Vous êtes sur la page 1sur 2

2002 Ford EXPLORER

Submodel: | Engine Type: V6 | Liters: 4.0


Fuel Delivery: FI | Fuel: GAS

SECTION 501-10: Seating


DISASSEMBLY AND ASSEMBLY

2002 Explorer/Mountaineer Workshop Manual


Procedure revision date: 12/09/2004

Front Seat Cushion


Disassembly
WARNING: Always wear safety glasses when repairing an air bag supplemental restraint system (SRS) vehicle and when handling an air bag module. This will reduce
the risk of injury in the event of an accidental deployment.
WARNING: The safety belt pretensioner is a pyrotechnic device. Always wear safety glasses when repairing an air bag equipped vehicle and when handling a safety
belt buckle pretensioner or safety belt retractor pretensioner. Never probe a pretensioner electrical connector. Doing so could result in pretensioner or air bag
deployment and could result in personal injury.
WARNING: To reduce the risk of personal injury, do not use any memory saver devices.
NOTE: If a seat equipped with a seat mounted side air bag and/or a safety belt pretensioner (if equipped) system is being serviced, the supplemental restraint system (SRS) must
be depowered.
NOTE: The air bag warning lamp illuminates when the RCM fuse is removed and the ignition switch is ON. This is normal operation and does not indicate a supplemental restraint system
(SRS) fault.
NOTE: The SRS must be fully operational and free of faults before releasing the vehicle to the customer.
NOTE: If a front seat has a loose or rocking condition, refer to "the power seat moves but is loose" in the symptom chart before installing new parts.
NOTE: Sport bucket shown, other vehicle seats are similar.
1.

Position the front seat to gain access to all four mounting bolts.

2.

Depower the SRS. For additional information, refer to Supplemental Restraint System (SRS) Depowering and Repowering in the General Procedures portion of Section 501-20B.

3.

Remove the affected seat. For additional information, refer to Front Seat in this section.

4.

Remove the front seat cushion from the seat frame. For additional information, refer to Front Seat Cushion.

5.

CAUTION: Use care when separating the seat cushion covering from the hook and loop fasteners to avoid tearing the fasteners off the seat foam.
Release the seat covering from the seat cushion foam hook and loop attchments.

6.

Remove the two roll pins (for installation, use two new roll pins) and remove the recliner assembly.

Assembly
1.

Install the recliner assembly and install the two new roll pins.

2.

Align and attach the seat upholstery hook and loop fasteners to the seat cushion hook and loop fasteners.

3.

Install the seat cushion on the seat frame. For additional information, refer to Front Seat Cushion.

4.

Install the front seat. For additional information, refer to Front Seat, in this section.

5.

Repower the SRS. For additional information, refer to Supplemental Restraint System (SRS) Depowering and Repowering in the General Procedures portion of Section 501-20B.

Vous aimerez peut-être aussi