Académique Documents
Professionnel Documents
Culture Documents
Human Performance
Laboratory, Mapei Sport
Research Center, Castellanza,
Varese, Italy; 2 School of Sport
and Exercise Sciences, Faculty
of Medicine and Surgery,
University of Rome Tor Vergata,
Rome, Italy; 3 Facolta` di
Medicina e Chirurgia, Corso di
Laurea Specialistica in Scienze e
Tecnica dello Sport, Universita`
degli Studi di Firenze, Firenze,
Italia; 4 Department of
Circulation and Medical Imaging,
Norwegian University of Science
and Technology, Faculty of
Medicine, Trondheim, Norway;
5
Department of Cardiology, St.
Olavs Hospital, Trondheim,
Norway
Correspondence to:
Franco M Impellizzeri,
Neuromuscular Research
Laboratory, Schulthess Clinic,
Lengghalde 2, 8008 Zurich,
Switzerland; franco.
impellizzeri@kws.ch
Accepted 14 May 2007
Published Online First
25 May 2007
ABSTRACT
Objective: The lower impact on the musculoskeletal
system induced by plyometric exercise on sand compared
to a firm surface might be useful to reduce the stress of
intensified training periods or during rehabilitation from
injury. The aim of this study was to compare the effects
of plyometric training on sand versus a grass surface on
muscle soreness, vertical jump height and sprinting ability.
Design: Parallel two-group, randomised, longitudinal
(pretest2post-test) study.
Methods: After random allocation, 18 soccer players
completed 4 weeks of plyometric training on grass (grass
group) and 19 players on sand (sand group). Before and
after plyometric training, 10 m and 20 m sprint time,
squat jump (SJ), countermovement jump (CMJ), and
eccentric utilization ratio (CMJ/SJ) were determined.
Muscle soreness was measured using a Likert scale.
Results: No training surface 6 time interactions were
found for sprint time (p.0.87), whereas a trend was
found for SJ (p = 0.08), with both groups showing similar
improvements (p,0.001). On the other hand, the grass
group improved their CMJ (p = 0.033) and CMJ/SJ
(p = 0.005) significantly (p,0.001) more than players in
the sand group. In contrast, players in the sand group
experienced less muscle soreness than those in the grass
group (p,0.001).
Conclusions: Plyometric training on sand improved both
jumping and sprinting ability and induced less muscle
soreness. A grass surface seems to be superior in
enhancing CMJ performance while the sand surface
showed a greater improvement in SJ. Therefore,
plyometric training on different surfaces may be
associated with different training-induced effects on some
neuromuscular factors related to the efficiency of the
stretch-shortening cycle.
METHODS
Study design and randomisation
A parallel two-group, randomised, longitudinal
(pretest2post-test) design was used. After baseline
measurements, subjects were randomly allocated
to two intervention groups: plyometric training on
sand (sand group) and plyometric training on grass
(grass group). Balanced restricted randomization
was obtained using blocks (block sizes of 4 and 6)
with allocation ratio of one-to-one.20 As the
independent variable was training surface, no
Original article
control group was used. Baseline measurements were completed
1 week before the commencement of the training period, while
postintervention measurements were carried out 4 weeks after
the end of the experimental training period. This tapering
duration (4 weeks) was necessary and corresponded to the
recovery period needed to maximize and highlight the traininginduced changes after 4 weeks of high-intensity plyometric
training.21 Furthermore, in the current study we adopted the
training programme used by Luebbers et al.21 to ensure
improvement in jumping ability, with the slight modification
that set 6 repetitions instead of set 6 distance was used.
Participants
Sprinting tests
Muscle soreness
Plyometric training programme
As the preseason training period lasted 4 weeks, we employed a
4-week plyometric training programme similar to that used by
Luebbers et al.21 that has been shown to be effective in
enhancing lower limb muscular anaerobic power (table 1).
Training was completed on a grass pitch or on a 0.2 m-deep dry
sand surface. The characteristics of the sand (ie grain diameter)
resulted in a harder sand surface compared to beach sand. The
plyometric training sessions were completed 3 times a week in
addition to the usual training consisting of generic and specific
aerobic interval training and technical-tactical training.
Participants were asked to exert a maximal intensity during
all the training sessions. Recovery time between repetitions and
sets were 1530 s and 12 min, respectively. During the 4-week
recovery period corresponding to the start of the competitive
season, soccer players trained three times a week and competed
once a week in an official match, but no plyometric exercises or
sprint training were completed.
Training outcomes
Jump tests
Soccer players completed the jump test sessions after a 15 min
warm-up consisting of low-intensity running, striding and selfadministered submaximal jumps performed as practice and
specific additional warm-up. All jumps were performed on a
photocell mat (Optojump, Microgate, Bolzano, Italy) in a
random order with at least five trials of each type of jump test:
squat jump (SJ) and countermovement jump (CMJ). All vertical
jumps were completed keeping the hands on the iliac crest to
Table 1 Four-week plyometric training programme* modified from
Luebbers et al21
Number of sets (number of repetitions)
Exercise
Week 1
Week 2
Week 3
Week 4
Vertical jumping
Bounding
Broad jumping
Drop jump
15 (10)
3 (10)
5 (8)
3 (5)
20 (10)
4 (10)
5 (10)
5 (9)
25
5
7
6
25
5
8
6
(10)
(10)
(10)
(15)
(10)
(10)
(10)
(15)
Statistical analysis
Data are presented as mean (SD). We tested the null hypothesis
of no difference between groups in all baseline measures using
multiple unpaired Student t tests. A two-way mixed analysis of
variance (ANOVA) was used on each continuous dependent
variable. The independent variables included one between
subjects factor, plyometric training surface, with two levels
(grass and sand), and one within subject factor, time, with two
levels (pretest and post-test). We used these ANOVAs to test
the null hypothesis of no different change over time between
the grass and the sand group (plyometric training surface 6time
interaction) and no different change over time in response to
plyometric training intervention. When a significant F value
was found, Bonferronis post hoc test was applied. Effect sizes
(g2) were also calculated, and values of 0.01, 0.06 and above 0.15
were considered small, medium and large, respectively.25 The
level of statistical significance was set at p,0.05.
RESULTS
Thirty-seven players completed the study. No differences were
found between groups in baseline values. No significant
interactions were found for the 10 m sprint time and 20 m
sprint time, while significant interactions were found for CMJ
Table 2
Value Description
0
1
2
3
4
5
6
A
A
A
A
A
A
A
43
Original article
Table 3 Effect of 4 weeks of plyometric training on a grass versus sand surface on sprint and vertical jump performance
Grass group
10 m sprint (s)
20 m sprint (s)
SJ (cm)
CMJ (cm)
CMJ/SJ
Sand group
Pretest
(mean (SD))
Post-test
(mean (SD))
Pretest
(mean (SD))
Post-test
(mean (SD))
Interaction
Value
Descriptor
1.89 (0.08)
3.23 (0.08)
34.0 (3.2)
37.8 (3.6)
1.11 (0.02)
1.82 (0.07)
3.14 (0.09)
35.8 (3.3)
43.3 (5.9){
1.21 (0.03)
1.88 (0.09)
3.19 (0.15)
34.3 (4.5)
37.2 (3.6)
1.09 (0.02)
1.80 (0.11)*
3.11 (0.11)*
37.8 (4.0)*
39.6 (5.5){
1.05 (0.03)*
p = 0.88
p = 0.87
p = 0.08
p = 0.03
p = 0.005
0.001
0.001
0.085
0.124
0.206
Small
Small
Medium
Medium
Large
session were similar between groups (0.4 (SD 0.6) for the sand
group vs 0.6 (SD 0.5) for the grass group).
DISCUSSION
The main findings in the present study were that plyometric
training performed on sand gives a similar improvement in
sprint performance, a different training response on jumping
abilities, but induced less muscle soreness than when performed
on grass. These data suggest different training-induced effects
on neuromuscular factors related to the stretch-shortening cycle
dependent upon the surface on which the training is performed.
Plyometric training is commonly performed on firm surfaces
to create high stretch loads that will store elastic energy,
increase the precontraction activation state and greatly activate
the stretch-reflex to produce explosive concentric muscle
contractions.6 These characteristics have been suggested to
induce neuromuscular adaptations leading to improvement in
performances requiring the stretch-shortening cycle such as
jumping and sprinting.4 6 26 However, this training modality
places considerable demands on the leg muscles, Achilles and
patellar tendons, and muscle2tendon unit.12 27 These factors, in
addition to the fatigue caused by increased training load during
the preseason training period, may increase the injury risk.19 28 29
On the other hand, the use of a softer surface may be useful in
the rehabilitation phase or during intensified training periods to
reduce the stress on the musculoskeletal system and hence the
risk of injuries or re-injuries. The results of the present study
showed that during the 4-week training period, the sand group
44
Original article
experienced less muscle soreness. Indeed, using the 7-point
Likert scale, the mean value of muscle soreness of the sand
group was 0.6 lower than the grass group, with individual
maximal values reached in the first week of training of 5 for the
sand group and 6 for the grass group. This result confirms the
finding of Miyama and Nosaka12 who showed that plyometric
training on sand induced less muscle soreness than jumping on a
firm surface. Muscle soreness decreased during the training
period for both groups indicating a repeated bout effect despite
the fact that the exercise intensity was increased each week.
Although we did not measure other indirect indices of muscle
damage, it is likely that the lower muscle soreness was related to
less muscle damage and hence less stress on the musculoskeletal
system as shown by Mihama and Nosaka.12
A significant effect of training surface was found in some
jump characteristics related to the efficiency of the stretchshortening cycle. During SJ, no prestretch actions are involved
and therefore this type of jump test is commonly considered a
measure of pure concentric strength.23 30 Although both groups
increased their SJ performance, a trend for greater improvement
in the sand group was found. This may suggest that jumping on
sand required a more intense concentric push-off phase,
probably to compensate for the degradation of elastic energy
potentiation caused by sand absorption and the difficulty of the
ankle to push along the vertical axis.13 On the other hand,
performance in CMJ is enhanced by the effects of prestretch
augmentation.31 32 The grass group showed a greater improvement in CMJ than the sand group. Similarly, the eccentric
utilization ratio (CMJ/SJ) increased in the grass group only. As
this index has been suggested to provide information on slow
stretch-shortening cycle performance,23 this finding seems to
indicate a greater effectiveness of plyometric training on grass
on performances requiring slow stretch-shortening cycle
actions. It has previously been reported that vertical jump
heights during SJ and CMJ are lower on sand than on a firm
surface.12 13 33 The lower jump height on sand has been
associated with a lower reuse of the stored elastic energy as
well as energy loss due to feet slipping during the push-off
phase.12 13 34 These characteristics may potentially reduce the
mechanical load on the musculoskeletal system and hence the
training effect on the efficiency of the muscle2tendon
complex.35 However, the other performances requiring fast
stretch-shortening cycle actions increased similarly in both
groups. Indeed, no surface effects were found for sprint
performance. The positive effects of plyometric training on
sprint ability has already been reported.4 However, as in the
present investigation no control group was included, we cannot
exclude that the sprint improvements found after plyometric
training were determined by other physical training exercises
used during the study period (eg generic and specific aerobic
interval training and technical and tactical training).
Nevertheless, the two plyometric training surfaces did not
affect the improvement in sprint performance for distances
typical of soccer.2 The improvement in sprint performance
found in this study may be very useful for soccer players
because it would correspond to an advantage during sprintduels that may allow players to reach the ball before the
opponent.1 However, future studies using biomechanical
analyses are needed to investigate more fully the underlying
mechanisms behind the effect of plyometric training surface on
jumping ability.
Overall, the results of this study suggest that plyometric
training on sand may be incorporated into soccer training when
a reduction of stress on the musculoskeletal system is desired,
REFERENCES
1.
2.
3.
4.
5.
6.
7.
8.
45
Original article
9.
10.
11.
12.
13.
14.
15.
16.
17.
18.
19.
20.
21.
22.
23.
Chimera NJ, Swanik KA, Swanik CB, et al. Effects of plyometric training on muscleactivation strategies and performance in female athletes. J Athl Train 2004;39:24
31.
Marginson V, Rowlands AV, Gleeson NP, et al. Comparison of the symptoms of
exercise-induced muscle damage after an initial and repeated bout of plyometric
exercise in men and boys. J Appl Physiol 2005;99:117481.
McHugh MP. Recent advances in the understanding of the repeated bout effect: the
protective effect against muscle damage from a single bout of eccentric exercise.
Scand J Med Sci Sports 2003;13:8897.
Miyama M, Nosaka K. Influence of surface on muscle damage and soreness induced
by consecutive drop jumps. J Strength Cond Res 2004;18:20611.
Giatsis G, Kollias I, Panoutsakopoulos V, et al. Biomechanical differences in elite
beach-volleyball players in vertical squat jump on rigid and sand surface. Sports
Biomech 2004;3:14558.
Almeida SA, Williams KM, Shaffer RA, et al. Epidemiological patterns of
musculoskeletal injuries and physical training. Med Sci Sports Exerc 1999;31:1176
82.
Woods C, Hawkins R, Hulse M, et al. The Football Association Medical Research
Programme: an audit of injuries in professional footballanalysis of preseason
injuries. Br J Sports Med 2002;36:43641; discussion 441.
Walden M, Hagglund M, Ekstrand J. Injuries in Swedish elite footballa
prospective study on injury definitions, risk for injury and injury pattern during 2001.
Scand J Med Sci Sports 2005;15:11825.
Inklaar H. Soccer injuries. II: aetiology and prevention. Sports Med 1994;18:8193.
Ekstrand J, Nigg BM. Surface-related injuries in soccer. Sports Med 1989;8:5662.
Ekstrand J, Hilding J. The incidence and differential diagnosis of acute groin injuries
in male soccer players. Scand J Med Sci Sports 1999;9:98103.
Schulz KF, Grimes DA. Generation of allocation sequences in randomised trials:
chance, not choice. Lancet 2002;359:5159.
Luebbers PE, Potteiger JA, Hulver MW, et al. Effects of plyometric training and
recovery on vertical jump performance and anaerobic power. J Strength Cond Res
2003;17:7049.
Bagger M, Petersen PH, Pedersen PK. Biological variation in variables associated
with exercise training. Int J Sports Med 2003;24:43340.
McGuigan MR, Doyle TL, Newton M, et al. Eccentric utilization ratio: effect of sport
and phase of training. J Strength Cond Res 2006;20:9925.
24.
25.
26.
27.
28.
29.
30.
31.
32.
33.
34.
35.
36.
37.
38.
Vickers AJ. Time course of muscle soreness following different types of exercise.
BMC Musculoskelet Disord 2001;2:5.
Ary D, Cheser Jacobs L, Razavieh A, et al. Introduction to research in education.
Belmont, CA: Wadsworth, 2006:1557.
Young WB, Wilson GJ, Byrne C. A comparison of drop jump training methods:
effects on leg extensor strength qualities and jumping performance. Int J Sports Med
1999;20:295303.
Jamurtas AZ, Fatouros IG, Buckenmeyer P, et al. Effects of plyometric exercise on
muscle soreness and plasma creatine kinase levels and its comparison with eccentric
and concentric exercise. J Strength Cond Res 2000;14:6874.
Moran KA, Marshall BM. Effect of fatigue on tibial impact accelerations and knee
kinematics in drop jumps. Med Sci Sports Exerc 2006;38:183642.
Zatsiorsky VM. Science and practice of strength training. Champaign, IL: Human
Kinetics, 1995:44.
Hasson CJ, Dugan EL, Doyle TL, et al. Neuromechanical strategies employed to
increase jump height during the initiation of the squat jump. J Electromyogr Kinesiol
2004;14:51521.
Cavagna GA, Dusman B, Margaria R. Positive work done by a previously stretched
muscle. J Appl Physiol 1968;24:2132.
Kubo K, Kawakami Y, Fukunaga T. Influence of elastic properties of tendon structures
on jump performance in humans. J Appl Physiol 1999;87:20906.
Bishop D. A comparison between land and sand-based tests for beach volleyball
assessment. J Sports Med Phys Fitness 2003;43:41823.
Lejeune TM, Willems PA, Heglund NC. Mechanics and energetics of human
locomotion on sand. J Exp Biol 1998;201:207180.
Kjaer M. Role of extracellular matrix in adaptation of tendon and skeletal muscle to
mechanical loading. Physiol Rev 2004;84:64998.
Chmielewski TL, Myer GD, Kauffman D, et al. Plyometric exercise in the
rehabilitation of athletes: physiological responses and clinical application. J Orthop
Sports Phys Ther 2006;36:30819.
Bahr R, Reeser JC. Injuries among world-class professional beach volleyball players.
The Federation Internationale de Volleyball beach volleyball injury study. Am J Sports
Med 2003;31:11925.
Lian O, Refsnes PE, Engebretsen L, et al. Performance characteristics of volleyball
players with patellar tendinopathy. Am J Sports Med 2003;31:40813.
46
Copyright of British Journal of Sports Medicine is the property of BMJ Publishing Group and its content may
not be copied or emailed to multiple sites or posted to a listserv without the copyright holder's express written
permission. However, users may print, download, or email articles for individual use.