
1/2"
MLS141212T-30
1/4 x 1/2
30
1/2"
MLS141212T-50
1/4 x 1/2
50
1/2"
MLS141212T-65
1/4 x 1/2
65
1/2"
MLS141212-100
1/4 x 1/2
100
1/2"
MPLS385812T-10
3/8 x 5/8
10
1/2"
MPLS385812T-15
3/8 x 5/8
15
1/2"
MPLS385812T-30
3/8 x 5/8
30
1/2"
MPLS385812T-50
3/8 x 5/8
50
MSY/Z-GE24NA,
MSY/Z-D30,36NA; MXZ-8B48NA,
1/2"
MSZ-FE18NA
MPLS385812T-65
3/8 x 5/8
65
1/2"
MPLS385812T-100
3/8 x 5/8
100
1/2"
MS-A09WA; MSZ-GE06NA;
MSY/Z-GE09,12NA;
MSZ-FE09,12NA;
SEZ-KD09,12NA;
MFZ-KA09,12NA
SLZ-KA09, 12, 15NA
MS-A12WA; MSY/Z-GE15,18NA;
SEZ-KD12,18NA;
MFZ-KA18NA; SLZ-KA18
Indoor Unit
MS-A09WA
MS-A12WA
MSY-GE09NA
MSY-GE12NA
MSY-GE15NA
MSY-GE18NA
MSZ-GE09NA
MSZ-GE12NA
MSZ-GE15NA
MSZ-GE18NA
MSY-GE24NA
MSZ-GE24NA
MSY-D30NA
MSZ-D30NA
MSY-D36NA
MSZ-D36NA
MSZ-FE09NA
MSZ-FE12NA
MSZ-GE06,09,12,15NA;
MSZ-FE09,12NA;
MFZ-KA09,12NA;
SEZ-KD09,12,15NA
MSZ-GE06,09,12,15,18NA;
MSZ-FE09,12, 18N;
MFZ-KA09,12,18NA;
SEZ-KD09,12,15,18NA
SLZ-KA09, 12, 15NA
Outdoor Unit
Length Height
in feet in feet
MU-A09WA
MU-A12WA
MUY-GE09NA
MUY-GE12NA
MUY-GE15NA
MUY-GE18NA
MUZ-GE09NA
MUZ-GE12NA
MUZ-GE15NA
MUZ-GE18NA
MUY-GE24NA
MUZ-GE24NA
MUY-D30NA
MUZ-D30NA
MUY-D36NA
MUZ-D36NA
MUZ-FE09NA
MUZ-FE12NA
65
65
65
65
65
100
65
65
65
100
100
100
100
100
100
100
65
65
35
35
40
40
40
50
40
40
40
50
50
50
50
50
50
50
40
40
MXZ-2B20NA-1
164
49*/33
MXZ-3B24NA
164
49*/33
MSZ-GE06,09,12,15,18NA;
MSZ-GA24NA,
MSZ-FE09,12, 18NA;
MFZ-KA09,12,18NA;
SEZ-KD09,12,15,18NA
SLZ-KA09, 12, 15NA
MXZ-3B30NA
230
49*/33
MSZ-GE06,09,12,15,18NA;
MSZ-GE24NA,
MSZ-FE09,12, 18NA;
MFZ-KA09,12,18NA;
SEZ-KD09,12,15,18NA
SLZ-KA09, 12, 15NA
MXZ-4B36NA
230
49*/33
MSZ-GE06,09,12,15,18NA;
MSZ-GE24NA,
MSZ-FE09,12, 18NA;
MFZ-KA09,12,18NA;
SEZ-KD09,12,15,18NA
SLZ-KA09, 12, 15NA
MXZ-8B48NA
377
66*/98
OPTIONALACCESSORIES
PART NUMBER
MAC-A454JP-E
MAC-A455JP-E
MAC-A456JP-E
MSDD-50AR-E
MSDD-50BR-E
PAC-493PI
PAC-SG76RJ-E
USE WITH
MXZ-Series
MXZ-Series
MXZ-Series
MXZ-Series Branch Box
MXZ-Series Branch Box
MXZ-Series
MXZ-Series
DESCRIPTION
Port Adapters and Connection Pipes
Adapter: 3/8" X 1/2"
Adapter: 1/2" X 3/8"
Adapter: 1/2" X 5/8"
Tee Distribution Pipe - Flare Connection between two branch boxes
Tee Distribution Pipe - Braze Connection between two branch boxes
Adapter: 1/4" X 3/8"
Adapter: 3/8" X 5/8"
26
*49' & 66' applies to installations in which the outdoor unit is installed below indoor unit.
OPTIONALACCESSORIES (continued)
PART NUMBER
USE WITH
DESCRIPTION
Control Options and Accessories
Remote temperature sensor for M-Series indoor units
MA and contact terminal interface - Required to use PAR-21MAA wired, wall mount controller
with M-Series Systems
MAC-397IF-E
MAC-399IF-E
CMCN M-NET control adapter / Interface for Mr. Slim M-Series MSY/Z, SEZ / MFZ
PAC-YU25HT
PAR-FL32MA
SEZ
Wireless remote controller for SEZ units (Requires signal receiver PAR-SA9FA-E)
PAR-SA9CA-E
SEZ
TAZ-MS303
M-Series
ICM-326HM-2
MAC-641BH-U
MAC-1415FT-E
MAC-2300FT
MAC-308FT
MAC-408FT-E
MAC-415FT-E
MAC-418FT
MSZ/MSY-D30/36
MSY/MSZ-GA24
MSZ-FD9/12 / FE09/12
M-Series Indoor Unit - GE09/GE12/GE15/GE18
MFZ-KA
MSZ- FD9/12 / FE09/12
FBL1-1
PAR-21MAA-G
MAC-640BH-U
FBL1-2
Deluxe MA remote controller (Requires MAC-397IF-E for use with M-Series - MSY/Z, MFZ)
3-pole disconnect switch; 30A, 600V; turns off power between indoor and outdoor units mounts in 2 X 4 utility box and requires standard single gang switch plate/cover
Low Ambient
Low ambient head pressure controller
Drain pan heater
Drain pan heater
Filters
Anti-allergy enzyme filter
Anti-allergy enzyme filter
Platinum deodorizing filter
Anti-allergy enzyme filter
Air Cleaning Filter/Anti-Allergy Enzyme Filter
Anti-allergy enzyme filter
Filter Boxes
Optional filter box with MERV 8 filters
Optional filter box with MERV 8 filters
FBL1-3
SI1730-230
SI3100-115
MS-Series - non-INVERTER
SI3100-230
BRP-1
Miscellaneous
Converts low profile ducted indoor unit from rear return to bottom return
BRP-2
Converts low profile ducted indoor unit from rear return to bottom return
BRP-3
BV12FSI
BV14FSI
BV38FSI
BV58FSI
Converts low profile ducted indoor unit from rear return to bottom return
Refrigeration Ball Valve-Flare/Schrader/Insulated - 1/2"
Refrigeration Ball Valve-Flare/Schrader/Insulated - 1/4"
Refrigeration Ball Valve-Flare/Schrader/Insulated - 3/8"
Refrigeration Ball Valve-Flare/Schrader/Insulated - 5/8"
CWMB1
Condensing unit wall mounting brackets (set of 2) - 440 lb. capacity: painted steel NOTE:
Installer is responsible to select and provide suitable hardware and materials to insure proper
mount of bracket to wall
DSD-400N
MAC-851DS
MAC-855SG
MAC-856SG
MAC-860DS
MAC-889SG
MAC-899SG
M-Series
MUZ-GE18 / MUZ(Y)-D30/36 /
SUZ-KA18
MUZ-FD09/12
M-Series
M-Series
MUZ-GE09/12/15 / MUZ-FE09/12
M-Series
M-Series
PAC-SG59SG-E
MXZ-8B48NA
PAC-SG61DS-E
PAC-SG64DP-E
RCMKP1CB
ULTRILITE1
MXZ-8B48NA
MXZ-8B48NA
M-Series Wireless
All M-Series
Pumps
MAC-811DS
27
Unit Port
Size
2-zone combinations w/
both units 12K
N/A
A: 3/8" x
1/4"
6+15
1-MAC-A454JP-E
B: 3/8" x
1/4"
9+15
1-MAC-A454JP-E
Combinations
MXZ-2B20NA-1
Combinations
Qty.
Qty.
N/A
N/A
1-MAC-A454JP-E
N/A
1-MAC-A454JP-E
1-MAC-A454JP-E
1-PAC-SG76RJ-E
1-PAC-SG76RJ-E
1-MAC-A454JP-E
1-PAC-SG76RJ-E
1-PAC-SG76RJ-E
1-PAC-SG76RJ-E
1-PAC-SG76RJ-E
MXZ-8B48NA
MXZ-3B24NA
All rated 2-zone combinations
N/A
A: 1/2" x
1/4"
15+24 or 18+24
N/A
B: 3/8" x
1/4"
24+24
C: 3/8" x
1/4"
MXZ-3B30NA
2-zone combinations w/ at
least one unit 12K
N/A
A: 1/2" x
1/4"
2-zone combinations w/
both units 15K
1-MAC-A454JP-E
B: 3/8" x
1/4"
9 + 24
1-MAC-A456JP-E
C: 3/8" x
1/4"
3-zone combinations w/
all units 12K
1-MAC-A455JP-E
N/A
N/A
1-MAC-A454JP-E
N/A
1-MAC-A454JP-E
1-MAC-A454JP-E
1-MAC-A454JP-E
1-MAC-A454JP-E
1-PAC-SG76RJ-E
1-PAC-SG76RJ-E
1-MAC-A454JP-E
1-PAC-SG76RJ-E
1-PAC-SG76RJ-E
1-MAC-A454JP-E
1-MAC-A454JP-E
MXZ-4B36NA
2-zone combinations w/ at
least one unit 12K
N/A
A: 1/2" x
1/4"
2-zone combinations w/
both units 15K
1-MAC-A454JP-E
B: 3/8" x
1/4"
6 + 24
1-MAC-A456JP-E
C: 3/8" x
1/4"
9 + 24
1-MAC-A456JP-E
D: 3/8" x
1/4"
3-zone combinations w/ at
least two units 12K
N/A
3-zone combinations w/
two units 15K
1-MAC-A454JP-E
6+6+24 or 6+9+24
1-MAC-A456JP-E
9+9+24
1-MAC-A456JP-E
4-zone combinations w/ at
least three units 12K
1-MAC-A455JP-E
6+6+15+15
1-MAC-A454JP-E
6+6+15+15
1-MAC-A454JP-E
28
N/A
1-PAC-SG76RJ-E
1-PAC-SG76RJ-E
1-PAC-SG76RJ-E
1-PAC-SG76RJ-E
1-MAC-A454JP-E
1-PAC-SG76RJ-E
1-PAC-SG76RJ-E
MXZ-8B48NA
Branch Box
Branch Box
PAC-AKA31BC
PAC-AKA51BC
Wall-Mounted
MSZ-GE06/09/12NA
MSZ-GE15/18NA
MSZ-GE-24NA
MSZ-FE09/12/18NA
Floor-Standing
MFZ-KA09/12NA
MFZ-KA18NA
PLA-A12/18BA
PLA-A24BA
PLA Ceiling-Cassette
Horizontal Ducted
SEZ-KD09/12NA
SEZ-KD15/18NA
PEAD-A24AA
BV14FFSI
BV38FFSI
BV12FFSI
BV58FFSI
US
LISTED 891N
REFRIGERANT
VALVE
SAE
Flare
BV14FFSI
1/4
6.19
2.60
1.80
1.22
1.42
1.10
BV38FFSI
3/8
6.30
2.67
1.80
1.22
1.42
1.10
BV12FFSI
1/2
6.51
2.67
1.80
1.22
1.42
1.10
BV58FFSI
5/8
6.64
2.67
1.80
1.28
1.42
1.10
Platform Stands
Lift the Mitsubishi Electric Comfort Solution
outdoor unit to new heights with our
Diamondback Platform Stands.
Easy to install
Available for all sizes of Mr. Slim outdoor units
Color matched to the outdoor units
Model Number: DSD-400N
L: 15-3/4 x W: 3-1/4 x H: 3-1/4
29
Linesets
Caps on
Lineset
Model Number
Tube
Size (In.)
Length
Ft.
Insul.
MLS143812T-15
MLS143812T-30
MLS143812T-50
MLS143812T-65
MLS141212T-15
MLS141212T-30
MLS141212T-50
MLS141212T-65
MLS141212T-100
1/4 x 3/8
1/4 x 3/8
1/4 x 3/8
1/4 x 3/8
1/4 x 1/2
1/4 x 1/2
1/4 x 1/2
1/4 x 1/2
1/4 x 1/2
15
30
50
65
15
30
50
65
100
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
MLS145812T-15
MLS145812T-30
MLS145812T-50
MLS145812T-65
MLS145812T-100
MPLS385812T-10
MPLS385812T-15
MPLS385812T-30
MPLS385812T-50
1/4 x 5/8
1/4 x 5/8
1/4 x 5/8
1/4 x 5/8
1/4 x 5/8
3/8 x 5/8
3/8 x 5/8
3/8 x 5/8
3/8 x 5/8
15
30
50
65
100
10
15
30
50
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
MPLS385812T-65
3/8 x 5/8
65
1/2"
MPLS385812T-100
3/8 x 5/8
100
1/2"
Filter Boxes
FBL1-1
FBL1-2
FBL1 filter boxes include 1" thick pleated MERV 8 filter(s) installed.
Filters are tested in accordance with ANSI/ASHRAE Standard 52.2
and Rated Class 2 under U.L. Standard 900.
FBL1-3
30
Line - Hide
Lineset Cover System
TM
31
2011 Mitsubishi Electric & Electronics USA, Inc. Mr Slim and H2i are
registered trademarks of Mitsubishi Electric. The three-diamond logo is a
registered logo of Mitsubishi Electric Corporation.
*Hyper-Heating technology Patent Pending.
See complete warranty for terms, conditions and limitations.
A copy is available from Mitsubishi Electric.
facebook.com/mehvac
twitter.com/mitsubishihvac
twitter.com/mitsubishihvac
Please Recycle