Académique Documents
Professionnel Documents
Culture Documents
1 (2007-08)
Technical Report
Reference
RTR/SES-00288
Keywords
antenna, earth station, GSO, satellite
ETSI
650 Route des Lucioles
F-06921 Sophia Antipolis Cedex - FRANCE
Tel.: +33 4 92 94 42 00 Fax: +33 4 93 65 47 16
Siret N 348 623 562 00017 - NAF 742 C
Association but non lucratif enregistre la
Sous-Prfecture de Grasse (06) N 7803/88
Important notice
Individual copies of the present document can be downloaded from:
http://www.etsi.org
The present document may be made available in more than one electronic version or in print. In any case of existing or
perceived difference in contents between such versions, the reference version is the Portable Document Format (PDF).
In case of dispute, the reference shall be the printing on ETSI printers of the PDF version kept on a specific network drive
within ETSI Secretariat.
Users of the present document should be aware that the document may be subject to revision or change of status.
Information on the current status of this and other ETSI documents is available at
http://portal.etsi.org/tb/status/status.asp
If you find errors in the present document, please send your comment to one of the following services:
http://portal.etsi.org/chaircor/ETSI_support.asp
Copyright Notification
No part may be reproduced except as authorized by written permission.
The copyright and the foregoing restriction extend to reproduction in all media.
European Telecommunications Standards Institute 2007.
All rights reserved.
TM
TM
TM
DECT , PLUGTESTS and UMTS are Trade Marks of ETSI registered for the benefit of its Members.
TM
TIPHON and the TIPHON logo are Trade Marks currently being registered by ETSI for the benefit of its Members.
TM
3GPP is a Trade Mark of ETSI registered for the benefit of its Members and of the 3GPP Organizational Partners.
ETSI
Contents
Intellectual Property Rights ................................................................................................................................5
Foreword.............................................................................................................................................................5
Introduction ........................................................................................................................................................5
1
Scope ........................................................................................................................................................7
References ................................................................................................................................................7
3.1
3.2
3.3
3.4
Definitions..........................................................................................................................................................8
Symbols..............................................................................................................................................................8
Abbreviations .....................................................................................................................................................8
Mathematical formulas.......................................................................................................................................8
5.1
5.2
5.3
5.3.1
5.3.2
5.3.3
5.3.3.1
5.3.3.2
5.3.3.3
5.3.4
5.4
6
6.1
6.2
6.3
6.4
6.5
6.6
6.7
6.8
6.9
6.10
6.11
7
7.1
7.1.1
7.1.2
7.1.3
7.1.4
7.2
8
8.1
8.2
8.3
9
9.1
9.2
9.3
Excel tool................................................................................................................................................75
General .............................................................................................................................................................75
Cell colours ......................................................................................................................................................76
Constants ..........................................................................................................................................................76
ETSI
9.4
9.5
9.6
9.6.1
9.6.2
9.6.3
9.6.4
9.6.5
9.6.6
9.6.7
9.6.8
9.6.9
9.6.10
9.6.11
9.6.12
9.6.13
9.6.14
9.7
9.7.1
9.7.2
Buttons .............................................................................................................................................................76
Input data..........................................................................................................................................................77
Functions and Subroutines ...............................................................................................................................78
Function Azimuth().....................................................................................................................................78
Function Elevation() ...................................................................................................................................79
Function Phi_Az() ......................................................................................................................................79
Function Phi_El()........................................................................................................................................80
Functions Phi_cos_Alpha() and Phi_sin_Alpha().......................................................................................80
Function Inclination_with_Az_El_mount() ................................................................................................81
Function Inclination_with_E_field_alignment().........................................................................................81
Function Inclination_with_equatorial_mount() ..........................................................................................81
Function Az_El_mount_alignment_error().................................................................................................82
Function Az_El_mount_with_E_field_alignment_error()..........................................................................82
Function Equatorial_mount_alignment_error() ..........................................................................................83
Function Max_satellite_longitude_offset().................................................................................................83
Subroutine GSO_external_contour() ..........................................................................................................83
Subroutine GSO_internal_contour() ...........................................................................................................85
Output data and graphs.....................................................................................................................................86
General........................................................................................................................................................86
GSO shadow for a given ES and a given pointed satellite..........................................................................86
History ..............................................................................................................................................................88
ETSI
Foreword
This Technical Report (TR) has been produced by ETSI Technical Committee Satellite Earth Stations and Systems
(SES).
The present document is intended to be used as a guideline to assist with the measurement methods of the compliance
with the off-axis EIRP density limits for the protection of the GSO arc specified within the Harmonized standards
applicable to satellite earth stations. The present document is intended to be cited in the harmonized standards as a non
normative document, with its reference listed in the bibliography.
The TR 102 375 Excel tool is contained in archive tr_102375v010201p0.zip which accompanies the present document.
Introduction
Most of the harmonized European standards (ENs) applicable to satellite Earth Stations (ESs), prepared in ETSI by the
TC SES, contain off-axis e.i.r.p density limits for the protection of other satellites on the Geostationary Satellite Orbit
(GSO) and in its vicinity: within 3 north/south. These limits are based on the relevant ITU-R Recommendations and
Regulations such as ITU-R Recommendations S.728-1 [1], S.580-6 [2], S.465-5 [3], S.524-8 [4], ITU-R
Resolution 902 [5]. For non-symmetrical antenna patterns around their main beam axis, the requirement for the
protection of the GSO arc may be limited to the off-axis directions towards the visible part of GSO arc. For verification
of the conformance with the applicable EN of earth stations fitted with antennas with non-symmetrical patterns, it is
necessary to provide guidelines for determining the parts of satellite earth station antenna radiation patterns concerned
by the geostationary satellite orbit protection.
The purpose of the present document is to provide a method for the determination of the range of off-axis directions
which could be oriented towards the visible part of GSO according to the following operational parameters:
1)
2)
3)
4)
5)
the minimum offset angle, relative to the satellite position, on the GSO from which protection of the GSO arc
is required.
ETSI
The GSO arcs is presented in various coordinate systems, e.g. geocentric for an observer far from the Earth,
tropocentric for an observer located at the earth station, in a Cartesian coordinate system defined on the
antenna for an observer located at the antenna flange, in a polar coordinate system defined on the antenna
which will be use to determine the plane containing the antenna main beam axis, concerned by the GSO
protection.
The contours of the mapping on the antenna radiation patterns where the shadow of the GSO arcs may occur,
for various type of antenna mount.
The coordinate system used within the present document (see figure 6) may be different from other antenna
coordinate systems. In particular, the present document uses the x-axis as the antenna main beam axis instead
of the z-axis.
The effect of the alignment error of the antenna mount axes on the contours of theses mappings.
The mathematical analysis used for the determination of the GSO shadow and the contours of the mappings.
A presentation of the Excel tool implementing the mathematical method and provided with the present
document.
The Excel tool provided with the present document has been developed on the base of the present document and may be
used to obtain indicative results, but in any case neither ETSI, nor the ETSI technical committee members who prepared
and approved the present document and the tool are responsible of the errors which may remains nor for the direct or
indirect consequences of those errors.
ETSI
Scope
The present document provides a method for the determination of the range of off-axis directions which could be
oriented towards the visible part of GSO according to the following operational parameters:
1)
2)
3)
4)
5)
the minimum East-West offset angle, relative to the satellite position, on the GSO from which protection of the
GSO arc is required; and
6)
in the case of an antenna designed for operation with a specific list of satellites, the minimum distance of the
antenna to the sub-satellite points at the surface of the Earth.
specified within the standard (e.g. the minimum antenna main beam axis elevation is equal to 7); or
References
For the purposes of this Technical Report (TR), the following references apply:
[1]
ITU-R Recommendation S.728-1: "Maximum permissible level of off-axis e.i.r.p density from
very small aperture terminals (VSATs)".
[2]
ITU-R Recommendation S.580-6: "Radiation diagrams for use as design objectives for antennas of
earth stations operating with geostationary satellites".
[3]
[4]
ITU-R Recommendation S.524-8: "Maximum permissible levels of off-axis e.i.r.p density from
earth stations in geostationary-satellite orbit networks operating in the fixed-satellite service
transmitting in the 6 GHz, 13 GHz, 14 GHz and 30 GHz frequency bands".
[5]
ITU-R Resolution 902 (WRC-03): "Provisions relating to earth stations located on board vessels
which operate in fixed-satellite service networks in the uplink bands 5 925-6 425 MHz and
14-14,5 GHz".
ETSI
3.1
Definitions
For the purposes of the present document, the following terms and definitions apply:
antenna azimuth axis (Az-axis): direction towards the left hand side and parallel to the horizontal plane when the
antenna is oriented towards the South
antenna elevation axis (El-axis): direction parallel to the local vertical when the antenna is oriented towards the South
with its main beam axis horizontal
antenna main beam axis: direction where the antenna gain is maximum
applicant: manufacturer or his authorized representative within the European Community or the person responsible for
placing the apparatus on the market
azimuth: angle of the projection of the considered direction on the local horizontal plane with the local North direction
elevation: angle of the considered direction with the local horizontal plane
GSO vicinity: band within 3 of the GSO on the sphere of radius = 42 164 km around the Earth
3.2
Symbols
For the purposes of the present document, the following symbols apply:
rad
radian
the antenna azimuth axis inclination variation or equivalent value
3.3
Abbreviations
For the purposes of the present document, the following abbreviations apply:
Az
Az-El
e.i.r.p
El
EN
ES
ESV
FSS
GPS
GSO
ITU
ITU-R
Lt
SES
TC
VSAT
WRC
3.4
Azimuth angle
Azimuth-Elevation
equivalent isotropically radiated power
Elevation angle
European standard (Norm)
Earth Station
Earth Station on board a Vessel
Fixed Satellite Service
Global Positioning System
Geostationary Satellite Orbit
International Telecommunication Union
ITU - Radio sector
Latitude
Satellite Earth station and Systems
Technical Committee
Very Small Aperture Terminal
World Radiocommunication Conference
Mathematical formulas
For the purposes of the present document, the following mathematical formulas will be used:
ETSI
x2 = 9
( a b ) = (b a )
r r r r r r
( a b ) .c = a.(b c )
r r r r r r
a
( b ) .c = c.( a b )
0
( x) =
1
Sign ( x ) = 0
+1
=
ArcTan2 ( x, y ) =
= +
ar br .br
1
a = r 2 .
b
((
thevalueof xisincrementedby 2
) ) .b = b .( a b )
rr r r r r
( a.b ) .b + ( a b ) b
2
for x < 0
, the Heaviside function,
for x 0
(1)
(2)
for x < 0
for x = 0 , the "sign of" function,
for x > 0
rad if a 0
rad if a < 0
x = a.sin ( )
for :
y = a.cos ( )
(3)
(4)
Several ITU-R Recommendations and Resolutions specify off-axis eirp density limits for the protection of the satellites
within 3 of the GSO arc as it could be seen within the following examples:
The ITU-R Recommendation S.728-1 [1] applicable to Ku band Very Small Aperture Terminals (VSATs)
recommends "that VSAT earth stations operating with geostationary satellites in the 14 GHz frequency band
used by the FSS be designed in such a manner that at any angle specified below, off the main-lobe axis of an
earth-station antenna, the maximum EIRP in any direction within 3 of the GSO should not exceed" the
specified values and for 2.
The ITU-R Recommendation S.580-6 [2] recommends design objectives for antenna radiation diagrams of
earth stations operating with geostationary satellites which should be met for any off-axis direction which is
within 3 of the GSO and for which: min 20 where min is a function of the antenna diameter and the
wave length and for an greater off-axis angles, , that the ITU-R Recommendation S.465-5 [3] should be used.
ITU-R Recommendation S.524-8 [4] (Maximum permissible levels of off-axis EIRP density from earth
stations in geostationary-satellite orbit networks operating in the fixed-satellite service transmitting in the
6 GHz, 14 GHz and 30 GHz frequency bands) recommends "that GSO networks in the FSS operating in the
6 GHz frequency band be designed in such a manner that at any angle, , which is 2,5 or more off the main
lobe axis of an earth station antenna, the EIRP density in any direction within 3 of the GSO should not
exceed" the specified limit. In Ka band the minimum value of is 2. Additionally for Ku and Ka bands, "for
any direction in the region outside 3 of the GSO, the specified limits may be exceeded by no more than 3 dB".
The ITU-R Resolution 902 (WRC-03) [5] applicable to Earth Stations located on board Vessels (ESVs)
requires that: "at any angle , etc., off the main-lobe axis of an earth-station antenna, the maximum EIRP in
any direction within 3 of the GSO shall not exceed" the specified limits for 2,5 in C band and for 2
in Ku band.
ETSI
10
and:
The ITU-R Recommendation S.580-6 [2] in "Note" recommends 3 that: "When elliptical beam antennas are
used the side-lobe radiation in the direction of the GSO can be reduced if the minor axis of the beam (major
axis of the antenna) is oriented so that it is parallel to the GSO". Further study is required on the application of
this Recommendation in the case of the minor axis of the antenna which would correspond with a D / < 50.
The present document is intended to show how to compute which parts of the antenna radiation pattern are affected by
any of these requirements - antenna radiation patterns or the e.i.r.p. density - in order to provide protection of the
satellites within the vicinity of the GSO.
5.1
From the space the GSO is a circle of radius = 42 164 km around the Earth and the GSO vicinity is the band within 3
of the GSO on the sphere of radius around the Earth.
North pole
3
3
Earth
GSO vicinity
GSO
ETSI
11
5.2
Only one portion of the GSO arc above the horizon is visible from an earth station. The GSO arc and the limits of the
GSO vicinity look like ellipses.
GSO
GSO vicinity
r
D
Horizon
South
Horizontal
plane
East
El
Az
North
r
D may be defined by:
the elevation angle (El) of the direction with the horizontal plane; and
the azimuth angle (Az) of the projection of that direction on the horizontal plane with the local North direction.
In figure 3, the GSO arc and its vicinity are represented as a function of the elevation (El) and azimuth (Az) for different
values of the earth station latitude (Lt).
90
80
70
60
50
El
Lt = 5/N
Lt = 45/N
40
30
20
Lt = 75/N
10
0
Az -180
-10
-105 -90 -75 -60 -45 -30 -15 0 15 30 45 60 75 90 105
Figure 3: Azimuth (Az) and elevation (El) of the GSO arc and its vicinity
for different values of the earth station latitude (Lt)
ETSI
12
5.3
An ES antenna may be represented by its reflector or the -3 dB contour of its 3-dimension (3-D) antenna radiation
pattern.
Antenna El axis
Main beam axis
Antenna Az axis
Front view
- 3 dB contour
Lateral view
Antenna diagram
Antenna reflector
the antenna main beam axis: the direction where the antenna gain is maximum;
the antenna azimuth axis (Az-axis): the direction towards the left hand side and parallel to the horizontal plane
when the antenna is oriented toward the South;
the antenna elevation axis (El axis): the direction parallel to the local vertical when the antenna is oriented
toward the South with its main beam axis horizontal.
ETSI
13
The directions of these 3 axis are dependent on the antenna orientation as shown in figure 5.
Antenna El axis
GSO vicinity
Horizon
South
East
El
Az
North
r
D from the antenna may be defined by a couple (Az, El) of angles, represented in figure 6, and where:
the angle Az is the angle of the projection of the considered direction on the plane orthogonal to the antenna
elevation axis (El axis) with the antenna main beam axis (Az-axis); and
the angle El is the angle of the considered direction with the plane orthogonal to the antenna elevation axis
(El axis).
When the satellite is within the meridian plane of the antenna, then for any direction in the vicinity of the satellite:
the angle Az is approximately equal to the azimuth angle of the considered direction minus 180; and
the angle El is approximately equal to the elevation angle of the considered direction minus the elevation of
the satellite direction.
ETSI
14
Antenna Az axis
Antenna El axis
zA
Antenna
Main beam axis
r
D
El
yA
Az
GSO
xA
Figure 6: Antenna axes and angles AZ and EL of a direction
NOTE:
r
D
The coordinate system used within the present document (see figure 6) may be different from other
antenna coordinate systems. In particular, the present document uses the x-axis as the antenna main beam
axis instead of the z-axis.
In figure 7, the GSO arc and its vicinity are represented as a function of the angles AZ and EL for an earth station at
0/E and 45/N and for different values of the satellite longitude (Lg_S).
50 Phi_El
Lg_S = - 67/E
Lg_S = + 67/E
40
30
20
10
0
-10
-20
Lg_S = 0/E
Lg_S = -30/E
-30
-180 -150 -120 -90 -60 -30
Phi_Az
0
30
60
Figure 7: GSO arc and its vicinity for an earth station at 0/E and 45/N
and pointed towards different satellites at longitude Lg_S
Any direction
r
D from the antenna may also be defined by a couple (, ) of angles, represented in figure 8, where:
the angle is the angle of the projection of the considered direction on the plane orthogonal to the antenna
main beam direction with the antenna azimuth axis (Az-axis); and
the angle is the off-axis angle of the considered direction with the antenna main beam direction.
ETSI
15
r
D
- 3 dB contour
Antenna Az axis
Antenna El axis
r
D
The antenna radiation pattern is usually measured within 2 or more planes containing the main bean axis:
when necessary, e.g. with non symmetrical antennas, within intermediate planes (e.g. for = - 45 and
= +45).
Gain(,
ETSI
16
Plane = constant
Az-axis
= 90
= 180
Figure 10: (, ) domain for the representation of planes within the antenna radiation pattern
For an antenna which always has its azimuth axis parallel to the horizontal plane, the GSO arc and its vicinity may
cover a large range within the off-axis angle domain (, ).
5.3.1
the azimuth-elevation antenna mounts without possibility of alignment of the antenna Az-axis with the GSO
tangent;
the azimuth-elevation antenna mounts with alignment of the antenna Az-axis with the GSO tangent, with two
sub-cases:
the case where the polarizer is not rotating but fixed, the two polarization planes rotate with the antenna
and one of these two planes is aligned with the electric field received from the satellite;
More precisely, what is called "alignment of the antenna Az-axis with the GSO tangent" consists of:
putting into coincidence the plane defined by the antenna main beam axis and the antenna Az-axis with the
plane defined by the antenna main beam axis and the GSO tangent; or
putting orthogonal the El-axis with the GSO tangent as shown in figure 11.
For an observer located behind the antenna and looking at the satellite in the direction of the antenna main beam axis,
the GSO tangent and the antenna Az-axis appear aligned, even though they are not parallel.
ETSI
17
El-axis
Satellite
Vertical
Station
GSO
Main beam axis GSO tangent Az-axis
Earth centre
Figure 11: Alignment of the antenna Az-axis with the GSO tangent
5.3.2
An azimuth-elevation antenna mount without GSO tangent alignment capability consists of two axes:
In the case of an azimuth-elevation antenna mount without GSO tangent alignment, the antenna orientation relative to
the antenna mount elevation axis is constant for any direction of the antenna main beam axis.
Vertical
Antenna
Antenna mount Az-axis
Antenna Az-axis
Antenna mount El-axis
Antenna El-axis
Horizontal plane
ETSI
18
-3 dB contour
GSO
Horizon
Figure 13: GSO arc and -3 dB contour of the antenna main beam
for various satellite positions
Figure 14 represents the GSO arc and its vicinity within the antenna (, ) domain for various ES latitudes and satellite
positions on the GSO arc.
Table 1: Cases represented in figure 14
Case
(1)
(2)
(3)
(4)
(5)
ES latitude
5,000/N
30,000/N
70,000/N
30,000/N
1,000/N
Lg_S0
74,313/E
71,880/E
38,046/E
-71,880/E
0,744/E
Case (5) corresponds to the case of an ES in the vicinity (e.g. at 138 km) of the sub-satellite point on the Earth.
El axis
Phi.sin(Alpha)
180
(1)
150
120
90
60
(4)
(2)
30
(3)
Az axis
0
-30
(5)
-60
-90
-120
-150
Phi.cos(Alpha)
-180
180 150 120 90 60 30 0 -30 -60 -90 -120 -150 -180
Phi = 180
GSO -3
GSO
GSO +3
Phi = 90
Figure 14: GSO arc and its vicinity within the (, ) domain
ETSI
19
For a given range of ES latitudes, a given minimum elevation angle of the pointed satellite, a given minimum elevation
of the satellites to be protected, the envelope of projections or shadows of the GSO arc and its vicinity on the (, )
domain for all the possible positions of the pointed satellite, can be determined. It will be called the (, ) domain of the
shadow of the GSO arc and its vicinity on the antenna radiation pattern. It is represented in figure 15 for:
The part of contour which is approximately a circle of radius equal to 90, corresponds to an ES located clause to the
sub-satellite point on the Earth.
El axis
Phi.sin(Alpha)
180
150
120
90
60
30
Az axis
0
-30
-60
-90
-120
-150
Phi.cos(Alpha)
180 150 120 90
Phi = 90
60
30
-180
-30 -60 -90 -120 -150 -180
Phi = 180
Limit
Figure 15: Limit within the (, ) domain of the shadow of the GSO arc
and its vicinity for latitudes from -74/N to 74/N
ETSI
20
Due to the complexity of the contour, the contour has been computed for three adjacent satellite latitudes (-3, 0 and
+3), and for different cases:
the cases where the ES latitude varies from the minimum latitude to the maximum latitude, the ES antenna is
successively pointed towards the western and eastern satellites at the minimum elevation, and the satellites to
be protected are successively the eastern and western satellites at the minimum elevation;
the cases where the ES latitude is maximum, the ES antenna is successively pointed towards the western and
eastern satellites at the minimum elevation, and the longitude of the satellite to be protected varies from the
eastern to the western satellite longitudes at the minimum elevation. If the absolute value of the ES maximum
latitude is lower than 1 then computations are made with 1 instead of the ES maximum latitude;
the cases where the ES latitude is minimum, the ES antenna is successively pointed towards the western and
eastern satellites at the minimum elevation , and the longitude of the satellite to be protected varies from the
eastern to the western satellite longitudes at the minimum elevation. If the absolute value of the ES minimum
latitude is lower than 1 then computations are made with 1 instead of the ES minimum latitude;
the cases where the ES latitude is minimum, the longitude of the satellite pointed by the ES antenna varies
from the eastern to the western satellite longitudes at the minimum elevation, and the longitude of the satellite
to be protected is successively the eastern to the western satellite longitudes at the minimum elevation. If the
absolute value of the ES minimum latitude is lower than 1 then computations are made with 1 instead of the
ES minimum latitude.
This method of computation the contour has also been used for the other type of antenna mount.
In the following clause it will be shown that for an antenna which has always its azimuth axis aligned with the tangent
to the GSO arc, the GSO arc and its vicinity covers a smaller range within the off-axis angle domain (, ).
For an antenna designed for a limited range of latitudes, the GSO arc and its vicinity covers a smaller range within the
off-axis angle domain (, ), as shown in figure 16 for:
ETSI
21
El axis
Phi.sin(Alpha)
180
150
120
90
60
30
Az axis
0
-30
-60
-90
-120
-150
Phi.cos(Alpha)
180 150 120 90
60
Phi = 90
30
-180
-30 -60 -90 -120 -150 -180
Phi = 180
Limit
Figure 16: Limit within the (, ) domain of the projection of the GSO arc
and its vicinity for latitudes from 35/N to 65/N
With an alignment error or offset of the antenna Az-axis the contour is rotated as shown in figure 17 for:
ETSI
22
El axis
Phi.sin(Alpha)
180
150
120
90
60
30
Az axis
0
-30
-60
-90
-120
-150
Phi.cos(Alpha)
180 150 120 90
Phi = 90
60
30
-180
-30 -60 -90 -120 -150 -180
Phi = 180
Limit
Figure 17: Limit within the (, ) domain of the shadow of the GSO arc
and its vicinity for latitudes from -74/N to 74/N and with an alignment offset of +5
ETSI
23
El axis
Phi.sin(Alpha)
180
150
120
90
60
30
Az axis
0
-30
-60
-90
-120
-150
Phi.cos(Alpha)
180 150 120 90
60
30
-180
-30 -60 -90 -120 -150 -180
Phi = 90
Phi = 180
Limit
Figure 18: Limit within the (, ) domain of the shadow of the GSO arc
and its vicinity for latitudes from 35/N to 65/N and with an alignment error of 5
It is obvious that a permanent offset i of the Az-axis results in a rotation of i the contour. This is verified in figures 17
and 18.
For antennas which could be used up-side down, the contour has to be computed for offset i = 0 and for i = 180.
It will be demonstrated that:
For a antenna with an azimuth-elevation mount without GSO tangent alignment, designed for a maximum
ElS ,max and for a maximum vertical axis offset max then the maximum value imax of the
uuuur
additional offset i of the antenna azimuth axis u Az , S , due to misalignment, is given by the following
elevation
equations:
for
for
0 ElS ,max
max
imax
sin
max
= ArcSin
cos El
S ,max
imax =
ETSI
rad
(4a)
(4b)
24
This value imax is indirectly a function of the ES latitude and has to be added, for one extreme case, and subtracted,
for the other extreme case, to the permanent offset i for the computation of the GSO shadow on the antenna radiation
pattern, for each ES latitude.
5.3.3
5.3.3.1
General
An azimuth-elevation antenna mount with GSO tangent alignment capability consists of three axes:
the antenna mount "attitude" axis which is parallel to the antenna main beam axis.
In the case of an azimuth-elevation antenna mount with GSO tangent alignment capability, the antenna orientation
relative to the antenna mount elevation axis is adjustable for any direction of the antenna main beam axis.
Vertical
Antenna
Antenna mount Az-axis
Antenna Az-axis
Antenna main beam axis
Antenna mount
attitude axis
Antenna El-axis
Horizontal plane
ETSI
25
-3 dB contour
GSO
Horizon
Figure 20: GSO arc and -3 dB contour of the antenna main beam
for various satellite positions
5.3.3.2
Ideal case
Figure 21 represents the GSO arc and its vicinity within the antenna (, ) domain for various ES latitudes and satellite
positions on the GSO arc.
Table 2: Cases represented in figure 21
Case
(1)
(2)
(3)
(4)
(5)
ES latitude
5,000/N
30,000/N
70,000/N
30,000/N
1,000/N
Lg_S0
74,313/E
71,880/E
38,046/E
-71,880/E
0,744/E
Case (5) corresponds to the case of an ES in the vicinity (e.g. at 138 km) of the sub-satellite point on the Earth.
ETSI
26
El axis
Phi.sin(Alpha)
180
150
120
90
60
30
(5)
Az axis
0
-30
(3)
(1) -60
-90
(4)
(2)
-120
-150
Phi.cos(Alpha)
180 150 120 90 60 30
GSO -3
GSO
-180
-30 -60 -90 -120 -150 -180
GSO +3
Phi = 90
Phi = 180
Figure 21: GSO arc and its vicinity within the (, ) domain
The (, ) domain of the shadow of the GSO arc and its vicinity on the antenna radiation pattern is represented in figure
22 for:
ETSI
27
El axis
Phi.sin(Alpha)
180
150
120
90
60
30
Az axis
0
-30
-60
-90
-120
-150
Phi.cos(Alpha)
180 150 120 90
60
Phi = 90
30
-180
-30 -60 -90 -120 -150 -180
Phi = 180
Limit
Figure 22: Limit within the (, ) domain of the shadow of the GSO arc
and its vicinity for latitudes from -74/N to 74/N
The above contour has been computed for 3 different latitudes of the adjacent satellite: -3, 0 and +3, using the
method described for the Az-El antenna mount without GSO alignment.
With an alignment error or offset of the antenna Az-axis the contour is rotated as shown in figure 23 for:
ETSI
28
El axis
Phi.sin(Alpha)
180
150
120
90
60
30
Az axis
0
-30
-60
-90
-120
-150
Phi.cos(Alpha)
180 150 120 90
Phi = 90
60
30
-180
-30 -60 -90 -120 -150 -180
Phi = 180
Limit
Figure 23: Limit within the (, ) domain of the shadow of the GSO arc and its vicinity
for latitudes from -74/N to 74/N and with an alignment error of 5
It is obvious that a permanent offset i of the Az-axis result in a rotation of i the contour. This is verified in figure 23.
For antennas which could be used up-side down, the contour has to be computed for offset i = 0 and for i = 180.
It will be demonstrated that:
For a antenna with an azimuth-elevation mount with GSO tangent alignment the value of the additional offset
uuuur
u Az , S is always equal to zero:
i = 0
what ever are the values of the elevation and of the vertical axis offset.
5.3.3.3
In that case the polarizer is not rotating but fixed, the two polarization planes rotate with the antenna and one of these
two planes is aligned with the electric field received from the satellite.
ETSI
29
In order to estimate the (, ) domain of the shadow of the GSO arc and its vicinity on the antenna radiation pattern the
uur
uuur
E0 and the associated magnetic field H 0 in the direction of the
uuur
centre Sc of the antenna beam coverage so that the direction of the received electric field Er , n and the associated
uuuur
uur
magnetic field H r , n at station Sn may be computed. The electric field E0 may have a tilt angle (i_E0) with the pole
direction.
Er,n
Sn
E0
iE0
S
Hr,n
Sc
un
u0
H0
a tilt angle (i_E0) with the North pole direction of the electric field at the satellite of 0;
with alignment on the received H field or the E field but with an additional rotation of 90.
ETSI
30
El axis
Phi.sin(Alpha)
180
150
120
90
60
30
Az axis
0
-30
-60
-90
-120
-150
Phi.cos(Alpha)
180 150 120 90
60
Phi = 90
30
-180
-30 -60 -90 -120 -150 -180
Phi = 180
Limit
Figure 25: Limit within the (, ) domain of the shadow of the GSO arc
and its vicinity for latitudes from -74/N to 74/N and Lg_c = 5, Lt_c = 50, i_E0 = 0
With an alignment error or offset of the antenna Az-axis the contour is rotated as shown in figure 26 for:
a tilt angle (i_E0) with the North pole direction of the electric field at the satellite of 0;
with alignment on the received H field or the E field but with an additional rotation of 90.
ETSI
31
El axis
Phi.sin(Alpha)
180
150
120
90
60
30
Az axis
0
-30
-60
-90
-120
-150
Phi.cos(Alpha)
180 150 120 90
Phi = 90
60
30
-180
-30 -60 -90 -120 -150 -180
Phi = 180
Limit
Figure 26: Limit within the (, ) domain of the shadow of the GSO arc and its vicinity
for latitudes from -74/N to 74/N, Lg_c = 5, Lt_c = 50, i_E0 = 0 and with an alignment error of 5
It is obvious that a permanent offset i of the Az-axis result in a rotation of i the contour. This is verified in figure 27.
For antennas which could be used up-side down, the contour has to be computed for offset i = 0 and for i = 180.
With a tilt angle of the electric field radiated by the satellite equal to 22, as for Telecom 2 satellites in Ku band, the
contour is no more ideal as shown in figure 27 for:
a tilt angle (i_E0) with the North pole direction of the electric field at the satellite of 22;
with alignment on the received H field or the E field but with an additional rotation of 90.
ETSI
32
El axis
Phi.sin(Alpha)
180
150
120
90
60
30
Az axis
0
-30
-60
-90
-120
-150
Phi.cos(Alpha)
180 150 120 90
Phi = 90
60
30
-180
-30 -60 -90 -120 -150 -180
Phi = 180
Limit
Figure 27: Limit within the (, ) domain of the shadow of the GSO arc and its vicinity
for latitudes from -74/N to 74/N, Lg_c = 5, Lt_c = 50, i_E0 = 22 and with no alignment error
When the centre of the satellite beam coverage is not at the sub-satellite point on the Earth, as in the above example,
this implies that the coverage area is limited to a portion of the visible part of the Earth from the satellite, and
consequently that the range of operational latitudes of the ES is also limited to a smaller range than the range from
-74/N to 74/N, in the above example.
When the range of operational latitudes of such antenna is limited to the range from 30/N to 74/N, with a tilt angle of
the electric field radiated by the satellite equal to 22, as for Telecom 2 satellites in Ku band, the contour is still close to
the ideal contour but it is rotated as shown in figure 28 for:
a tilt angle (i_E0) with the North pole direction of the electric field at the satellite of 22;
with alignment on the received H field or the E field but with an additional rotation of 90.
ETSI
33
El axis
Phi.sin(Alpha)
180
150
120
90
60
30
Az axis
0
-30
-60
-90
-120
-150
Phi.cos(Alpha)
180 150 120 90
60
Phi = 90
30
-180
-30 -60 -90 -120 -150 -180
Phi = 180
Limit
Figure 28: Limit within the (, ) domain of the shadow of the GSO arc and its vicinity
for latitudes from 30/N to 74/N, Lg_c = 5, Lt_c = 50, i_E0 = 22 and with no alignment error
Theses performances would be quite ideal if the antenna mount is fitted with a means of putting an offset equal to the
electric field tilt angle as shown in figure 29 for:
a tilt angle (i_E0) with the North pole direction of the electric field at the satellite of 22;
with alignment on the received H field or the E field but with an additional rotation of 90.
ETSI
34
El axis
Phi.sin(Alpha)
180
150
120
90
60
30
Az axis
0
-30
-60
-90
-120
-150
Phi.cos(Alpha)
180 150 120 90
60
30
Phi = 90
-180
-30 -60 -90 -120 -150 -180
Phi = 180
Limit
Figure 29: Limit within the (, ) domain of the shadow of the GSO arc and its vicinity
for latitudes from 30/N to 74/N, Lg_c = 5, Lt_c = 50, i_E0 = 22 and with an alignment offset of -22
The tilt angle (i_E0) with the North Pole direction of the electric field at the satellite depends of the satellite and of the
considered coverage and transmit frequency band. It is equal to 22 for Telecom 2 satellites. It seems that for some
satellite operators the common values of the tilt angles is 0, 3 or 7,5, but it is not a general rule.
Presently, the values of the tilt angles seem to be not available in the satellite documentation published on the Web.
Consequently the design of antenna using this technique of alignment with the GSO tangent is unsuitable for any
satellite but could be suitable for a specific satellite or a series of satellites with the same value of the tilt angle,
provided that the user is informed of that limitation, e.g. within the user documentation.
The value of the offset
uuuur
u Az , S is the sum of:
the offset i_E0, if applied, for compensation of the tilt angle i_E0 of the electric field radiated by the satellite;
the error
the error PS due to a difference of orientation of the electric field radiated in the direction of the ES with the
electric field radiated in the direction of the centre of coverage;
the error PSn due to a difference of orientation of the polarization plane of the receive antenna in the satellite
direction but within the tracking or pointing contour of the antenna main beam with the polarization plane in
the direction of the antenna main beam axis;
iE 0
i
i
ETSI
35
iP alignment
the error ionosphere + rain equal to the rotation angle of the received electric field through the ionosphere and
through the atmosphere mainly when it is raining at the time of the alignment of the antenna polarization plan
with the received electric field.
The error
iionosphere + rain is important in C-band and not negligible in Ku band during rainy conditions. For this reason:
the initial alignment of the polarization plane of antennas receiving in Ku band with the GSO tangent should
be performed during clear sky conditions;
the alignment of the polarization plane of antennas receiving in Ku band with the GSO tangent should not be
performed during rainy sky conditions, consequently the automatic and permanent alignment systems are
unsuitable for these antennas;
the alignment of the polarization plane of antennas receiving in C band with the GSO tangent is unsuitable for
antennas receiving in C band.
For the use of such antennas, investigations have to be performed on the range of values of the above listed errors and
on their effects on the contour.
5.3.4
An equatorial antenna mount normally consists of one axis but is in fact in three axes:
the antenna mount pole axis which is parallel to the Earth pole axis;
The antenna mount azimuth axis and elevation axis are used to give the correct orientation to the antenna mount pole
axis. Once done, the antenna only rotates around the antenna mount pole axis.
Antenna El-axis
Antenna
Antenna Az-axis
Vertical
90 - Lt_n
ETSI
36
Figure 31 represents the GSO arc and its vicinity within the antenna (, ) domain for various ES latitudes and satellite
positions on the GSO arc.
Table 3: Cases represented in figure 31
Case
(1)
(2)
(3)
(4)
(5)
ES latitude
5,000/N
30,000/N
70,000/N
30,000/N
1,000/N
Lg_S0
74,313/E
71,880/E
38,046/E
-71,880/E
0,744/E
Case (5) corresponds to the case of an ES in the vicinity (e.g. at 138 km) of the sub-satellite point on the Earth.
El axis
Phi.sin(Alpha)
180
150
120
90
60
30
(5)
Az axis
0
-30
(3)
(1)
-60
-90
(4)
(2)
-120
-150
Phi.cos(Alpha)
180 150 120 90
GSO -3
60
GSO
30
-180
-30 -60 -90 -120 -150 -180
GSO +3
Phi = 90
Phi = 180
Figure 31: GSO arc and its vicinity within the (, ) domain
The (, ) domain of the shadow of the GSO arc and its vicinity on the antenna radiation pattern is represented in figure
32 for:
ETSI
37
El axis
Phi.sin(Alpha)
180
150
120
90
60
30
Az axis
0
-30
-60
-90
-120
-150
Phi.cos(Alpha)
180 150 120 90
60
Phi = 90
30
-180
-30 -60 -90 -120 -150 -180
Phi = 180
Limit
Figure 32: Limit within the (, ) domain of the shadow of the GSO arc
and its vicinity for latitudes from -74/N to 74/N
The above limit has been computed for 3 different latitudes of the adjacent satellite: -3, 0 and +3.
The above contour has been computed for 3 different latitudes of the adjacent satellite: -3, 0 and +3, using the
method described for the Az-El antenna mount without GSO alignment.
With an alignment error or offset of the antenna Az-axis the contour is rotated as shown in figure 33 for:
ETSI
38
El axis
Phi.sin(Alpha)
180
150
120
90
60
30
Az axis
0
-30
-60
-90
-120
-150
Phi.cos(Alpha)
180 150 120 90
60
Phi = 90
30
-180
-30 -60 -90 -120 -150 -180
Phi = 180
Limit
Figure 33: Limit within the (, ) domain of the shadow of the GSO arc
and its vicinity for latitudes from -74/N to 74/N and with an alignment error of 5
It is obvious that a permanent offset i of the Az-axis result in a rotation of i the contour. This is verified in figure 33.
For antennas which could be used up-side down, the contour has to be computed for offset i = 0 and for i = 180.
It will be demonstrated that:
i of the antenna
uuuur
azimuth axis u Az , S due to an error ElN , n on the elevation and to an error Az N , n on the azimuth of the
uur
estimated direction N of the North pole in a station Sn at latitude Ltn is given by the following relationship:
For a antenna with an equatorial mount the maximum value i of the inclination error
El N ,n
Az N ,n
i
sin = sin
+ sin
.cos ( Ltn ) .cos ( Ltn + ElN ,n )
2
2
2
2
(5)
When the latitude of the station is known with an accuracy highly better than i , e.g. with a GPS, then the
following relationship applies:
Az N ,n
i
sin = sin
2
2
ETSI
.cos ( Ltn )
(6)
39
NOTE 1: A North-South error of 1 km on the location of the earth station corresponds to an error of 0,009
(= 360 x 1 km / 40 000 km) on the latitude of the earth station. This error is considered negligible for the
antenna axis alignment. A GPS gives a better accuracy.
For ESs designed to operate at any latitude, with the coordinates provided by a GPS, then the following
relationship applies:
2
El N , n
Az N ,n
i
sin = sin
+ sin
2
2
2
2
(7)
uur
an error
on the azimuth of the estimated direction N of the North pole in the station of 4;
uur
ElN ,n
on the elevation of the estimated direction N of the North pole in the station of 3.
an error
Az N , n
NOTE 2: These values correspond to a global error angle between the North pole direction and its estimation of 5
42 + 32 = 5 .
ETSI
40
El axis
Phi.sin(Alpha)
180
150
120
90
60
30
Az axis
0
-30
-60
-90
-120
-150
Phi.cos(Alpha)
180 150 120 90
60
30
Phi = 90
-180
-30 -60 -90 -120 -150 -180
Phi = 180
Limit
Figure 34: Limit within the (, ) domain of the shadow of the GSO arc
and its vicinity for latitudes from -74/N to 74/N and with a pole axis alignment error of 5
5.4
The requirement for the protection of the other satellites of the GSO applies to adjacent satellites the longitudes of
which are greater or equal to a minimum longitude offset (dLg_S_min).
To a minimum longitude offset (dLg_S_min) corresponds a minimum off-axis angle. The value of this minimum angle
depends on the latitude of the ES and on the relative position of the pointed satellite.
In figure 35 the minimum off-axis angles are marked with red squares. Figure 35 corresponds to the case of alignment
on the received electrical field:
a tilt angle (i_E0) with the North pole direction of the electric field at the satellite of 22;
ETSI
41
with alignment on the received H field or the E field but with an additional rotation of 90;
A marker, represented by a dotted line, is used to determine the minimum size of the minimum off-axis angle. It is
made of a straight line (Alpha = constant) a circle (Phi = constant) and a square with a side length equal to 2 Phi and
an inclination equal to Alpha.
El axis
Phi.sin(Alpha)
5
4
3
2
1
Az axis
0
-1
-2
-3
-4
Phi.cos(Alpha)
-5
5
4
GSO -3
2
GSO
-1
GSO +3
-2
-3
Marker
-4
-5
dLg_S_min
Figure 35: Minimum off-axis angle within the (, ) domain of the shadow of the GSO arc
and its vicinity for latitudes from -74/N to 74/N, Lg_c = 5, Lt_c = 50, i_E0 = 22,
with alignment error of 1 and dLg_S_min = 3
The minimum off-axis angles corresponding to the minimum longitude offset (dLg_S_min) have been computed for
three adjacent satellite latitudes (-3, 0 and +3), and for following cases:
the cases where the ES latitude varies from the minimum latitude to the maximum latitude, the ES antenna is
pointed towards the satellite at the ES latitude, and the satellites to be protected are successively the East and
West satellites at the minimum longitude offset (dLg_S_min);
the cases where the ES latitude varies from the minimum latitude to the maximum latitude, the ES antenna is
successively pointed towards the West and East satellites at the minimum elevation, and the satellites to be
protected are successively the East and West satellites at the minimum longitude offset (dLg_S_min).
The smallest values of the minimum off-axis angles are obtained for the lowest elevation angles.
ETSI
42
Mathematical analysis
6.1
Geographical coordinates
Z North pole
Nn
Vn
En
Sn
R
dn
Ltn
Y
O
a
Lgn
LgS
NS
S
ES
GSO
Let:
O:
R:
uuur
OZ :
uuur
OX :
uuur
OY :
uur
N:
uuur
uuur
OX and OZ axis towards the East;
Then:
X = 0
uur
N = Y = 0
Z = 1
ETSI
(8)
43
6.2
Let:
Sn :
Lgn:
Ltn:
uur
Vn :
uur
Nn :
uur
En :
Sn ;
Sn ;
Sn .
Z = R.sin ( Ltn )
uur uur
S n .N n = 0
6.3
(9)
Z = sin ( Ltn )
(10)
Z = cos ( Ltn )
(11)
X = sin ( Lg n )
uur
En = Y = cos ( Lg n )
Z = 0
(12)
uur uur
Sn .En = 0
Let:
S:
the nominal GSO radius = 42 164 km, and also radius the sphere of the GSO vicinity;
LgS:
ETSI
(13)
44
LtS:
uuur
NS :
uur
ES :
Then:
X = .cos ( Lt S ) .cos ( Lg S )
ur
S = Y = .cos ( LtS ) .sin ( Lg S )
Z = .sin ( Lt S )
(14)
Z = cos ( LtS )
(15)
X = sin ( Lg S )
uur
ES = Y = cos ( Lg S )
Z = 0
(16)
ur uuur
S .N S = 0
6.4
ur uur
S .E S = 0
Local coordinates
GSO
S
Zenith
Vn
z
North
ElS
Sn
Azn
South
x
y
En
ETSI
(17)
45
Let:
Sn :
uur
Ox :
NOTE:
Sn ;
The GSO arc is mainly southwards for a station on the north hemisphere but it is northwards for a station
on the south hemisphere.
uur
Oy :
uur
Oz :
AzD:
ElD:
uur
Vn :
uur
Nn :
uur
En :
M:
Sn ;
Sn ;
ur
ur
Sn ;
Sn ;
Sn ;
( xM , yM , zM ) ;
dM
Sn to M .
Then:
x = 0
uur
Vn = y = 0
z = 1
x = 1
uur
Nn = y = 0
z = 0
x = 0
uur
En = y = 1
z = 0
uuuuur
dM = Sn M
zM = d M .sin ( ElM )
uuuuur uur
uur uur uur uur
uur uur
xM = Sn M .N n = M .N n S n .N n
= M .N n
uuuuur
uuuuur uur
uur uur uur uur
uur uur
= M .En
Sn M = yM = Sn M .En = M .En Sn .En
uuuuur uur
uur uur uur uur
uur uur
=
=
=
z
S
M
V
M
V
S
V
M
.
.
.
.Vn R
n
n
n
n n
M
(18)
(19)
ETSI
(20)
(21)
46
XM =
+ z .cos ( Lt ) .cos ( Lg ) R.cos ( Lt ) .cos ( Lg )
n
n
n
n
M
uuuuur
+ xM .sin ( Ltn ) .sin ( Lg n ) + yM .cos ( Lg n )
Sn M = YM =
(22)
6.5
Let:
S:
the nominal GSO radius = 42 164 km, and also radius the sphere of the GSO vicinity;
AzS:
ElS:
dn:
n :
the angle at the Earth centre between the direction of the satellite S and the direction of the station
uuur
NS :
uur
ES :
Sn to the satellite S;
Sn ;
the direction of the North at the satellite S position. This direction is different of the North Pole direction
when the latitude of the satellite is not equal to 0;
the direction of tangent to the GSO towards the East at the satellite S position.
Then:
ur uur
ur uur
S .Sn
S .Sn
cos ( n ) = ur uur =
= cos ( LtS ) .cos ( Ltn ) .cos ( Lg S Lg n ) + sin ( LtS ) .sin ( Ltn )
.R
S . Sn
uuur
uuur uuur
ur ur uur uur
ur uur
d n = Sn S = Sn S .Sn S = S .S + Sn .Sn 2.S .Sn = 2 + R 2 2. .R.cos ( n )
ur uur
xS = S . N n
uuur
ur uur
Sn S = yS = + S .En
ur uur
z
=
+
S .Vn R
S
ETSI
(23)
(24)
(25)
47
(26)
z S = d n .sin ( ElS )
(27)
6.6
Let:
an :
the aspect angle from the satellite S between the direction of the Earth centre O and the direction of the station
Sn .
Vn
Sn
dn
Eln
R
n
an
Sn )
sin + Eln
cos ( Eln ) sin ( n ) sin ( an )
2
= sin ( n ) = sin ( an )
=
=
d
R
dn
R
n
or:
rr
S .Sn
= cos ( Lt S ) .cos ( Ltn ) .cos ( Lg S Lg n ) + sin ( Lt S ) .sin ( Ltn )
cos ( n ) =
.R
d n = 2 + R 2 2. .R.cos ( n )
(28)
(29)
(30)
uuur r
S n S .Vn
sin ( Eln ) = uuur =
Sn S
.cos ( n ) R
2 + R 2 2. .R.cos ( n )
uuur r
cos ( Lt ) .sin ( Lt )
S n S .N n
xS
n
S
ETSI
(31)
(32)
48
uuur r
Sn S .En yS .cos ( Lt S ) .sin ( Lg S Lg n )
cos ( Eln ) .sin ( Azn ) = uuur =
=
dn
Sn S
2 + R 2 2. .R.cos ( )
(33)
y
x
Azn = ArcTan2 S , S = ArcTan2 ( yS , xS )
dn dn
(34)
with:
a > 0 and
for
x [ , + [
S
n
(35)
(36)
The satellite longitude LgS corresponding to a given elevation Eln is a solution of the following equations:
.cos ( n ) R
sin ( Eln ) =
2 + R 2 2. .R.cos ( n )
(37)
or:
The discriminant
Two values of
(38)
(39)
R
R
2
2
cos ( n ) = .cos ( Eln ) sin ( Eln ) . 1 .cos ( Eln )
(40)
cos ( n ) corresponds to an earth station visible from the satellite, the other value to an earth
ETSI
49
Eln
Sn'
Sn
dn
Eln
n'
R.Cos(n) R.Cos(n')
Sn )
Then:
2
cos ( Lg S Lg n ) =
cos ( Lt S ) .cos ( Ltn )
(41)
The maximum satellite latitude Ltn, max corresponding to a given elevation Eln is solution of the following equations:
2
R
R
2
cos ( n ) = .cos ( Eln ) + sin ( Eln ) . 1 .cos ( Eln ) 2
cos ( Lg S Lg n ) =
cos ( Lt S ) .cos ( Ltn ,max )
Lg = Lg
n
S
(42)
or:
2
R
R
2
2
cos ( LtS Ltn ,max ) = .cos ( Eln ) + sin ( Eln ) . 1 .cos ( Eln )
6.7
z
i
LS,n
xa
North
TS,n
uAz,S u
El,S
uAz,S
Sn
uEl,S
ya En
y
uR,S Za Azn
Eln
ETSI
uR,S
(43)
50
Let:
Sn :
uur
Vn :
S:
the satellite;
uuuur
uR,S :
the antenna main beam axis, or radial axis towards the satellite;
uuuur
u Az , S :
uuuur
uEl , S :
uuur
LS ,n :
uuur
TS ,n :
Sn ;
uuur
uur
Sn : orthogonal to Sn S and Vn ;
uuur
uuur
Sn containing S, orthogonal to Sn S and to LS ,n ,
(x, y, z)
uuur
LS ,n ;
uuuur
u Az , S and the satellite left direction
uur
M:
(x
a,M
, ya , M , z a , M ) .
Then:
x = sin ( Az S )
= y = cos ( AzS )
z = 0
z = + cos ( ElS )
ETSI
(44)
(45)
(46)
51
Z
Sn
LS,n
Earth
uuur
LS ,n for a station Sn,
z = sin ( ElM )
xa , M
za , M
uuuuur uuuur
uuuuur uuuur
uuuuur uuuur
= S n M .u R , S = cos ( ElS ) .cos ( ElM ) .cos ( AzS Az M ) + sin ( ElS ) .sin ( ElM )
ETSI
(49)
(50)
(51)
(52)
52
6.8
one is used to describe the North-South and East-West variations (El and Az) from the main beam axis as it
could be seen by an observer at the antenna location;
the other describe the antenna radiation patterns, with the angle of the plan containing the main beam axis
and the direction to the considered point M and the off-axis angle of the direction of M from the main beam
axis.
Main beam axis
Antenna El axis
za
ya
El
Az
Sn
xa
Antenna Az axis
uuuuur
Sn M
Az
El
Sn
ya
xa
Antenna Az axis
Antenna El axis
ETSI
uuuuur
Sn M
53
Let:
Sn :
M:
M:
M:
El:
Az:
the angle of the projection of the direction of M on the plane define by the antenna main beam axis and
the antenna azimuth axis (Az-axis) with the antenna main beam axis.
M with the plane defined by the antenna main beam axis and the antenna
Then:
xa = cos ( El ) .sin ( Az )
uuuuur
Sn M = ya = sin ( El )
za = cos ( El ) .cos ( Az )
(53)
xa = sin ( M ) .cos ( M )
uuuuur
Sn M = ya = sin ( M ) .sin ( M )
za = cos ( M )
(54)
El = ArcSin ( ya )
(55)
Az = ArcTan2 ( xa , za )
(56)
(57)
and:
ya
xa
,
= ArcTan 2
sin ( M ) sin ( M )
(58)
0 sin ( Az ) 1
(59)
(60)
0 M 180
ETSI
54
6.9
GSO
N
uAz,S
TS,n
LS,n
uEl,S
ES
uR,S
i
Vn z
xa
ya En
y
Nn
Za
Sn
Earth
Z North pole
Nn
Vn
En
Sn
O
TS,n
N NS
ES
S
LS,n
GSO
Sn :
uur
Vn :
uur
Nn :
uur
En :
S:
the satellite;
uuur
NS :
Sn ;
Sn ;
Sn ;
ETSI
uuur
OS ;
55
uur
ES :
the direction of tangent to the GSO towards the East at the satellite S position, orthogonal to
uuuur
uR,S :
the antenna main beam axis, or radial axis towards the satellite;
uuuur
u Az , S :
uuuur
uEl , S :
uuur
LS ,n :
uuur
TS ,n :
uuur
NS ;
uuur
OS and
uuur
uur
Sn , orthogonal to Sn S and Vn ;
uuur
uuur
Sn containing S, orthogonal to Sn S and to LS ,n ,
iAz:
uuur
LS ,n of the satellite for station #n;
uuuur
u Az , S and the left hand side direction
uuuur
uuur
uuuur
uuur
u Az , S and LS ,n or between the uEl , S and TS ,n with the antenna
mount;
(x, y, z)
uuuur
uEl , S
uur uuur
E Sn S
uurS uuur
ES Sn S
(61)
uuuur uuur
iS = angle uEl , S , TS ,n
The values of
(62)
x = 0
uur
Vn = y = 0
z = 1
uur uuur
uuur V S S
n
LS , n = uurn uuur
Vn Sn S
ETSI
(63)
(64)
(65)
56
uuur
uuur S S uuur
n
LS , n
TS , n = uuur
Sn S
(66)
TS,n
uAz,S
(68)
(69)
uEl,S
iAz
iAz
LS,n
uuuur uuur
cos ( iAz ) = uEl , S .TS , n
uuuur uuur
(67)
uuuur
uuur
uuur
u El , S on LS ,n and TS ,n
(70)
The antenna azimuth axis (Az-axis) is aligned with the tangent to the GSO arc at the satellite S position when:
i = iAz .
6.10
Let:
S:
the satellite;
Sc :
Sn :
uur
Vn :
Sn ;
uur
N:
uur
un :
uur
uc :
ETSI
57
uuur
uur
Sn , orthogonal to Sn S and Vn ;
uuur
LS ,n :
uuuur
ES , c :
uur
E0 :
uuur
H0 :
Z0 :
iE0 :
the tilt angle of radiated electric field at the satellite relative to the North pole direction
uuur
Er ,n :
uuuur
H r ,n :
i:
iE:
uuur
uur
SSc and N ;
0
= 120. = 376, 6 ;
0
uuur
LS ,n of the satellite for station #n;
uur
N;
uuuur
u Az , S and the left hand side direction
uuur
uuuur
uuur
Er ,n or magnetic field H r ,n and LS ,n .
Then:
uur
un
uuur
SSn
uuur
SSn
(71)
uur
uc
uuur
SSc
uuur
SSc
(72)
uuur uur
uuur SS V
LS ,n = uuurn uurn
SSn Vn
(73)
uuur uur
uuuur SS N
ES ,c = uuurc uur
SSc N
(74)
uur
uur
uuuur
E0 = cos iE0 .N +sin iE0 .ES ,c
(75)
(76)
( )
uur
uuur un
Er ,n = uur
un
( )
uur uur
uuur
uur
H u )
( uuEr uuur ) + Z .( uuu
r uur
( E u ) + Z .( H u )
ETSI
(77)
(78)
58
uuur uuuur uuur uuur
cos
i
+
E 2 = LS ,n .u Az , S = LS ,n .Er , n = sin ( iE )
uuuur uuur
u Az , S = Er ,n
uuuur
uuuur
=
u
H r ,n
El , S
(79)
uuuur uuuur
uuur uuuur uuur uuuur
u Az , S = H r , n
cos ( iE ) = LS ,n .u Az , S = LS ,n .H r ,n
uuur uuuur uuur uuuur
uuuur uuur
sin ( iE ) = TS ,n .u Az , S = TS ,n .H r ,n
uEl , S = Er ,n
(80)
(81)
The antenna azimuth axis (Az-axis) is aligned with the received electric field
satellite S when:
6.11
uuur
uuuur
Er ,n or magnetic field H r ,n from
i = iE .
Vn
Vn
Sn
Sn
TS,n
O
S
uEl,S
uAz,S
LS,n
GSO
GSO
Figure 46: Antenna Cartesian coordinate systems relative to the local vertical direction
and relative to the Pole axis
Let:
Sn :
uur
Vn :
S:
the satellite;
uuuur
u Az , S :
uuuur
uEl , S :
uur
N:
uuur
NS :
Sn ;
ETSI
uuur
OS ;
59
uur
ES :
the direction of tangent to the GSO towards the East at the satellite S position, orthogonal to
uuur
LS ,n :
uuur
TS ,n :
uuur
NS ;
uuur
OS and
uuur
uur
Sn : orthogonal to Sn S and Vn ;
uuur
uuur
Sn containing S, orthogonal to Sn S and to LS ,n ,
iEq:
uuur
LS ,n of the satellite for station #n;
uuuur
u Az , S and the left hand side direction
uuuur
uuur
u Az , S and LS ,n with the antenna mount.
Then:
uuuur
u Az , S
uur uuur
N Sn S
uur uuur
N Sn S
(82)
uuur uuuur
uuuur S n S u Az , S
u El , S =
uuur
Sn S
uuuur uuur
iEq = angle u Az , S , LS ,n
The values of
(83)
(84)
x = 0
uur
Vn = y = 0
z = 1
uur uuur
uuur V S S
n
LS , n = uurn uuur
Vn Sn S
(85)
(86)
(87)
uuur
uuur S S uuur
n
LS , n
TS , n = uuur
Sn S
(88)
x = cos ( Ltn )
uur
N = y = 0
z = + sin Lt
( n)
(89)
ETSI
60
uuuur
u Az , S
uur uuur
N Sn S
uur uuur
N Sn S
(90)
uuuur uuur
cos ( iEq ) = u Az , S .LS ,n
(91)
When the equatorial antenna mount is correctly installed, the antenna azimuth axis (Az-axis) inclination is:
i = iEq .
7.1
7.1.1
General
Let:
Sn :
uur
Vn :
uur
Vn :
S:
the satellite;
uuur
LS ,n :
uuur
LS ,n :
the estimated left hand side direction at the satellite for station
Sn ;
Sn ;
uuur
uur
Sn , orthogonal to Sn S and Vn ;
uuur
uur
Sn , orthogonal to Sn S and Vn ;
uur
N:
uur
N :
uuuur
u Az , S :
uuuur
u Az , S :
uuur
TS ,n :
the direction towards the antenna top: within the vertical plane
uuur
TS ,n :
Sn ;
uuur
orthogonal to S n S ;
the direction towards the antenna top: within the vertical plane
uuur
orthogonal to S n S ;
ETSI
uur
N of the North is used;
uur
N of the North is used;
uur uuur
(V , S S ) in S
n
containing S, and
uur uuur
Vn , S n S in Sn containing S, and
61
i:
(i+i):
uuuur
u Az , S and the left hand side direction
uuur
uur
LS ,n of the satellite for station #n when the correct direction N of the North is used;
uuuur
u Az , S and the left hand side direction
uur
uuur
LS ,n of the satellite for station #n when the estimated direction N of the North is used.
Then:
uur uuur
uuur V S S
n
LS , n = uurn uuur
Vn Sn S
(92)
uur
uuur V uuur
Sn S
LS , n = uurn uuur
Vn S n S
(93)
uuur
uuur S S uuur
n
LS , n
TS , n = uuur
Sn S
(94)
uuur uuur
Sn S
uuur LS , n
Sn S
uuuur
uuur
uuur
u Az , S = cos ( i ) .LS ,n + sin ( i ) .TS ,n
(96)
uuur
uuur
uuuur
u Az , S = cos ( i ) .LS ,n + sin ( i ) .TS ,n
(97)
uuuur
uuur
uuur
u Az , S = cos ( i + i ) .LS ,n + sin ( i + i ) .TS , n
(98)
uuuur uuuur
u Az , S .u Az , S = cos ( i )
(99)
uuur
TS , n =
uuur
uuuur uuuur
uuur uuur
Sn S
u Az , S u Az , S = sin ( i ) .TS ,n LS ,n = sin ( i ) . uuur
Sn S
uuur
uuuur uuuur S S
n
sin ( i ) = u Az , S u Az , S . uuur
Sn S
7.1.2
(95)
(100)
(101)
uuuur uuur
u Az , S = LS ,n
(102)
uuuur uuur
u Az , S = LS ,n
(103)
ETSI
62
uuuur
uuur
uuur
u Az , S = cos ( i ) .LS ,n + sin ( i ) .TS , n
uur uuur
Vn Sn S
uur uuur
V S S
uur
uur uuur uuur
a + V uuur
S
S
V
.Sn S
n
n
n Sn S
uur uuur
uur uuur
uur uuur uuur
a = +Vn . Sn S Vn S n S Sn S
uu
r
uuur 2
uur uuur
a = + Sn S .Vn . Vn Sn S
((
) ((
( ((
)
(((
(
))
))
a = +
a = +
a = +
uuur
uuur
Sn S
uuuur uuuur S S
n
sin ( i ) = u Az , S u Az , S . uuur
= uur uuur
Sn S
Vn S n S
(104)
uur uuur
Vn Sn S uuur
uur uuur .Sn S
Vn Sn S
(
(
uuur uur
S n S Vn
uuur uur
S n S Vn
) .Vuur
(105)
(106)
(107)
uuur
Sn S
The value of uuur uur may be computed as follows:
S n S Vn
x = 0
uur
Vn = y = 0
z = 1
dn
uuur
Sn S
z = + d n .sin ( ElS )
(108)
(109)
(110)
(111)
uuur uur
Sn S Vn = d n .cos ( ElS )
(112)
uuur
Sn S
1
uuur uur =
cos ( ElS )
S n S Vn
ETSI
(113)
63
Then:
sin ( i ) =
.
cos ( ElS )
uuur uur
S n S Vn
uuur uur
S n S Vn
) .Vuur
(114)
sin ( i ) for given values of the satellite elevation ElS and of the vertical
uur uur
offset Vn Vn are simplified when using a local Cartesian coordinate system ( S n , x% , y% , z% ) oriented such that the
The computation of the maximum value of
z%
Vn
Vn
Sn
y%
S
ElS
n
x%
Figure 47: Local Cartesian coordinate system
( Sn , x%, y% , z% )
Let:
( Sn , x%, y% , z% ) :
uur
uur uur uur
Vn relative to the vertical Vn : Vn Vn
()
sin ;
uur
Vn in the horizontal plane with the x% axis.
Then:
x% = 0
uur
Vn = y% = 0
z% = 1
ETSI
(115)
64
(116)
( ) .cos ( )
( ) .sin ( )
( )
x% = sin
uur
Vn = y% = sin
z% = cos
(117)
( ) .sin ( )
( ) .cos ( ) cos ( El ) .cos ( )
( ) .sin ( )
(118)
uuur uur
uur
Sn S
Vn Vn = cos ( ElS ) .sin .sin ( )
uuur
Sn S
()
(119)
uuur uur 2
2
Sn S
uuur Vn = sin .sin ( ) + sin ( ElS ) .sin .cos ( ) cos ( ElS ) .cos
Sn S
( ()
) (
( ))
()
(120)
()
sin .sin ( )
sin ( i ) =
sin ( i ) =
(sin () .sin ( ))
(121)
(122)
d sin ( i )
d
) =0
(123)
with:
d sin ( i )
d
(
(
()
()
()
)
)
()
()
2.sin .sin ( ) .
=
2
2 2
(124)
()
( ()
) (
ETSI
( ))
65
d sin ( i )
= k .
) =0
()
()
(125)
= k .
sin ( i ) =
0 + cos ElS +
()
()
tg ( ElS ) .tg 1
for 0
( )
ctg ( ElS ) tg
for
()
()
=0
for ElS
(126)
ElS
sin ( i ) =
( )
sin
cos ( ElS
(127)
0 ElS
(128)
ElS :
2
2
sin ( i ) = 1
( )
ctg ( ElS ) tg
(129)
ElS
2
2
(130)
max
uuuur
axis u Az , S is given by the following equations:
for
for
At given latitude
0 ElS ,max
max
2
imax
sin
max
= ArcSin
cos El
S ,max
imax =
rad
(130a)
(130b)
Ltn the maximum elevation of an antenna is for a satellite within the meridian plane of the antenna.
ETSI
66
cos ( Elmax ) =
.sin ( Ltn )
2 + R 2 2. .R.cos ( Ltn )
(131)
7.1.3
In that clause the equivalent antenna azimuth axis inclination variation i due to the use of an approximated vertical
direction is determined for the case where the antenna mount antenna azimuth axis offset is not equal to zero: i 0 .
As for
i =0:
uuuur
uuur
uuur
u Az , S = cos ( i ) .LS ,n + sin ( i ) .TS ,n
(132)
uuur
uuur
uuuur
u Az , S = cos ( i ) .LS ,n + sin ( i ) .TS ,n
(133)
uuuur
uuur
uuur
u Az , S = cos ( i + i ) .LS ,n + sin ( i + i ) .TS , n
(134)
uuuur uuuur
u Az , S .u Az , S = cos ( i )
(135)
uuur
uuuur uuuur
uuur uuur
Sn S
u Az , S u Az , S = sin ( i ) .TS ,n LS ,n = sin ( i ) . uuur
Sn S
(136)
uuur
uuuur uuuur S S
n
sin ( i ) = u Az , S u Az , S . uuur
Sn S
(137)
but:
cos i
uuur .
S n S + cos
()
1
sin ( i ) = uur uuur uur uuur
Vn S n S . Vn S n S .
uur
1 uur
2
.Vcc + sin ( i ) . uuur 2 .Vss
Sn S
( i ) .sin ( i ) .
uuur .
Sn S
uur uur
Vsc + Vcs
(138)
with:
uur
V
cc
uur
V
ss
uur
V
sc
uur
Vcs
uur uuur
uur uuur uuur
Vn S n S Vn S n S .S n S
(( ) ( ))
uuur uur uuur
uuur uur uuur
uuur
( S S (V S S ) ) ( S S (V S S ) ) .S S
uuur uur uuur
uur uuur uuur
( S S (V S S ) ) (V S S ) .S S
uur uuur
uuur uur uuur uuur
( (V S S ) ( S S (V S S ) ) ) .S S
ETSI
(139)
67
uur uuur
uur
uur uuur uuur
V
S S V S S .S S
=
V
n
n
n
n
n
cc
uur uur uuur
uur uuur uuur
Vcc = Vn Sn S . Vn Sn S Sn S
r uuur
uur uuur uuur
uur uu
Vcc = Vn . Sn S Vn Sn S Sn S
uur
uur uuur uuur uuur uur
V = V S S S S S S .V
n
n
n
n
n
cc
uu
r
uuur 2 uur uuur
uur
Vcc = + Sn S . Vn Sn S .Vn
((
(
) ((
((
(((
))
))
uur uuur
uuur uur uuur
uur uuur
S S S S V S S
V
S
S
V
=
ss
n
n
n
n
n
n
uur
uur uuur uuur
uur uuur uuur
Vss = Vn S n S Sn S . Vn Sn S Sn S
uur
uuur 2 uur uuur uuur uur uuur
Vss = Sn S . Vn Sn S Sn S . Vn Sn S
(140)
)) ( (
( ( )) (( (
(( ) ) ((( )
(( ) ) (
(
uuur
)) .S S
n
uuur
)) S S )
uuur
Sn S
uur
V
=
ss
uur
Vss = +
uur
Vss = +
uur
V =
ss
uur
Vss = +
(
(
)(
) ((
(141)
))
))
(142)
uur uuur
uur uuur uuur
uur uuur
S S V S S .S S
=
V
S
S
V
sc
n
n
n
n
n
n
uur
uur uuur uuur uuur uur uuur
Vsc = Vn S n S S n S S n S . Vn S n S
uur uuur
uur uuur uuur uur
V = S S 2 . V
n
n S n S . S n S Vn
sc
uur uuur 2 uur uuur uuur uur
Vsc = S n S . Vn S n S S n S .Vn
(143)
(((
( ((
)
(((
((
))
)) ((
)
)(
)
ETSI
)(
)
68
uur uuur
uur
uuur uur uuur uuur
V
S S S S V S S .S S
=
V
n
n
n
n
n
n
cs
uur
uur uuur
uur uuur uuur uuur
Vcs = Vn Sn S Vn Sn S Sn S .Sn S
uur uuur
uur uuur uuur uuur
uur
S S . V S S S S S S
=
V
V
cs
n
n
n
n
n
n
uur uuur 2 uur uuur uur uuur
V = S S . V S S . V S S
n
n
n
n
n
cs
uu
r
uur uuur 2
uuur uur uuur
Vcs = Sn S .Vn . S n S Vn Sn S
uur
uur uuur uuur uur
2
V = uuur
.
S
S
V
n
n S n S S n S .Vn
cs
((
((
) ( (
) ((
) (((
(
)(
(
(
))
(144)
))
((
)))
and finally:
uuur
sin ( i ) =
This expression of
uuur
uur
.V
n
1
=
cos ( ElS )
uuur
uur
S S Vn
n
. uuur uur
S n S Vn
) .V
uur
n
(145)
sin ( i ) is independent of i.
7.1.4
uur
V Sn S
uur uuur . uurn uuur
Vn S n S Vn S n S
Sn S
For an antenna mount with alignment possibility of making the antenna azimuth axis parallel to the tangent to the GSO
at the satellite:
uuuur uuuur
u Az , S = u Az , S =
uur uuur
E Sn S uuur
Sn S
uurS uuur
ES S n S
and
uuuur uuuur
u Az , S u Az , S = 0
(146)
then:
uuur
uuuur uuuur S S
n
sin ( i ) = u Az , S u Az , S . uuur
=0
Sn S
(147)
i = 0
(148)
or:
ETSI
69
7.2
N
Vn
Sn
El,S
uEl,S
Az,S
uAz,S
O
i
GSO
uur
uuuur
Figure 48: Estimated North direction N and corresponding Az-axis u Az , S
Let:
Sn :
uur
Vn :
S:
the satellite;
Sn ;
uur
N:
uur
N :
uuuur
u Az , S :
uuuur
u Az , S :
uuur
LS ,n :
uuur
TS ,n :
Sn ;
uur
N of the North is used;
uur
N of the North is used;
uuur
uur
Sn : orthogonal to Sn S and Vn ;
uuur
uuur
Sn containing S, orthogonal to Sn S and to LS ,n ,
(i+i):
uuuur
u Az , S and the left hand side direction
uuur
uur
LS ,n of the satellite for station #n when the correct direction N of the North is used;
uuuur
u Az , S and the left hand side direction
uur
uuur
LS ,n of the satellite for station #n when the estimated direction N of the North is used.
ETSI
70
Then:
uur uuur
uuuur N S S
n
u Az , S = uur uuur
N Sn S
(149)
uur uuur
uuuur N S S
n
u Az , S = uur uuur
N S n S
(150)
uuuur
uuur
uuur
u Az , S = cos ( i ) .LS ,n + sin ( i ) .TS ,n
(151)
uuuur
uuur
uuur
u Az , S = cos ( i + i ) .LS ,n + sin ( i + i ) .TS , n
(152)
uuuur uuuur
u Az , S .u Az , S = cos ( i )
(153)
uuur
uuuur uuuur
uuur uuur
Sn S
u Az , S u Az , S = sin ( i ) .TS ,n LS ,n = sin ( i ) . uuur
Sn S
(154)
uuur
uuuur uuuur S S
n
sin ( i ) = u Az , S u Az , S . uuur
Sn S
(155)
sin ( i ) =
((
uur uuur
N Sn S
uur uuur
N S S
(156)
uur uuur
uur uuur uuur
N Sn S N Sn S .Sn S =
))
uur uuur
uur uuur
uuur uur uuur
uur uuur
= uuur
S S N S S = S S N S S . N S S
S
S
N
.
n
n
n
n
n
n
uu
r
uu
r
uu
r
uur uuur uuur 2
uur uuur
uuur 2 uuur uur
uuur 2
= Sn S . N N .Sn S = Sn S .N . N Sn S = Sn S . Sn S N .N
((
((
))
)(
((
uuur
Sn S
sin ( i ) = uuur uur
S S N
n
uuur uur
Sn S N
uuur uur
Sn S N
uuur uur
1
Sn S N
sin ( i ) =
uur uuur . uuur
uur
sin N , S n S S n S N
ETSI
)) (
uur
.N
uur
.N
(158)
(159)
71
uur uuur
sin N , Sn S 1
sin ( i )
uuur uur
Sn S N
uuur uur
Sn S N
uur
.N
(160)
uur
Sn , a given satellite S and for a given inclination error i the ends of the vector N representing
uuur uur
the estimated directions of the North at station Sn are on a circle in a plane parallel to the plane S n S , N and at a
distance equal to
Sn
El,S
uEl,S
Az,S
sin(i)
uAz,S
r =1
S
GSO
uur
Sn , any satellite S and for a given maximum inclination error i the ends of the vector
uur
uur uur
uur
N representing the estimated directions of the North at station Sn are within the cone N .N = cos ( i ) of axis N
Sn .
ETSI
72
r =1
Sn
El,S
uEl,S
Az,S
sin(i)
uAz,S
S
GSO
uur
uur
N of the North.
uur
N of the North and
Let:
ElN ,n
Az N ,n
( El
N ,n
( Az
N ,n
+ ElN ,n ) :
uur
N of the North pole in station Sn ;
uur
S
the azimuth of the direction N of the North pole in station n ;
uur
S
the elevation of the estimated direction N of the North pole in station n ;
+ Az N , n ) :
uur
S
the azimuth of the estimated direction N of the North pole in station n ;
ElN :
Az N :
Az N , n : Az N , n Az N ;
Ltn ,min :
the maximum operational latitude for which the earth station is designed.
ETSI
73
Then:
x = cos ( Ltn )
uur
N = y = 0
z = + sin ( Ltn )
(161)
= + sin ( ElN ,n )
(162)
and consequently:
El N ,n = Ltn
Az N ,n = 0
(163)
2
2
uur uur
El N ,n
Az N , n
N .N = 1 2.sin
2.sin
.cos ( Ltn ) .cos ( Ltn + ElN , n )
2
2
(164)
N .N cos ( i ) = 1 2.sin
2
(165)
becomes:
2
ElN ,n
Az N ,n
i
sin
+ sin
.cos ( Ltn ) .cos ( Ltn + ElN ,n ) sin
2
2
2
Az
Az N , n
El
N and
N are the maximum absolute values of
If
operational latitude for which the earth station is designed, then:
2
and
ElN ,n
, and if
Ltn ,min
(166)
is the maximum
ElN ,n
Az N ,n
i
sin
+ sin
.cos ( Ltn ,min ) .cos ( Ltn ,min + ElN ,n ) sin
2
2
2
(167)
When the latitude of the station is known with an accuracy highly better than i , e.g. with a GPS, then the maximum
error in azimuth of the direction of the local North or South is given by the following relationship:
ElN ,n = 0
NOTE:
Az N ,n
sin
2
i
sin
cos ( Ltn )
(168)
ETSI
74
For antennas designed to operate at any latitude the condition becomes the following:
ElN ,n = 0
Ltn [ 80, +80]
Az N ,n i
8.1
General
(169)
The computation of the contour of the shadows of the visible part of the GSO on an antenna radiation pattern is required
for the following three cases:
a)
b)
the case of stations within a range of latitudes pointed towards any satellites on the GSO and above a given
elevation, including the case of a station in a given location pointed towards any satellites on the GSO and
above a given elevation.
The functions referred to within the present clause 8 are described in detail in clause 9 (Excel tool).
The method of the computation of the contour is based on the type of antenna mount considered within the present
document. For any other type of antenna mount the same methodology should be followed for the determination of the
normal inclination of the antenna Az-axis and for the determination of the impact of the antenna mount axes alignment
errors on the antenna Az-axis inclination and the methods described within the following two clauses 8.2 and 8.3 apply.
8.2
In the case of a station in a given location pointed towards a given satellite, for the determination of the shadow of the
GSO and its vicinity on the antenna radiation pattern, within the (, ) domain, the method described in clause 9.7.2
applies.
The GSO shadow of the GSO and its vicinity should be computed:
a)
b)
c)
d)
if necessary when the maximum alignment error is large for intermediate alignment errors.
f)
g)
if necessary when the range of inclination offset is large for intermediate values.
For antennas which could be used up-side down, all the above computations should be repeated for the inclination offset
increased or decreased by 180.
The contour of the shadows of the GSO and its vicinity, with alignment errors and inclination offsets, on the antenna
radiation pattern, within the (, ) domain, is the envelop of all the shadows which have been computed.
ETSI
75
8.3
In the case of stations within a range of latitudes pointed towards any satellites on the GSO and above a given elevation,
including the case of a station in a given location pointed towards any satellites on the GSO and above a given
elevation, for the determination of the contour of the shadows of the GSO and its vicinity on the antenna radiation
patterns, within the (, ) domain, the method described in clause 9.6.13 applies.
The contour of the shadows of the GSO and its vicinity should be computed:
a)
b)
c)
d)
if necessary when the maximum alignment error is large for intermediate alignment errors.
f)
g)
if necessary when the range of inclination offset is large for intermediate values.
For antennas which could be used upside down, all the above computations should be repeated for the inclination offset
increased or decreased by 180.
The contour of the shadows of the GSO and its vicinity, with alignment errors and inclination offsets, on the antenna
radiation patterns, within the (, ) domain, is the envelop of all the contours which have been computed.
Excel tool
9.1
General
It is recognized that all the problems of limits and discontinuities have not been fully considered, mainly when crossing
the equator or in the vicinity of the sub-satellite point on the Earth. However it is considered that this tool provide
enough information on the limit within the (, ) domain of the shadow of the GSO arc and its vicinity for
measurement purpose.
The tool consists of:
3 sections for: the constants, the input data, the GSO shadow output data, the contour output data;
4 graphs:
-
the GSO arc and its vicinity for an observer at the ES (the elevation vs. azimuth of the GSO points);
the GSO arc and its vicinity for the antenna (Phi_El vs. Phi_Az of the GSO points);
the GSO arc and its vicinity within the (, ) domain and the limit within the (, ) domain of the
shadow of the GSO arc and its vicinity (Phi.sin(Alpha) vs. Phi.cos(Alpha) of the GSO points);
the minimum off-axis angle, corresponding to the minimum satellite longitude offset, within the (, )
domain.
ETSI
76
9.2
Cell colours
9.3
Constants
Remark
This table is use to display the type of antenna
selected by a number.
9.4
Value
= 3,14159265358979
= Pi_/180
= 42 164
= 6 371
= 1,4142135623731
Unit
rad/
km
km
Remark
GSO radius
Earth radius
= 2
Buttons
one "Command button" with caption "Contour" which initiate the computation of the contour with the input
parameters;
Spin button
When the spin button value of a row is incremented or decremented, the associated integer variable within the row
(e.g. i_ES_Lt_min) and the real variable (e.g. ES_Lt_min) of the row are updated with the spin button integer value.
Any modification of the integer variable results in a modification of the spin button value with that value. A negative
(e.g. -74) value may be given to an integer variable but after action on the spin button the number displayed will be
equal to -74 + 216.
There is an exception for "Lg_S0" where the integer variable is an integer between -100 and 100 and representing a
percentage of the maximum longitude offset of the other satellite.
ETSI
77
9.5
Spin button
Input data
Table 9: Input data within worksheet "GSO"
ETSI
78
100
-74,000/N
74,000/N
1,480/N
65 462/N
74/N
173,000
0,000
173
0
70,553/E
Azimuth_0
Elevation_0
Range of ES latitudes
ES latitude min
ES latitude max
ES latitude step
Markers
Phi
Alpha
Remarks
101,724
7,000
The minimum horizon elevation could be negative for an ES high above the sea level:
Table 10: Examples of negative horizon elevations for
various ES altitudes above the sea level
ES altitude Horizon elevation
0m
-0,000
100 m
-0,321
200 m
-0,454
500 m
-0,718
1 000 m
-1,015
1 500 m
-1,243
2 000 m
-1,435
3 000 m
-1,758
4 000 m
-2,030
9.6
The following Visual Basic functions and subroutines of the module "GSO_arc_functions" are used.
9.6.1
Function Azimuth()
Lg_S
Lt_S
Lg_n
Lt_n
The value of the function Azimuth is computed with the following equation:
S
n
ETSI
(170)
79
9.6.2
Function Elevation()
Lg_S
Lt_S
Lg_n
Lt_n
The value of the function Elevation is computed with the following equations:
rr
S .Sn
= cos ( Lt S ) .cos ( Ltn ) .cos ( Lg S Lg n ) + sin ( Lt S ) .sin ( Ltn )
cos ( n ) =
.R
uuur r
S n S .Vn
sin ( Eln ) = uuur =
Sn S
9.6.3
(171)
.cos ( n ) R
2 + R 2 2. .R.cos ( n )
(172)
Function Phi_Az()
Phi_Az is the angle [] of the projection of the considered direction within the plane defined by the antenna main beam
axis and its Az-axis, with the antenna main beam axis.
The inputs of the function Phi_ Az (Az_S0, El_S0, i, Az_S, El_S) are:
Az_S0
El_S0
Az_S
El_S
The value of the function Phi_ Az is computed with the following equations:
( )
(
( )
(173)
uuur uuuur
za = S n S .u R , S0 = cos ElS0 .cos ( ElS ) .cos AzS0 AzS + sin ElS0 .sin ( ElS )
(174)
Az = ArcTan2 ( xa , za )
(175)
ETSI
80
9.6.4
Function Phi_El()
Phi_El is the angle [] of the projection of the considered direction within the plane defined by the antenna main beam
axis and its El-axis, with the antenna main beam axis.
The inputs of the function Phi_ Az (Az_S0, El_S0, i, Az_S, El_S) are:
Az_S0
El_S0
Az_S
El_S
The value of the function Phi_ El is computed with the following equations:
( )
( )
El = ArcSin ( ya )
9.6.5
(176)
(177)
where:
Phi:
is the off-axis angle [] of the considered direction measured from the antenna main beam axis;
the plane defined by the antenna main beam axis and the considered direction; and
the plane defined by the antenna main beam axis and its Az-axis.
The inputs of these functions Phi_cos_Alpha(Phi_Az, Phi_El) and Phi_sin_Alpha(Phi_Az, Phi_El) are:
Phi_Az: the angle [] of the projection of the considered direction within the plane defined by the antenna main
beam axis and its Az-axis, with the antenna main beam axis;
Phi_El: the angle [] of the projection of the considered direction within the plane defined by the antenna main
beam axis and its El-axis, with the antenna main beam axis.
The value of the function Phi_cos_Alpha is computed with the following equations:
(178)
(179)
Phi_cos_Alpha= M .cos ( M )
(180)
ETSI
81
Phi_sin_Alpha= M .sin ( M )
9.6.6
(181)
Function Inclination_with_Az_El_mount()
The function Inclination_with_Az_El_mount returns the value of the inclination of the antenna Az-axis so that it is
aligned with the GSO tangent.
The inputs of the function Az_El_mount(Lg_S, Lt_S, Lg_n, Lt_n) are:
Lg_S:
Lt_S:
Lg_n:
Lt_n:
The value of the function Az_El_mount is computed with the set of equations selected in clause 6.9.
9.6.7
Function Inclination_with_E_field_alignment()
Lg_S:
Lt_S:
Lg_c:
Lt_c:
i_E0:
Lg_n:
Lt_n:
H_polar:
TRUE when the horizontal polar is used, FALSE when the vertical polar is used.
The value of the function Inclination_with_E_field_alignment is computed with the set of equations selected in
clause 6.10.
9.6.8
Function Inclination_with_equatorial_mount()
The function Inclination_with_equatorial_mount returns the value of the inclination of the antenna Az-axis when a
perfect equatorial mount is used.
The inputs of the function Inclination_with_equatorial_mount(Lg_S, Lt_S, Lg_n, Lt_n) are:
Lg_S:
Lt_S:
Lg_n:
Lt_n:
ETSI
82
The value of the function Inclination_with_equatorial_mount is computed with the set of equations selected in
clause 6.11.
9.6.9
Function Az_El_mount_alignment_error()
uuuur
u Az , S due to a maximum
Vertical_offset:
El_S:
The value of the function Az_El_mount_alignment_error is computed with the following equation:
For El
S
max
imax
imax =
sin
max
= ArcSin
cos ( ElS
rad
(182)
imax :
( )
9.6.10
(183)
Function Az_El_mount_with_E_field_alignment_error()
uuuur
u Az , S due to the E or H field alignment
error, for an antenna with an azimuth-elevation mount and with polarization alignment.
The input of the function Az_El_mount_with_E_field_alignment_error (di_E) is:
di_E:
The value of the function Az_El_mount_with_E_field_alignment_error is computed with the following equation:
i = iE
(184)
i := Sign ( iE ) . i
NOTE:
(185)
It is recognized that presently the above equations could be simplified (e.g. i = iE ) but the general
structure of this clause is kept identical to other similar clauses for possible future developments of this
clause for taking into consideration the various sources of errors.
ETSI
83
9.6.11
Function Equatorial_mount_alignment_error()
The function returns the variation value ( i ) of the antenna Az-axis inclination due to errors on the equatorial mount
North-South axis.
The inputs of the function Equatorial_mount_alignment_error(dAz_N, dEl_N, Lt_n) are:
dAz_N:
dEl_N:
Lt_n:
The value of the function Equatorial_mount_alignment_error is computed with the following equation:
2
2
ElN
Az N
i = 2. ArcSin sin
+
+
sin
.cos
Lt
.cos
Lt
El
(
)
(
)
n
n
N
2
2
i :
i := Sign ( ElN ) .i
9.6.12
(186)
(187)
Function Max_satellite_longitude_offset()
Lt_n:
El_min:
the minimum elevation of the satellite []. This parameter is optional. The default value is equal to
0;
Lt_S:
the satellite latitude [/N]. This parameter is optional. The default value is equal to 0.
The value of the function Max_satellite_longitude_offset is computed with the following equations:
2
R
R
2
2
cos ( n ) = .cos ( Eln ) + sin ( Eln ) . 1 .cos ( Eln )
(188)
( Lg S Lg n ) = ArcCos
9.6.13
(189)
Subroutine GSO_external_contour()
The subroutine GSO_external_contour() computes the contour within the (, ) domain of the shadows of the GSO arc
and its vicinity for various positions of the ES and the pointed satellite.
This subroutine is activated by the command button "Contour" and by some spin buttons.
The inputs of the subroutine GSO_external_contour() are read in the worksheet "GSO":
ES_Lg:
ES_Lt_min:
ES_Lt_max:
ETSI
84
ES_El_min:
Hz_El_min:
Type_of_antenna_mount:
1 for Az_El_mount_without_alignment;
2 for Az_El_mount_WITH_alignment;
3 for Az_El_mount_WITH_polar_alignment;
4 for Equatorial_mount;
Permanent_alignment_error:
Vertical_offset:
dAz_N:
dEl_N:
The contour is computed for three adjacent satellite latitudes (-3, 0 and +3), and for different cases:
the cases where the ES latitude varies from the minimum latitude to the maximum latitude, the ES antenna is
successively pointed towards the western and eastern satellites at the minimum elevation, and the satellites to
be protected are successively the eastern and western satellites at the minimum elevation;
the cases where the ES latitude is maximum, the ES antenna is successively pointed towards the western and
eastern satellites at the minimum elevation, and the longitude of the satellite to be protected varies from the
eastern to the western satellite longitudes at the minimum elevation. If the absolute value of the ES maximum
latitude is lower than 1 then computations are made with 1 instead of the ES maximum latitude;
the cases where the ES latitude is minimum, the ES antenna is successively pointed towards the western and
eastern satellites at the minimum elevation , and the longitude of the satellite to be protected varies from the
eastern to the western satellite longitudes at the minimum elevation. If the absolute value of the ES minimum
latitude is lower than 1 then computations are made with 1 instead of the ES minimum latitude;
the cases where the ES latitude is minimum, the longitude of the satellite pointed by the ES antenna varies
from the eastern to the western satellite longitudes at the minimum elevation, and the longitude of the satellite
to be protected is successively the eastern to the western satellite longitudes at the minimum elevation. If the
absolute value of the ES minimum latitude is lower than 1 then computations are made with 1 instead of the
ES minimum latitude.
In each case, for a given pointed satellite longitude (Lg_S0) and a given longitude (Lg_S) of the other satellite the
values of the following variables are computed using the functions already described:
Table 11: Intermediates variables of subroutine GSO external contour
Variables
Az_S0
El_S0
Az_S
El_S
Nominal_inclination
Equations
= Azimuth (Lg_S0, 0, ES_Lg, ES_Lt) '/N
= Elevation (Lg_S0, 0, ES_Lg, ES_Lt) '
= Azimuth (Lg_S, Lt_S, ES_Lg, ES_Lt) '/N
= Elevation (Lg_S, Lt_S, ES_Lg, ES_Lt) '
= (See next table)
Alignment_error
i_S0
Phi_Az_S
Phi_El_S
Phi_cos_Alpha_S
= Nominal_inclination + Alignment_error
Permanent_alignment_error
= Phi_Az (Az_S0, El_S0, i_S0, Az_S, El_S) '
= Phi_El (Az_S0, El_S0, i_S0, Az_S, El_S) '
= Phi_cos_Alpha (Phi_Az_S, Phi_El_S)
Phi_sin_Alpha_S
ETSI
Remarks
Azimuth of the pointed satellite
Elevation of the pointed satellite
Azimuth of the other satellite
Elevation of the other satellite
Antenna Az-axis inclination,
according to the Type_of_antenna_mount
Antenna Az-axis inclination error due to the
antenna mount axes alignment errors,
According to the Type_of_antenna_mount
Global inclination of the antenna Az-axis
Off-axis angle along the antenna Az-Axis
Off-axis angle along the antenna El-Axis
Phi * Cos(Alpha) ' Alpha is defined after the
next table
Phi * Sin(Alpha) ' Alpha is defined after the
next table
85
Equatorial_mount
Alignment_error
Az_El_mount_alignment_error
(Vertical_offset, El_S0)
0
Nominal_inclination
0
Inclination_with_Az_El_mount (Lg_S0,
0, ES_Lg, ES_Lt)
0
Inclination_with_E_field_alignment
(Lg_S0, 0, Lg_c, Lt_c, i_E0, ES_Lg,
ES_Lt, H_polar)
Equatorial_mount_alignment_error Inclination_with_equatorial_mount
(dAz_N, dEl_N, ES_Lt)
(Lg_S0, 0, ES_Lg, ES_Lt)
The outputs are stored in the table "GSO_external_contour" of the worksheet "GSO". The outputs are:
where:
Phi:
is the off-axis angle [] of each considered direction measured from the antenna main beam axis;
the plane defined by the antenna main beam axis and each considered direction; and
the plane defined by the antenna main beam axis and its Az-axis.
9.6.14
Subroutine GSO_internal_contour()
The subroutine GSO_internal_contour () computes the minimum off-axis angles within the (, ) domain
corresponding to the minimum longitude offset (dLg_S_min) for various positions of the ES and the pointed satellite.
This subroutine as the subroutine GSO_internal_contour() is activated by the command button "Contour" and by some
spin buttons.
The inputs of the subroutine GSO_internal_contour() are read in the worksheet "GSO". Their are those of the subroutine
GSO_external_contour() plus the following input data:
dLg_S_min:
The minimum off-axis angles corresponding to the minimum longitude offset (dLg_S_min) have been computed for
three adjacent satellite latitudes (-3, 0 and +3), and for following cases:
the cases where the ES latitude varies from the minimum latitude to the maximum latitude, the ES antenna is
pointed towards the satellite at the ES latitude, and the satellites to be protected are successively the East and
West satellites at the minimum longitude offset (dLg_S_min);
the cases where the ES latitude varies from the minimum latitude to the maximum latitude, the ES antenna is
successively pointed towards the West and East satellites at the minimum elevation, and the satellites to be
protected are successively the East and West satellites at the minimum longitude offset (dLg_S_min).
The outputs are stored in the table "GSO_internal_contour" of the worksheet "GSO". The structure of that table is
identical to the structure of the "GSO_external_contour" table.
ETSI
86
9.7
9.7.1
General
4 graphs which have already been presented along the present document.
9.7.2
The GSO shadow on the antenna radiation pattern, within the (, ) domain for a given ES and a given pointed satellite
uses the following inputs.
Table 13: Inputs for the computation of the GSO shadow on the antenna radiation pattern
Title
Antenna inclination
i_0
Earth station
ES latitude
ES longitude
Minimum horizon
elevation
Pointed satellite
Azimuth_0
Elevation_0
Variable
Remarks
-127,930
ES_Lt
ES_Lg
Hz_El_min
36,000/N
0,000/E
0,000
[-90, +90]
[-180, +180]
[-90, +90], of the other satellite
Azimuth_0
Elevation_0
101,724
7,000
ETSI
87
The GSO shadow on the antenna radiation pattern is computed within the worksheet "GSO" according to the following
formulae.
Table 14: Formulae and intermediate variables for the computation
of the GSO shadow on the antenna readiation pattern
Title
Satellite latitude
Variable
Formula
Lt_S
-3
Max satellite
longitude offset
Satellite longitude
step
Satellite longitude
dLg_S_max
dLg_S
= Max_satellite_longitude_offset
(ES_Lt; Hz_El_min; Lt_S)
= dLg_S_max / 50
Lg_S
= Lg_S + dLg_S
Az_S - 180
Az_S_180
El_S
El_S
Phi_Az
Phi_Az
Phi_El
Phi_El
.cos ()
.sin ()
ETSI
Remarks
Satellite latitude: -3, 0 and +3
successively
Satellite longitude
Lg_S is initiated with:
(ES_Lg - dLg_S_max)
and is increased up to:
(ES_Lg + dLg_S_max)
Satellite azimuth
Satellite elevation
The angle [] of the projection of the
satellite direction within the plane
defined by the antenna main beam axis
and its Az-axis, with the antenna main
beam axis
The angle [] of the projection of the
satellite direction within the plane
defined by the antenna main beam axis
and its El-axis, with the antenna main
beam axis
For the meaning of Phi_cos_Alpha_S
see the subroutine
"GSO_external_contour".
For the meaning of Phi_sin_Alpha_S
see the subroutine
"GSO_external_contour".
88
History
Document history
V1.1.1
February 2005
Publication
V1.2.1
August 2007
Publication
ETSI