Académique Documents
Professionnel Documents
Culture Documents
Hardware Structure
DBS3800V100R007
References
"
DBS3800 Overview
Antenna
BBU3806
RRU3801C
TMA
RF jumper
RRU3801C
RNC
Power cable
RF jumper
BBU3806
+24V/-48V DC
Grounding cable
Power cable
DBS3800 Installation
Outdoor
Outdoor macro
macro NodeB
NodeB
RRU
RRU
BBU
BBU
DBS3800 Deployment
Application scenario 1
Launch 3G services on the basis of a 2G site
DBS3800 Deployment
Application scenario 2
Launch a new 3G outdoor site without an
equipment room
&
DBS3800 Deployment
Application scenario 3:
Launch a new 3G indoor site, there is an equipment room
but the space is limited and load-bearing capacity is week
'(
DBS3800 Deployment
Application scenario 4
Launching a new 3G outdoor site, the operator has no equipment
room or fiber resources, or it is very hard to route optical fibers
''
Baseband unit
BBU3806
BBU3806C
Mini NodeB
RRU3801C
BTS3801C
'
DBS3800 Characteristics
supports circuit domain (CS) and packet (PS) domain services
supports positioning services
supports softer handover, soft handover and hard handover
Supports transmit diversity mode and receive diversity mode
Supports high-speed downlink packet access (HSDPA) technology
HSDPA allows the traffic at up to 14.4 Mbps for a single cell
HDSPA enables a single cell to support 15 OVSF codes
Supports RRU cascading
The maximum distance between two RRUs is 40km
The distance from the first one to the last one should be within 100km
When using the 1.25 G optical module, cascading levels is less than 4
When using the 2.5 G optical module, cascading levels is less than 8
'
'!
BBU Hardware
BTS3801C Hardware
Section4
'"
BBU Overview
BBU3806 appearance
Index
Dimension
BBU3806
BBU3806Cappearance
BBU3806C
the housing )
Weight
15kg
3kg
Power
and Power
Consumption
-48V DC
60W
220V AC
120W
+24V DC
60W
-48V DC
100W
CE Numbers
128CE(UL)/256CE(DL)(V17)
128CE(UL)/256CE(DL)(V17)
Cells
'#
'$
BBU3806 Panel
BITS
GPS
Ela
Elb
EXT_ALM
ON
OFF
OFF
ON
8K/TT110M
RST TYPE LOCAT_ID E1/T1/J1 ETH_RS232 PWR/RS485
TX RX TX RX TX RX
ESD E1/T1/J1
FE0
BBU-RNC interface
DIP switch
BBU-BBU interface
Indicator
BBU-RRU interface
BBU-RNC interface
'%
Iub Interface
Interface between
BBU and RRU
Interface between
BBUs
Types of interface
Quantity
Rate
E1
2 Mbit/s
T1
1.5 Mbit/s
E3
34.4 Mbit/s
T3
44.7 Mbit/s
STM-1
155 Mbit/s
Fast Ethernet
100 Mbit/s
CPRI
1.25 Gbit/s
EIa
3 2.5Gbit/s
EIb
3 2.5Gbit/s
Or
2.5 Gbit/s
'&
CPRI
CPRI
BBU3806 Indicators
Name
Color
Status
Flashing slowly at 0.5 Hz
RUN
green
ALM
red
ACT
green
LIU0
LIU7
green
green
On
Off
Off
On
Theres alarm
On
Off
Off
On
Flashing
CPRI0
CPRI2
Meaning
Off
On
The power of the signal received from the near end is not
enough
Flashing
LOS alarm
'
DIP position2
DIP position3
OFF
OFF
OFF
DIP position4
DIP position5
DIP position6
OFF
OFF
OFF
ON
OFF
OFF
Standby BBU3806
OFF
ON
OFF
Secondary BBU3806
ON
ON
OFF
Tertiary BBU3806
DIP position7
Meaning
undefined default is OFF
Meaning
DIP position8
Meaning
OFF
OFF
120ohm E1
OFF
ON
100ohm T1
ON
OFF
reserved
ON
ON
BBU3806C Panel
Maintenance Panel
Bottom Panel
Distributed Board
RST
10 M
RUN LIU0
PWR
FE
1 2 3 4
OPT
E1/T1 GND
CPRI0 LIU7
ETH_RS232
GPS
E1/T1
CPRI0_TX
CPRI0_RX
CPRI1 LIU6
LOCAT.ID
CPRI2 LIU5
ON
LIU4
OFF
LIU3
E1/T1&75/120
ACT LIU2
CPRI1_TX
CPRI1_RX
CPRI2_TX
CPRI2_RX
RS485&
EXT_ALM
Ela
ON
OFF
BBU Hardware
BTS3801C Hardware
Section4
RRU Overview
RRU3801C
Dimension
the housing
with
Weight
20W
40W
-48V DC
20WPower
amplifier
210W
40WPower
amplifier
240W
Power
Power
Consumption
Sector
Carrier
1 2
"
-40V
Optical interface or
electrical interface
Feedback channel
Transmit signal
processor
Tx1
Rx1
PA
MTRX
Receive signal
processor
Rx1
Rx2
LNA
LNA
Rx2
A&F
subsystem
RRU3801C Panel
Maintenance Panel
TST_ANT
Distributed Board
PWR
TST_CPRI
ALM
TX_ACT/
VSWR
RUN
TST_RSLT
EXT_ALM/ ALD
FAN
CPRI_W
CPRI_E
ETH/RS232
OFF
ON
1
2
3
4
RST
Bottom Panel
RX_IN/OUT
CPRI_E
ANT_TX/RXA
CPRI_W
LOCAT
_ID
ANT_RXB
DIP
DIP Switch
Switch used
used to
to indicate
indicate the
the slot
slot Number
Number of
of RRU3801C,
RRU3801C, not
not used
used yet
yet
RRU3801C Indicators
Name
RUN
ALM
Color
Status
Green
Flashing slowly at
0.5Hz
Flashing fast at1Hz
Red
Red and
Green
On
Off
Off
On
Theres alarm
Green is On
TX_A
CT/VS
WR
Meaning
RRU3801C Indicators
Name
Color
Status
Green is on
TST_RSLT
CPRI_W
Red and
Green
Green
Red is on
Green flashes
slowly at 0.5Hz
Green
Off
Un-tested status
Off
On
Flashing slowly at
0.5Hz
CPRI_E
Meaning
Off
On
Flashing slowly at
0.5Hz
&
BBU Hardware
BTS3801C Hardware
Section4
BTS3801C
Dimension
Weight
35kg
Power and
Power Consumption
Sector
Carrier
20W Power
amplifier
220V AC
310W
40W Power
amplifier
220V AC
340W
1 2
'
BBU Hardware
BTS3801C Hardware
Section4
Networking
BBUs and RNC can form multiple networking modes such as star, chain, tree,
ring, and hybrid
For both chain and tree networking modes:
cascading levels is less than 5
The BBUs in the ring topology require additional transmission equipment.
"
Networking
BBUs and RRUs can form multiple networking modes such as star, chain, tree,
ring, and hybrid
For both chain and tree networking modes:
When using the 1.25 G optical module, cascading levels is less than 4
When using the 2.5 G optical module, cascading levels is less than 8
Typical Configuration1
Typical Configuration2
Typical Configuration3
&
Thank You
www.huawei.com