Académique Documents
Professionnel Documents
Culture Documents
KM40108849C3
Telephone Equipment
KX-T2375MXW
Integrated Telephone System
White Version
(for Asia, Middle Near East and other areas)
KX-T2375MXW
CONTENTS
Page
1 LOCATION OF CONTROLS
2 DISPLAY
3 CONNECTION
Page
11.1. Communication ICs
12 MODULE BLOCK DIAGRAM
20
21
21
21
13 CIRCUIT OPERATION
22
22
22
23
24
25
26
4 SETTINGS
5 SPECIAL FEATURES
5.1. FLASH Button
27
10
27
11
28
12
28
13
29
6 DISASSEMBLY INSTRUCTIONS
14
30
15
31
27
7.1. Preparation
15
7.2. Procedure
7.3. Modification Procedure of Bridge
8 CPU DATA
31
15
33
15
34
16
18.1. MEMO
35
8.1. IC801
16
19 SCHEMATIC DIAGRAM
36
17
39
18
39
10 BLOCK DIAGRAM
19
40
20
2
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
1 LOCATION OF CONTROLS
3
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
2 DISPLAY
4
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
3 CONNECTION
3.1.
3.2.
If you connect a communication device (computer, modem, fax, answering machine, etc.) to the telephone line, you can
connect it through this unit using the DATA jack.
After connecting the handset and telephone line cord, connect the communication device telephone line cord to the DATA jack.
Make sure the communication device is not in use before using this unit (making calls, storing phone numbers in memory etc.)
or the communication device may not operate properly.
5
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
4 SETTINGS
4.1.
You can select the dialing mode by programming. If you have touch tone service, set to "Tone". If rotary or pulse service is used,
set to "Pulse". Your phone comes from the factory set to "Tone".
Make sure that a call is not put on hold.
6
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
4.2.
Time Adjustment
7
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
4.3.
You can select the LCD contrast level from 1 to 4 by programming. Your phone comes from the factory set to 3.
Make sure that a call is not put on hold.
4.4.
You can select the ringer volume to HIGH, LOW or OFF. Your phone comes from the factory set to HIGH.
8
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
5 SPECIAL FEATURES
5.1.
FLASH Button
Pressing
allows you to use special features of your host PBX such as transferring an extension call or accessing
special telephone services (optional) such as call waiting.
5.2.
The flash time depends on your telephone exchange or host PBX. You can select the following flash times: "80, 90, 100, 110,
200, 250, 300, 400, 600, 700 ms (milliseconds)". Your phone comes from the factory set to "600 ms".
Make sure that a call is not put on hold.
If you are connected via a PBX, a longer flash time may be necessary to use PBX functions (transferring a call, etc.). Consult
your PBX installer for the correct setting.
9
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
5.3.
A 4-digit Pin Code (Personal Identification Number) prevents unauthorized persons from using your unit. The Pin Code is
required for the dial lock and call restriction to be set or canceled. The factory preset Pin code is "1111".
Make sure that a call is not put on hold.
10
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
5.4.
Dial Lock
You can prevent others from making a call to any number except the one pre-programmed in the memory of the EMERGENCY
button. Once you locked the dialing buttons, even emergency numbers cannot be dialed. Only incoming calls are accepted until
the dial lock is canceled.
Before using this feature, we recommend storing an emergency number in the memory of the EMERGENCY button. Even if the
dialing buttons are locked, the number stored in the button can be dialed.
If you choose not to program emergency numbers, but plan to use the dial lock, any number programmed into the
EMERGENCY button can be accessed.
5.4.1.
You can use the following features while the dialing buttons are locked.
Dialing a number you programmed into the memory of the EMERGENCY button.
Adjusting the handset and speakerphone volumes.
Muting the conversation.
Answering the second call by pressing
5.4.2.
will disappear, and the unit will return to the standby mode.
11
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
5.5.
Call Restriction
You can prevent the unit from dialing phone numbers beginning with specified digit(s) (1 digit or 2 digits). Phone numbers with
the restricted leading digits cannot be dialed out.
5.5.1.
If your unit is connected to a PBX, this function may not operate. Contact your PBX supplier for more information.
When dialing a phone number with the restricted leading digit(s), the dialed number will flash on the display, but not dialed out.
12
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
5.6.
13
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
6 DISASSEMBLY INSTRUCTIONS
Ref. No.
1
2
Procedure
1
1~2
Shown in Fig .
1
2
To remove .
Lower Cabinet
Printed Circuit Board
14
Downloaded from www.Manualslib.com manuals search engine
Remove .
Screws (2.612) . . . . . . . . . . . . . (A)5
Remove the P.C.Board
KX-T2375MXW
Preparation
SOLDER
Sparkle Solder 115A-1, 115B-1 or Almit Solder KR-19, KR-19RMA
Soldering iron
Recommended power consumption will be between 30 W to 40 W.
Temperature of Copper Rod 662 50F (350 10C)
(An expert may handle between 60 ~ 80 W iron, but beginner might damage foil by overheating.)
Flux
HI115 Specific gravity 0.863
(Original flux will be replaced daily.)
7.2.
Procedure
3. Solder employing specified solder to direction of arrow, as sliding the soldering iron.
7.3.
15
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
8 CPU DATA
8.1.
IC801
16
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
8.2.
Speakerphone IC Data
Pin Name
Description
NO.
1
RR
A resistor to ground provides a reference current for the transmit and receive attenuators.
2
RTX
A resistor to ground determines the nominal gain of the transmit attenuator. The transmit channel gain is inversely proportional to
the RTX resistance.
3
TXI
Input to the transmit attenuator. Input resistance is nominally 5.0 kohms.
4
TXO
Output to the transmit attenuator. The TXO output signal drives the input of the transmit level detector, as well as the external
circuit which drives the telephone line.
5
TLI
Input of the transmit level detector. An external resistor ac coupled to the TLI pin sets the detection level. Decreasing this resistor
increases the sensitivity to transmit channel signals.
6
TLO
Output of the transmit level detector. An external resistor and capacitor set the time the comparator will hold the system in the
transmit mode after speech ceases.
7
RLI
Input of the receive level detector. An external resistor ac coupled to the RLI pin sets the detection level. Decreasing this resistor
increases the sensitivity to receive channel signals.
8
RLO
Output of the receive level detector. An external resistor and capacitor set the time the comparator will hold the system in the
receive mode after the receive signal ceases.
9
MCI
Microphone amplifier input. Input impedance is nominally 10 kohms and the dc bias voltage is approximately equal to VB.
10
MCO Microphone amplifier output. The mic amp gain is internally set at 34 dB (50 V/V).
11
CP1
A parallel resistor and capacitor connected between this pin and Vcc holds a voltage corresponding to the background noise level.
The transmit detector compares the CP1 voltage with the speech signal from CP2.
12
CP2
A capacitor at this pin peak detects the speech signals for comparison with the background noise level held at CP1.
13
XDI
Input to the transmit detector system. The microphone amplifier output is ac coupled to the XDI pin through an external resistor.
14
SKG High current ground pin for the speaker amp output stage. The SKG voltage should be within 10 mV of the ground voltage at pin
22.
15
SKO Speaker amplifier output. The SKO pin will source and sink up to 100 mA when ac coupled to the speaker. The speaker amp gain
is internally set at 34 dB (50 V/V).
16
V+
Input dc supply voltage. V+ can be powered from Tip and Ring if an ac decoupling inductor is used to prevent loading ac line
signals. The required V+ voltage is 6.0 to 11 V (7.5 V nominal) at 7.0 mA.
17
AGC A capacitor from this pin to VB stabilizes the speaker amp gain control loop, and additionally controls the attack and decay time
of this circuit. The gain control loop limits the speaker amp input to prevent clipping at SKO. The internal resistance at the AGC
pin is nominally 110 kohms.
18
CS
Digital chip select input. When at a Logic "0" (<0.7 V) the Vcc regulator is enabled. When at a Logic "1" (>1.6 V), the chip is in the
standby mode drawing 0.5 mA. An open CS pin is a Logic "0". Input impedance is nominally 140 kohms. The input voltage should
not exceed 11 V.
19
SKI
Input to the speaker amplifier. Input impedance is nominally 20 kohms.
20
Vcc
A 5.4 V regulated output which powers all circuit expect the speaker amplifier output stage. Vcc can be used to power external
circuitry such as a microprocessor (3.0 mA max). A filter capacitor is required. The MC 34018 can be powered by a separate
regulated supply by connecting V+ and Vcc to a voltage between 4.5 V and 6.5 V while maintaining CS at a Logic "1".
21
VB
An output voltage equal to approximately Vcc/2 which serves as an analogue ground for the speakerphone system. Up to 1.5 mA
of external load current may be sourced from VB. Output impedance is 250 ohms. A filter capacitor is required.
22
Gnd
Ground pin for the IC (except the speaker amplifier).
23
XDC Transmit detector output. A resistor and capacitor at this pin hold the system in the transmit mode during pauses between words
or phrases. When the XDC pin voltage decays to ground, the attenuators switch from the transmit mode to the idle mode. The
internal resistor at XDC is nominally 2.6 kohms.
24
VLC
Volume control input. Connecting this pin to the slider of a variable resistor provides receive mode volume control. The VLC pin
voltage should be less than or equal to VB.
25
ACF
Attenuator control filter. A capacitor connected to this pin reduces noise transients as the attenuator control switches levels of
attenuation.
26
RXO Output of the receive attenuator. Normally this pin is ac coupled to the input of the speaker amplifier.
27
RXI
Input of the receive attenuator. Input resistance is nominally 5.0 kohms.
28
RRX A resistor to ground determines the nominal gain of the receive attenuator. The receive channel gain is directly proportional to the
RRX resistance.
17
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
18
Downloaded from www.Manualslib.com manuals search engine
10 BLOCK DIAGRAM
19
KX-T2375MXW
KX-T2375MXW
20
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
signal
VDD
VLCD
VSS
DATA
WR
CS
Function
Power Supply (5V)
LCD Power Input
Power Gnd (0V)
Serial Data Input
Write Data
Chip Selection
21
Downloaded from www.Manualslib.com manuals search engine
Enable
H/L
H, L L
H, L H
KX-T2375MXW
13 CIRCUIT OPERATION
13.1. Bell Detector Circuit
When the bell signal is input between T/R, the signal are outputted at the speaker via the following path: Tel line R1/C1
D1 Pin 1 of IC1 Pin 8 of IC1 C6 T1 C625 Speaker
22
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
23
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
24
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
25
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
26
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
Check
Check
Check
Check
Check
Check
Check
Check
Check
Check
Check
Check
Check
Check
27
Downloaded from www.Manualslib.com manuals search engine
CURE
IC801, X801, X802
Q109, Q405, Q406.
Q421, Q424, Q108.
IC801, R921, R922, R923 and C923.
Q101, Q103, Q104.
IC201, Q201.
D1, IC1 and Q1.
IC601.
Q107.
handset jack
headset jack
IC801, IC601
IC801, Q405
IC801, Q108, Q401.
KX-T2375MXW
28
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
29
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
30
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
17 REPLACEMENT PARTS
LIST
Ref.
No.
10
11
12
13
14
15
16
17
18
19
Part No.
PQKM10503Z1
PQYF10525Z1
PQBC10347Z1
PQBH10034Z1
PQBX10348Z1
PQAS57P03Z
PQGD10162Z
PQGV10039Z
PQHR10875Z
Remarks
S
S
S
S
S
31
Downloaded from www.Manualslib.com manuals search engine
PQKK10105Z1
PQKE10070Z3
PQJC10044Z
PQJC10045Z
PQJC313Z
PQJC314Z
PQQT22058Z
PQSX10186Y
PQSX10187Z
PQGP10190Z1
Remarks
S
S
Ref.
No.
Part No.
Ref.
No.
PCB1
Part No.
PQWPT2375MXW
IC1
IC201
IC302
IC303
IC304
IC601
IC801
IC903
PQVIBA8206F
PQVINJM2904F
PQVIPS3238NT
PQVIPS3327UT
PQVIXCF3702P
PQVISC77655S
C2CBFE000007
PQVIUM66T11L
Q1
Q101
Q103
Q104
Q107
Q108
Q109
Q201
Q302
Q303
Q401
Q405
Q406
Q421
Q423
Q424
Q425
Q426
Q491
Q492
Q493
Q602
Q801
Q802
2SD1819A
2SA1625
PQVT2N6517CA
2SK1398
2SD1819A
2SC2120
2SD1819A
UN5213
2SD1819A
2SB1218A
PQVTFB1J3P
2SD1819A
2SD1819A
2SD1819A
PQVTFB1A4M
2SD1819A
2SD1819A
2SD1819A
UN5213
UN5213
UN5213
UN5213
PQVTDTC144TU
PQVTDTC144TU
D1
D2
D3
D101
D102
D103
D104
D105
D106
D202
D203
D301
D302
D304
D305
D308
D401
D601
D602
D907
LED1
LED801
PQVDS1ZB60F1
MA4300
1SS119
PQVDS1YB60F1
MA111
MA111
MA4180
1SS119
MA4062
MA111
MA111
MA111
1SS119
1SS119
MA111
1SS119
MA111
1SS119
MA111
MA111
PSVD1SRCT
PSVD1SRCT
Remarks
S
S
S
S
S
S
S
S
S
S
S
S
S
S
S
S
S
S
S
S
S
S
S
S
S
KX-T2375MXW
Ref.
No.
Part No.
JJ101
JJ102
Handse
CN401
PQJJ1T020Z
PQJJ1T020Z
PQJJ1T030Z
PQJJ1C001Z
LCD
L5DCBJC00001
SA101
PQVDDSS301L
S1
SW101
PQSS3A17W
PQSH2B105Z
T1
PQLT2D2A
X801
X802
PQVBCST80MG6
PFVCCFS32Z
R1
R2
R3
R4
R5
R6
R7
R101
R102
R103
R104
R105
R107
R108
R116
R117
R118
R119
R120
R121
R123
R124
R125
R126
R127
R128
R129
R130
R184
R201
R202
R203
R204
R205
R206
R207
R208
R209
R301
R302
R303
R304
R305
R310
R311
R312
R313
R320
R401
R403
R404
R405
R406
R407
R408
ERDS1TJ682
ERJ3GEYJ183
ERJ3GEYJ334
ERJ3GEYJ124
ERJ3GEY0R00
ERJ3GEYJ103
ERJ3GEYJ473
ERDS2TJ563
ERJ3GEYJ104
ERJ3GEYJ104
ERJ3GEYJ473
ERJ3GEYJ684
ERJ3GEYJ474
ERDS2TJ472
ERJ3GEYJ473
ERJ3GEYJ682
ERJ3GEYJ103
ERJ3GEYJ104
ERJ3GEYJ122
ERJ3GEYJ103
ERJ3GEYJ330
ERDS1TJ150
ERJ3GEYJ472
ERJ3GEYJ335
ERJ3GEYJ472
ERJ3GEYJ470
ERJ3GEYJ334
ERJ3GEYJ102
ERJ3GEY0R00
ERDS2TJ103
ERJ3GEYJ124
ERJ3GEYJ103
ERJ3GEYJ394
ERJ3GEYJ562
ERJ3GEYJ183
ERJ3GEYJ103
ERJ3GEYJ472
ERJ3GEYJ104
ERJ3GEYJ225
ERJ3GEYJ685
ERJ3GEYJ225
ERJ3GEYJ475
ERJ3GEYJ221
ERJ3GEYJ223
ERJ3GEYJ104
ERJ3GEYJ104
ERJ3GEYJ104
ERJ3GEYJ103
ERJ3GEYJ333
ERJ3GEYJ473
ERJ3GEYJ183
ERJ3GEYJ333
ERJ3GEYJ335
ERJ3GEYJ222
ERJ3GEYJ681
Remarks
Ref.
No.
R409
R410
R411
R412
R421
R422
R423
R424
R425
R426
R427
R428
R429
R430
R432
R434
R435
R436
R437
R438
R439
R440
R441
R442
R481
R482
R483
R600
R601
R602
R603
R604
R605
R606
R607
R608
R609
R610
R611
R612
R613
R614
R615
R617
R618
R619
R661
R662
R663
R664
R665
R666
R667
R801
R802
R803
R811
R812
R813
R814
R891
R901
R902
R903
R921
R922
R923
D310
D311
L401
J3
J4
J110
S
S
32
Downloaded from www.Manualslib.com manuals search engine
Part No.
ERJ3GEYJ223
ERJ3GEYJ474
ERJ3GEYJ681
ERJ3GEYJ682
ERJ3GEYJ182
ERJ3GEYJ153
ERJ3GEY0R00
ERJ3GEYJ334
ERJ3GEYJ225
ERJ3GEYJ272
ERJ3GEYJ121
ERJ3GEYJ562
ERJ3GEY0R00
ERJ3GEYJ473
ERJ3GEYJ223
ERJ3GEYJ155
ERJ3GEYJ182
ERJ3GEYJ681
ERJ3GEYJ153
ERJ3GEYJ473
ERJ3GEYJ153
ERJ3GEYJ473
ERJ3GEYJ104
ERJ3GEYJ104
ERJ3GEYJ334
ERJ3GEYJ155
ERJ3GEYJ275
ERJ3GEYJ152
ERJ3GEYJ822
ERJ3GEYJ122
ERJ3GEYJ332
ERJ3GEYJ472
ERJ3GEYJ225
ERJ3GEYJ303
ERJ3GEYJ683
ERJ3GEYJ682
ERJ3GEYJ335
ERJ3GEYJ104
ERJ3GEYJ183
ERJ3GEYJ472
ERJ3GEYJ104
ERJ3GEYJ473
ERJ3GEYJ103
ERJ3GEYJ472
ERJ3GEYJ222
ERJ3GEYJ103
ERJ3GEYJ683
ERJ3GEYJ333
ERJ3GEYJ153
ERJ3GEYJ474
ERJ3GEYJ225
ERJ3GEYJ475
ERJ3GEYJ225
ERJ3GEYJ105
ERJ3GEYJ104
ERJ3GEYJ101
ERJ3GEYJ103
ERJ3GEYJ683
ERJ3GEYJ393
ERJ3GEYJ104
ERJ3GEYJ102
ERJ3GEYJ103
ERJ3GEYJ103
ERJ3GEYJ474
ERJ3GEYJ103
ERJ3GEYJ103
ERJ3GEYJ683
PQ4R10XJ000
PQ4R10XJ000
PQ4R18XJ000
ERJ3GEY0R00
ERJ3GEY0R00
ERJ3GEY0R00
Remarks
S
S
S
KX-T2375MXW
Ref.
No.
J111
J115
J120
Part No.
ERJ3GEY0R00
ERJ3GEY0R00
PQ4R10XJ000
C1
C2
C3
C5
C6
C101
C102
C103
C105
C106
C107
C108
C109
C111
C112
C113
C114
C202
C203
C205
C301
C302
C303
C304
C306
C308
C404
C405
C406
C408
C414
C415
C421
C422
C423
C424
C425
C426
C435
C438
C481
C600
C601
C603
C605
C606
C607
C608
C609
C610
C611
C612
C613
C614
C615
C616
C617
C618
C619
C620
C621
C622
C623
C624
C625
C801
C802
C803
C804
ECQE2E105KZ
ECEA1HU100
ECEA1HUR22
ECUV1H822KBV
ECEA1HKA010
ECKD2H681KB
ECKD2H681KB
ECUV1H103KBV
ECEA1CU221
ECEA1HU100
ECEA1AU331
ECUV1C104KBV
ECUV1H103KBV
ECUV1H103KBV
ECUV1C104KBV
ECUV1H333KBV
ECEA1AU470
ECEA1EU470
ECUV1H222KBV
PQCUV1C224KB
ECA0JM471
ECEA0JKA331
ECEA0JU331
PQCUV1H333JC
ECUV1C104ZFV
ECEA0JKA221
ECUV1C104KBV
ECUV1C104KBV
ECUV1H180JCV
ECUV1C104KBV
ECEA1CKA100
ECUV1H103KBV
ECUV1H333KBV
ECUV1E223KBV
ECUV1H682KBV
ECUV1H183KBV
ECUV1C104KBV
ECUV1C104KBV
ECUV1C104KBV
ECUV1C104KBV
ECUV1H103KBV
ERJ3GEY0R00
ECA0JM102B
ECUV1H333KBV
ECUV1E223KBV
ECUV1C683KBV
ECUV1C273KBV
ECUV1C153KBV
ECUV1C104KBV
ECEA1HKA010
ECEA1HKA010
ECEA1VKS4R7
ECUV1C683KBV
ECEA1EU470
ECEA0JU220
ECUV1C104KBV
ECEA1CKS470
ECEA1VU330
ECEA1VKS4R7
ECUV1E183KBV
ECEA0JKA101
ECUV1C104KBV
ERJ3GEY0R00
ECUV1H103KBV
ECEA1AU101
ECUV1H103KBV
ECUV1H120JCV
ECUV1H150JCV
ECUV1C104ZFV
Remarks
S
S
S
S
Part No.
ECUV1C104ZFV
ECUV1H102KBV
ECEA1CKA100
ECUV1H472KBV
ECUV1H103KBV
ECUV1H103KBV
ECUV1H103KBV
ECUV1H332KBV
ECUV1H152KBV
ECUV1H152KBV
E1
E2
PQJM122Z
PQMG10025Z
Remarks
0.1
0.001
10
0.0047
0.01
0.01
0.01
0.0033
0.0015
0.0015
(OTHERS)
MICROPHONE
RUBBER, MIC
S
S
Part No.
A1
A2
A3
A4
A5
A6
PQJA10075Z
PQJA212M
PQJXC0102Z
PQKL10038Y1
PQQW12501Z
PQQX13090Z
P1
P2
PQPH89Y
PQPK13449Z
S
S
S
S
S
S
33
Downloaded from www.Manualslib.com manuals search engine
Ref.
No.
C805
C806
C901
C902
C903
C904
C905
C921
C922
C923
Remarks
KX-T2375MXW
34
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
18.1. MEMO
35
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
(32) (33)
19 SCHEMATIC DIAGRAM
IC601
(31)
IC651
(18)(19)
(5.8V)
(14~17)
Beep
IC903
(11~13)
IC801
DTMF
(1~4)
(5)
3.7V
(3.7V)
(6) (7~9)
(10)
Hold Music
36
Downloaded from www.Manualslib.com manuals search engine
(32) (33)
KX-T2375MXW
(6.3V)
4.2V
(5.8V)
(11~13)
(14~17)
(18)(19)
(31)
IC1
(6.3V)
(1~4)
(5)
(6) (7~9)
(10)
IC201
Battery Low
3.8V
IC304
3.7V
(3.7V)
IC303
4.5V
IC302
3.9V
(5.7V)
37
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
38
Downloaded from www.Manualslib.com manuals search engine
KX-T2375MXW
41
Downloaded from www.Manualslib.com manuals search engine
K
KXT2375MXW
Printed in Japan