Académique Documents
Professionnel Documents
Culture Documents
(See QW-200.1 , Section IX, ASME Boiler and Pressure Vessel Code)
Company
Name:__________________________________By:____________________________________________
Welding Procedure Specification No.: ______________ Date: _____________Supporting PQR No.
(s)_____________
JOINTS (QW-402)
Details
_______________________
___________________________
Material (Type) ________________
Metal
Nonmetallic
Joints Design:
Backing:
Baking
Nonfusing Metal
Other
PREHEAT (QW-406)
Preheat Temp. Min.
____________________________
Interpass Temp. Max.
__________________________
Preheat Maintenance
__________________________
Gas (QW-408)
Percent Composition
Gas(es)
Mixture
Flow Rate
Shielding
__________
___________
Trailling
__________
__________
Backing
__________
__________
___________
___________
___________
___________________________________________________________________
Multiple or Single Pass (Per side)
__________________________________________________________________
Travel Speed (Range)
___________________________________________________________________________
Peening
______________________________________________________________________________________
Other
_______________________________________________________________________________________
Other
Weld
Layer
(s)
Filler Metal
Current
Process
Class
Diamete
r
Type /
Polarity
Volt
Range
Travel
Speed
Range
(e.g.
Remarks,
Comments,
Hot Wire
addition,
Technique,
Torch
Angle,
etc. )
Amp
Range
No of passes
Voltage
Process
Travel speed
Current
PREHEAT (QW-406)
Preheat Temperature
___________________________
Gas (QW-408)
Percent
Composition
Gas
Mixture
Flow rate
Shielding ___________ _____________
__________
Trailing
___________ _____________
__________
Backing
___________ _____________
__________
Interpass temperature
___________________________
Other
_________________________________________
_____________Rev. ________
Tensile Test (QW-150)
Specimen
No.
1
2
Width
19.16
19.10
Thickness
Area
mm2
Ultimate
total load ,
N
24.91
477.276
232910
25.15
480.365
235520
Guided Bend Tests (QW-160)
Ultimate
Unit Stress,
MPa
488
190.3
Type of
Failure and
Location
Weld area
Weld area
Results
Side Bend
SB-4
Mendril Dia.
Fillet Weld Test (QW-180)
Result Satisfactory : Yes________ No________ Penetration into Parent Metal: Yes ____________
No__________
Other Test
Visual
examination
of
______________________________________________________________
Completed
Test:
Radiography
_______________________________________________________________________________
Test:
Type
of
___________________________________________________________________________________
test:
Deposit
________________________________________________________________________________
analysis:
Other:
________________________________________________________________________________________
Welders
Name:
________________________________________
_______________________________
Stamp
Test
Conducted
______________________________________________________________________________
Laboratory
Test
report
_______________________________________________________________________
No:
By:
No.:
We certify that the statements in this record are correct and the test welds were prepared,
welded and tested in accordance with the requirements of section IX of the ASME BOILER
AND PRESSURE VESSEL CODE.