Académique Documents
Professionnel Documents
Culture Documents
IPN = 10 mA
VPN = 10 .. 500 V
16084
Features
Electrical data
IPN
Primary nominal current rms
IPM
Primary current, measuring range
RM
Measuring resistance
with 12 V
@ 10 mA max
@ 14 mA max
with 15 V
@ 10 mA max
@ 14 mA max
ISN
Secondary nominal current rms
K N
Conversion ratio
VC
Supply voltage ( 5 %)
IC
Current consumption
10
0 .. 14
RM min
mA
mA
RM max
30 190
30 100
100 350
100 190
25
mA
2500 : 1000
12 .. 15
V
10 (@ 15 V) + IS mA
%
%
%
mA
mA
mA
s
General data
TA
TS
RP
RS
m
0 .. + 70
C
- 25 .. + 85
C
250
110
22
g
EN 50178: 1997
Principle of use
For voltage measurements,
a current proportional to the
measured voltage must be
passed through an external
resistor R1 which is selected by
the user and installed in series
with the primary circuit of the
transducer.
Advantages
Excellent accuracy
Very good linearity
Low thermal drift
Low response time
High bandwidth
High immunity to external
interference
Low disturbance in common
mode.
Applications
AC variable speed drives and
servo motor drives
Static converters for DC motor
drives
Battery supplied applications
Uninterruptible Power Supplies
(UPS)
Power supplies for welding
applications.
Application domain
Industrial.
Page 1/3
20November2012/version 18
LEM reserves the right to carry out modifications on its transducers, in order to improve them, without prior notice
www.lem.com
2.5 1)
16
Min
19.5
19.5
175
kV
kV
mm
mm
Applications examples
According to EN 50178 and IEC 61010-1 standards and following conditions:
Over voltage category OV 3
Pollution degree PD2
Non-uniform field
dCp, dCI, Vw
EN 50178
IEC 61010-1
Nominal voltage
Basic insulation
1600 V
1600 V
Reinforced insulation
800 V
800 V
Safety
Page 2/3
20November2012/version 18
LEM reserves the right to carry out modifications on its transducers, in order to improve them, without prior notice
www.lem.com
Mechanical characteristics
General tolerance
Fastening & connection of primary
Fastening & connection of secondary
Recommended PCB hole
Remarks
0.2 mm
2 pins
0.635 0.635 mm
3 pins 1 mm
1.2 mm
20November2012/version 18
LEM reserves the right to carry out modifications on its transducers, in order to improve them, without prior notice
www.lem.com