Académique Documents
Professionnel Documents
Culture Documents
BS EN 1435
BS EN 444
BS EN 462 Part 1 Image Quality Indicators and recommendations for their use
Replaces BS 3971
BS 2737 (current)
1)
Focal spot or source size and strength should be displayed on the apparatus and
evidence of this should be available.
2)
3)
4)
5)
6)
7)
8)
9)
Film storage.
Appendix 2
(manual operation)
BS EN 12668
Part 1
Part 2
Part 3
BS 2704 (current)
Method of UT examination of
1)
2)
Correct calibration blocks are available with evidence of dimensional checks having
been carried out
3)
4)
Appendix 2
BS EN 3059
BS EN 1330
Part 1
1)
2)
3)
Check fluorescent and red penetrant comparison of filter papers by eye or black light
monitor. Check for water contamination. Add 50% by volume to manufacturers
quoted water tolerance. If penetrant turns milky it is above the water tolerance
specified.
4)
5)
6)
7)
a)
b)
Wet developer (Visual inspection for red. Black light inspection for fluorescent)
Dry developer (Visual inspection for dampness eg.Grey in colour, not fluffy. Black
light inspection for fluorescent
8)
9)
10) Check level of white light for red dye operation (Minimum 500 Lux)
20 Lux or
Appendix 2
BS EN 3059
BS EN 1330
BS 5044 (current)
BS 89 (current)
1)
2)
Ammeter checks. Difference between check ammeter and m/c ammeter shall not
exceed 10% of scale reading. Note check ammeter shall be calibrated to traceable
standard
3)
4)
Test for solid content and general condition of inks, agitate ink, place sample of
100ml into settlement flask, allow to settle for 60 minutes. Read off result to nearest
0.1 ml. Record as solid content by volume. Special test for fluorescent inks: Check
ink for evidence of yellow green fluorescence in the supernatant liquid. If observed
discard the ink
5)
commencing with the hole nearest the surface. powder should be applied at a
distance of 200300mm At least 5 holes should give an indication
Magnetic flow technique for inks and powders: Use test piece Fig 4 BS 4069
Magnetise test piece parallel to coil axis or use electro-magnets. The hole should
give and indication. Aerosol containers should be date stamped
6)
Corrosion test: Use low carbon steel bar 150mm long 12.5mm with surface
texture of 3.2 m RA. Partially immerse the bar in ink sample form minimum of 12
hours at 25 C There should be no evidence of corrosion
7)
8)
9)