Académique Documents
Professionnel Documents
Culture Documents
Description
01
Application
02
03
04
05
06
07
08
Degree of protection
09
Type of duty
10
11
Permissible variations in
a) Voltage :
10%
b) Frequency
:
5%
c) Combined
12
13
14
15
100 %
75 %
50 %
Stator winding
Connection
ii)
Type & nos. of terminals Brought out
Starting current as % of full load current
17
16
18
19
20
21
Particulars
Remark if any
Sr. No.
22
Description
Starting time in sec.(Note the type of coupling
mechanism Flexible / hydraulic)
i) with rated voltage
ii) with 85% of rated voltage
iii) with 110% of rated voltage
23
24
Insulation
i) Class of insulation
ii) Material & treatment of Insulation
Whether insulation is suitable
F,Limited to Class B temp. rise.
for ungrounded system
25
Method of starting
26
27
28
29
30
31
32
33
34
35
Method of cooling
Details of water cooling system
Bearings
i. Number
ii.Type
iii.
Space Heaters
Machine Terminal designation corresponds to direction
of rotation (Facing driving end).
iii. Lubrication system
Terminal boxes with accessories separate terminal boxes
provided.
Type & Nos.
Mains
Winding temp. detectors
Bearing Temp. details.
Neutral terminals
Main terminal box details
i) Type & Nos.
ii) Location
iii) Cable gland size & no.
iv) Direction of cable entry.
Space Heater
Number
Location below winding Overhang
Capacity of each
Total power requirement
Voltage
Details of 4 wire RTDs required
i) Nos.
ii) Locations
Whether CTs for differential protection are
If Yes, no. of CTs supplied with motors.
a)
C.T. ratio.
b)
Accuracy Class.
c)
Knee point voltage.
Particulars
Remark if any
d)
S.C. withstand capacity.
e) Exciting Current at Vk / 2.
Sr. No.
Description
36
Type of mounting
37
Shaft orientation
38
Shaft extension
39
40
41
Motor GD2
42
Rotor GD2
43
Noise Level
44
Vibration
Particulars
Remark if any
Drawings furnished
General arrangement of motor
45
ii) ii) Main terminal box showing the method of
terminating the Boards incoming cables
Specifications
as per IS
46
47
Notes:1
User section shall try to furnish above data to get proper Motor from multivendor, if above data not
available, vendor technical team must visit at site to collect data.
a Motor technical data as mentioned above.
b Motor General arrangement drawing.
c Motor characteristic curves.