Académique Documents
Professionnel Documents
Culture Documents
0)
1 Which queuing mechanism can allow for all queues to have an equal priority or allow certain queues relatively higher priorities?
first-in, first-out (FIFO)
increase in throughput
3 Which class-based quality of service (QoS) feature can be used on traffic after the traffic has been classified by network -based
application recognition (NBAR)?
link fragmentation and interleaving (LFI)
traffic shaping
bandwidth multiplexing
4 Which three options can be used for packet classification in priority queuing? (Choose three.)
packet rate
outgoing interface
fragment length
protocol type
packet size
5 Which three link fragmentation and interleaving (LFI) mechanisms are supported by Cisco IOS? (Choose three.)
Multilink PPP (MLP)
FRF.12
stacker
FRF.11 Annex C
predictor
6 Which three WAN link efficiency mechanisms are supported by Cisco IOS? (Choose three.)
payload compression
priority queuing
header compression
Refer to the exhibit. How many packets are in the queue that is associated with Conversation 127?
0
124
585
4096
9
Refer to the exhibit. What is the length of the hardware queue?
0
19
27
75
10
Refer to the exhibit. What type of queuing has been configured for the default class?
FIFO
WFQ
LLQ
priority queuing
11
Refer to the exhibit. After QoS is configured on the tunnel interface that is shown, testing indicated that traffic was not being properly
treated by QoS. What should be done to correct this problem?
The qos pre-classify command should be applied to the tunnel interface.
The crypto map command should be removed from the tunnel interface.
12 What are three things to consider when performing classification and marking in enterprise networks? (Choose three.)
Classification and marking should take place as close to the access edge of the network as possible.
Classification and marking should take place as close to the core edge of the network as possible.
Classification and marking should take place before the traffic reaches a trusted device in the network.
Classification and marking should take place after the traffic reaches a trusted device in the network.
IP precedence and DSCP fields should be used to mark the traffic in order to reduce the classification overhead by the other QoS
tools that are enabled in the network.
ToS and CoS fields should be used to mark the traffic in order to reduce the classification overhead by the other QoS tools t hat are
enabled in the network.
13
Refer to the exhibit. Which statement is true?
Any HTTP traffic whose URL contains the string "search" is marked with DSCP default.
Only HTTP traffic whose URL contains the string "search" will be marked and directed to the default queue.
Any HTTP traffic whose URL contains the string "search" is marked with AF21.
Only HTTP traffic whose URL contains the string "search" will be marked and permitte d on the Fa0/0 interface. The rest of the
traffic will be dropped.
The FIFO strategy is used, which is necessary for the interface drivers to transmit packets one by one.
Round robin, priority queuing, and FIFO can be configured for both incoming and outgoing traffic.
The hardware queue will be emptied based on the configured QoS method.
Refer to the exhibit. What action will result from this configuration?
Any voice traffic exceeding a bandwidth of 10 Mb/s will be dropped.
Any traffic not matching a class will be sent to the default class and must wait to be transmitted until all other queues hav e been
emptied.
All mission-critical traffic exceeding 30 percent o f the bandwidth will continue to transmit unless congestion occurs.
19
Refer to the exhibit. What can be determined from the output in the exhibit?
Low latency queuing is being applied in policy1.