Académique Documents
Professionnel Documents
Culture Documents
USERS GUIDE
Table Of Contents
INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TECHNICAL SPECIFICATIONS . . . . . . . . . . . . . . . . . . . . . . . . .
Page 2
INTRODUCTION
The RoboScan 804/805 is a high-performance, intelligent spotlight which
features :
High quality stepper motors
4 dichroic colors, plus white
The RoboScan 804 has 8 manually selectable gobos
The RoboScan 805 has motorized gobos featuring 5 different patterns.
Precision optics
Adjustable focus
180 degree pan and 90 degree tilt
150 watt halogen lamp
Efficient fan cooling
Can be controlled by Martin 2501 (32 pcs.), 2308 (8 pcs.), 2032 (32
pcs.), 3032 (96 pcs.)
Can be controlled by DMX 512 via Martin Interface.
Can run without controller using built-in random-sequence programmes
with and without music trig. (Stand alone)
Built-in microphone for music triggering.
Built-in variable speed control.
HOW TO INSTALL THE ROBOSCAN
Before opening the RoboScan 804/805 be sure to position the mirror
as shown in
figure 1. Failure to do this can result in damage to the
mirror.
Remove the 4 knurled screws as shown in figure 2 pull out the
RoboScan 804/805 chassis, as shown in to figure 3. The lamp can
now be installed. On the RoboScan 804 the desired gobo can be
selected by turning the gobo wheel.
Check the mains voltage on the power supply board (see figure 4):
USA/Canada 110 / 115 / 120V - 60 Hz.
Europe
220 / 230 / 240V - 50 Hz.
If the lamp-life is shorter than expected you can set the voltage to a
higher value. This reduces the voltage applied to the lamp.
Push the RoboScan 804/805 chassis back into place and tighten the
screws.
Mount the RoboScan 804/805, without fully tightening the clamps.
Remove the transport fixture from the mirror.
Page 3
Page 4
Unit no.
1
2
1,2
3
1,3
2,3
1,2,3
4
1,4
2,4
1,2,4
3,4
1,3,4
2,3,4
1,2,3,4
5
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
1,5
2,5
1,2,5
3,5
1,3,5
2,3,5
1,2,3,5
4,5
1,4,5
2,4,5
1,2,4,5
3,4,5
1,3,4,5
2,3,4,5
1,2,3,4,5
6
This page shows the different address and sequence settings for the
DIP switch on the Roboscan models 804/805.
The above settings refer to the pin(s) on the DIP switch which are set
to the ON position.
The examples in figure 1 and figure 2, would be described above as;
"1"(Unit no.1), and; "2,6"(Demo 1).
Page 5
TECHNICAL SPECIFICATIONS
Roboscan 804/805
Dimensions :
Length
Width
Height
560 mm
130 mm
110 mm
Weight:
8.0 Kg
Power consumption:
180 W
Lamp:
150 W HLX
Page 6