Académique Documents
Professionnel Documents
Culture Documents
b
t1
R
Lv
t3
25,4
10
197,2
350
6,4
P1
P2
Ratio
J1
c shell
c plate
I1
0,3
0,145
1,12685714
0,05965771
5
3,2
2116,66667
P = P1-P2
MPa
MPa
ratio of long to short side of plate element
check plate parameter table 13-13 c below
I3
554,871467 mm4
Design stress
S
E
0,0 MPa
0,6 MPa
6,6 MPa
mm
mm
mm4
115,1 MPa
1
(4)=(1)+(3)
165,9 MPa
64,3 MPa
(9) or (10)
0,0 MPa
Diametral Plate
ST
(5)=(2)
0%
166,0 MPa
3 bar
13-4(b)
13-4(b)
weld = S.E =
115,1424419
144%
13-4(b)
13-4(b) "The joint efficiency factor E shall also be applied to
the allowable design stress for evaluation of the calculated
bending stress Sb at the location of the joint only. See 13l(d), 13-5 footnote 1, and 13-8(b)."
13-4(b)
primary membrane + bending stress allowable
1,5.S allowable =
172,7 MPa
37%
(11)=(6)+(8)
4%
Diametral Plate
Sm
0,155 MPa
See UW-9 Design of welded joints, (f) Welded Joints Subject to Bending Stresses :
corner joints with fillet welds shall not be used unless the plates forming the corner are
properly supported independently of such welds. See UW-18 FILLET WELDS
USE GREEN RESULTS
See Section 2 for fatigue considerations.
(c) for the case of unequal pressures in the compartiments, stresses are
as follows, where P is the maximum value of P1 or P2.
(1) Membrane stresses
Shell Section
Sm
(1)
5,9 MPa
(6)
primary membrane stress allowable
5%
S allowable = S
115,1 MPa
5%
Diametral Plate
Sm
(2)
0,0 MPa
(7)
primary membrane stress allowable
0%
S allowable = S
115,1 MPa
0%
(2) Bending stresses
Shell Section
Is this check mandatory?
(S b ) A
(3)
58,4 MPa
(8)
If yes, is correct to check against
1%
SE and not 1,5.SE?
Diametral plate
Lv =< 2R
Sb
16700 PSI
Use consistant units (mm, N/mm = MPa) or (in., psi.) with help of parameter b.
fill in yellow cells only
(12)=(7)+(9) or (10)
(4)
N/A
14/11/200709:58
tigny - Eng-Tips
ENG-TIPS de Vessel circular section single diametral staying member rev 000c.xls13-13