Académique Documents
Professionnel Documents
Culture Documents
Product: PL-2303
Features
SSOP 28 PACKAGE
(TOP VIEW)
00/03/27
TXD
28
OSC2
DTR_N
27
OSC1
RTS_N
26
PLL_TEST
VDD_232
25
GND_PLL
RXD
24
VDD_PLL
RI_N
23
LD_MODE
GND
22
TRI_MODE
VDD
21
GND
DSR_N
20
VDD
DCD_N
10
19
RESET
CTS_N
11
18
GND_3V3
SHTD_N
12
17
VDD_3V3
EE_CLK
13
16
DM
EE_DATA
14
15
DP
Company Confidential
Product SPEC
Product: PL-2303
1. Introduction
The PL-2303 operates as a bridge between one USB port and one standard RS232
Serial port. Figure 1 in the following page shows its interface and internal block
diagram.
The two large on-chip buffers accommodate the data flow from two different buses.
The USB bulk-type data is adopted for maximum data transfer. Automatic handshake
is supported at the Serial port. With these, a much higher baud rate can be achieved
compared to the legacy UART controller.
This device is also compliant with USB power management and remote wakeup
scheme. Only minimum power is consumed from the host during suspend. By
integrating all the functions into the SSOP-28 package, this chip is suitable for cable
embedding. Users just simply hook the cable into PC or hub s USB port, then they
can connect to any RS-232 devices.
00/03/27
Company Confidential
Product SPEC
Product: PL-2303
USB
Transceiver
Control
Unit
USB
SIE
REGISTER/
CONFIG/
STATUS/
CONTROL
DOWN
STREAM
BUFFER
UP
STREAM
BUFFER
CLOCK
SYNTHESIZER
OSCILLATOR
RS-232
SERIAL
INTERFACE
Serial Port
EEPROM
INTERFACE
I2C Bus
USB Port
00/03/27
Company Confidential
Product SPEC
Product: PL-2303
2. Pin Description
I Input signal
O Output signal
I/O Bi-directional signal
Name
Pin
No.
1
2
3
4
TXD
DTR_N
RTS_N
VDD_232
O*
O*
O*
P
5
6
7
8
9
10
11
12
13
RXD
RI_N
GND
VDD
DSR_N
DCD_N
CTS_N
SHTD_N
EE_CLK
I*
I*
P
P
I*
I*
I*
O
I/O
14
15
16
17
18
19
20
21
22
23
EE_DATA
DP
DM
VDD_3V3
GND_3V3
RESET
VDD
GND
TRI_MODE
LD_MODE
I/O
I/O
I/O
O
P
I
P
P
I
I
00/03/27
Product SPEC
24
25
26
27
28
VDD_PLL
GND_PLL
PLL_TEST
OSC1
OSC2
00/03/27
P
P
I
I
O
Product: PL-2303
Company Confidential