Académique Documents
Professionnel Documents
Culture Documents
2007-2008 Expedition
2007-2008 Navigator
ISSUE:
Some 2007-2008 Expedition and Navigator vehicles equipped with electronic stability control (ESC)/roll
stability control (RSC) may exhibit the stability/traction control indicator "sliding-car icon" on or flashing with
diagnostic trouble code (DTC) C1996 or sensitive ESC/RSC activation with no codes.
ACTION:
1.
2.
3.
1.
2.
3.
4.
1.
2.
5.
1.
6.
If no problems found with the stability control sensor cluster proceed to Step 4.
Start engine and keep vehicle at a stand still. Monitor the YAW rate PID value for the Stability
Control Sensor Cluster. Expected values: 2.0 d/s YAW.
If not within specification, replace the Stability Control Sensor Cluster per the Workshop
Manual (WSM), Section 206-09: Vehicle Dynamic Systems.
If within specification, go to Step 5.
Refer to Symptom Chart in the WSM, Section 206-09: Vehicle Dynamic Systems: Unintended ABS
activation, ABS too sensitive, ABS activates on a normal stop.
If no problem found with the base brakes or wheel speed sensors, proceed to Step 6.
If all steps above have no concern or are repaired and concern still exhibited, or you have been
previosly directed to this step, replace the ABS module per the WSM, Section 206-09: Vehicle Dynamic
Systems.
PART NUMBER
7L1Z-2C219-F
9L1Z-2C219-E
7L1Z-3C187-A
7L1Z-2C190-D
7L1Z-2C204-B
7L1Z-3F818-A
PART NAME
ABS Module (2007 Model Year)
ABS Module (2008 Model Year)
Yaw Sensor
Rear Wheel Speed Sensor
Front Wheel Speed Sensor
SWA Sensor
WARRANTY STATUS:
Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits
determined by the identified causal part.
OPERATIO
N
DESCRIPTION
Use SLTS Operations If Available; Claim Additional Diagnosis Or Labor Performed As
MT081402 Actual Time.
are
TIME
Actual
Time
DEALER CODING
BASIC PART NO.
CONDITION CODE
2c219
42
ISSUE:
Some 2007-2008 Expedition and Navigator vehicles built on or before 4/10/2008 may exhibit a traction
control light (TCL) on with diagnostic trouble codes (DTCs) C1277 and/or C1278 (steering wheel angle 1 and
2 circuit failure and/or signal faulted).
ACTION:
SERVICE PROCEDURE
1.
Check to see if the steering wheel rotation (SWR) sensor wiring near the connector has come in
contact with or is touching the brake pedal bracket. Vibration of the harness may cause interruption in the
SWR signal.
1.
2.
2.
3.
4.
If yes, go to Step 2.
If no, do not continue with this procedure. Refer to normal diagnosis in the Workshop
Manual (WSM), Section 206-09.
Repair any chafing that may have occurred.
Move the harness towards the driver's side of the vehicle and tuck in front of the 14401 harness
above the steering column. Use a tie strap to secure in place.
Replace the SWR sensor following WSM, Section 206-09.
PART NUMBER
9L1Z-3F818-A
PART NAME
SWR Sensor
WARRANTY STATUS:
Eligible Under Provisions Of New Vehicle Limited Warranty Coverage
IMPORTANT: Warranty coverage limits/policies are not altered by a TSB. Warranty coverage limits are
determined by the identified causal part.
OPERATIO
N
DESCRIPTION
TIME
2007-2008 Expedition, Navigator: Replace The Steering Wheel Rotation Sensor, Includes
Time To Reposition Harness, Check DTCs, Repair Wires If Required, And Calibrate New
082008A
Sensor. (Do Not Use With 12650D, 14200A)