Académique Documents
Professionnel Documents
Culture Documents
No : PE/21-WO/1539/15
DATE : 28.07.15
GBA SIZE, MM
S.NO
1
2
3
W.O.NO
1539
1539
1539
ITEM CODE
TUBESHEET
1500
TUBESHEET
1850
TUBESHEET
2850
TOTAL
QTY (Nos.)
800 65 + 12
1900 65 + 12
1900 65 + 12
1
1
1
3
3. GENERAL REQUIREMENTS :
3.1. Cladded Plates supplied to this specification shall confirm to the latest issue of applicable specification - ASTM B 432,
SA 20 and SA 578 with additional requirements mentioned below.
3.2. Cladding shall be done by Explosion bonding out of free isuue materials supplied along with material identification reports.
3.3. Repair of cladding by welding not permitted.
3.4. Cladded plate shall be stress relieved at 620C for 135 minutes minimum.
SHT 1 OF 2
PREPARED BY
CHECKED BY
APPROVED BY
ENGINEER, DESIGN
PRECISION EQUIPMENTS
(CHENNAI) PVT . LTD,
CHENNAI
HEAD, QA
TECHNICAL SPECIFICATION
FOR
B 432 CLADDED PLATES
GM-PROJECTS
SPEC No.
PE/432/CLAD
REV.
0
W.O.No : PE/21-WO/1539/15
DATE : 28.07.15
3.5. Tensile test of base plate shall be carried out after removal of clad plate and the tensile result
shall meet the base metal requirements.
3.6. All clad plates shall be shear tested. The strength of bond shall be 10 kg/mm^2 minimum.
3.7. All clad plates shall be UT tested in accordance with SA 578 with acceptance standard level C
Scanning shall be 100% surface area from clad side.
3.8. UT test shall be conducted after the specified Heat Treatment.
3.9. Good bond area of plate shall be marked for reference.
3.10. Hardness of base plate after cladding and heat treatment shall be < 180 BHN (Maximum).
3.11. Cladded plates after cladding and heat treatment shall be substantially flat and acceptance
shall be within 2 mm.
4. CERTIFIED DOCUMENTS :
Supplier shall furnish certified documents for the tests carried out as per specification B 432 as a
minimum.
4.1. Mechanical test for base metal and shear strength for clad plate.
4.2. Data of heat treatment of clad plate-Heat chart duly reviewed and certified by TPI.
4.3. Ultrasonic Examication witness and certification by TPI. Sketch showing good bond area duly certified
by TPI along with report.
4.4. Method of cladding
4.5. Date of cladding shall be indicated in MTC.
4.6. MTC shall be in accordance with EN 10204 Type 3.2 Certification.
5. SCOPE FOR TPI INSPECTION :
5.1. Identification of Base Plate & Clad Plate.
5.2. Witnessing of Mechanical test after cladding.
5.3. Witnessing of Ultrasonic testing after cladding.
5.4. Witnessing of final dimensions and flatness.
5.5. Final certification and issue of IRN.
SHT 2 OF 2
PREPARED BY
CHECKED BY
APPROVED BY
ENGINNER,DESIGN
PRECISION EQUIPMENTS
(CHENNAI) PVT . LTD,
CHENNAI
HEAD, QA
TECHNICAL SPECIFICATION
FOR
B 432 CLADED PLATES
GM-PROJECTS
SPEC No.
PE/432/CLAD
REV.
0