Académique Documents
Professionnel Documents
Culture Documents
1.
If an alternator has 4 poles and 1800 rpm
frequency is:
a) 60 cps
b) 120 cps
c) 100 cps
2.
3.
4.
5.
6.
7.
15.
16.
a)
b)
c)
d)
17.
Alcladding means
a) to roll a pure Al- sheet over Al-alloy
b) Al-alloy over pure at sheet
c) both
18.
19.
20.
a)
8.
9.
10.
11.
12.
21.
22.
23.
24.
25.
13.
a)
b)
c)
a)
26.
Anodizing is:
a) electrolytic treatment
b) simple chemical treatment
27.
39.
28.
40.
29.
41.
Teflon hose:
unaffected by any known fuel and other
solvents
b) its disadvantage is to operating strength
c) both
a)
30.
42.
43.
a)
44.
In R.L.C. circuit:
a) p.f. is more if XI < Xc
b) p.f. is more if R < Xc
c) p.f. is more if Xc < Xl
45.
46.
Intergranular corrosion:
a) it is an attack along grain boundaries
b) very severe cases, may cause the surface of
metal to exfoliate
c) it is caused by improper heat treatment
d) all
47.
1 milibar:
a) 0.75 cm
b) 0.75 inch
c) 1.013 cm of Hg
31.
32.
33.
34.
35.
36.
37.
38.
48.
a)
49.
50.
51.
59.
60.
61.
c)
a)
52.
62.
Addendum means:
portion of teeth that projects above or
outside of pitch circle.
b) Portion that projects below the pitch circle
a)
53.
63.
Honeycomb has:
a) high strength to wt ratio
b) corrosive resistant
c) As in a & b & more weight than alloys
a)
54.
55.
56.
a)
b)
c)
d)
a)
b)
c)
d)
57.
58.
Synchronization alternator:
two or more alternator must have same phase
sequence as well as equal voltage and
frequency
b) two or more alternator must have same phase
sequence as well as equal voltage and different
frequency
a)
b) Face, heel,edge
c) Edge , heel, face
71. Fig indicate (FAA 533)
a) extension bar
b) Socket
c) Hinge handle
72. Why triangular file use
c)
none
102.Mg is
a) has tendency to crack
b) resistance to corrosion
c) both a & b
114.MTCS
a) Al alloy close tolerance bolt used with grease
b) Internal wrenching bolt
c)
Clevis bolt
115.This bolt is
a) internal wrenching bolt
b) clevis bolt
c) Al alloy close tolerance bolt
116.Turn buckle consist of
a) brass barrel with left & right hand thread
b) stainless steel barrel with either left hand or
right hand thread
c) only Cadmium plated steel barrel and end
fitting
d) none
117.Fig shows
a) hidden line
b) visible outlines
c) centre line
d) none
118.For cleaning anodized surfaces
a) aluminium Wire brushes useD
b) steel wire brush
c) chemical method
119.On lead acid battery compartment neutralize acid
deposites we use
a) Bi carbonate of soda
b) Boric acid
c) Vinegar