0 évaluation0% ont trouvé ce document utile (0 vote)
36 vues3 pages
This document contains an assignment for an engineering mechanics course. It lists 8 problems related to mechanics, materials, and structures. The problems involve calculating angles, forces, moments, and pressures given information about physical configurations, masses, loads, dimensions and other mechanical parameters. Students are asked to determine expressions and values to solve for unknown variables in static equilibrium scenarios. The last date to submit the assignment is August 18, 2016.
This document contains an assignment for an engineering mechanics course. It lists 8 problems related to mechanics, materials, and structures. The problems involve calculating angles, forces, moments, and pressures given information about physical configurations, masses, loads, dimensions and other mechanical parameters. Students are asked to determine expressions and values to solve for unknown variables in static equilibrium scenarios. The last date to submit the assignment is August 18, 2016.
This document contains an assignment for an engineering mechanics course. It lists 8 problems related to mechanics, materials, and structures. The problems involve calculating angles, forces, moments, and pressures given information about physical configurations, masses, loads, dimensions and other mechanical parameters. Students are asked to determine expressions and values to solve for unknown variables in static equilibrium scenarios. The last date to submit the assignment is August 18, 2016.
lies in a vertical plane and is acted upon by a couple . The ends of the rod are connected to small rollers which rest against frictionless surface. (a) Express the angle corresponding to equilibrium in terms of , , g, and . (b) Determine the value of corresponding to equilibrium when = 2.7 Nm, = 2 , and = 0.8 m.
3. Calculate the magnitude of the force
supported by the pin at C under the action of the 900 N load applied to the bracket. Neglect friction in the slot.
4. A slender rod of mass m1 is welded to
the horizontal edge of a uniform semi cylindrical shell of mass m2. Determine an expression for the angle with the horizontal made by the diameter of the shell through m1. 2. A thin, uniform ring of mass and radius R is attached by a frictionless pin to a collar at A and rests against a small roller at B. The ring lies in a vertical plane, and the collar can move freely on a horizontal force P. (a) Express the angle corresponding to equilibrium in terms of , g, and P. (b) Determine the value of corresponding to equilibrium when = 700 g and P = 3 N.
5. A block placed under the head of the
claw hammer as shown greatly facilitates the extraction of the nail. If a 50-lb pull on the handle is required to pull the nail, calculate the tension T in the nail and the magnitude A of the force exerted by
the hammer head on the block. The
contacting surfaces at A are sufficiently rough to prevent slipping.
6. When setting the anchor so that it
will dig into the sandy bottom, the engine of the 80 KN cruiser with center of gravity at G run in reverse to produce a horizontal thrust of T of 500N. If the angle chain makes an angle of 60o with the horizontal, determine the forward shift of b of the center of buoyancy from its position when the boat is floating free. The center of buoyancy is the point through which the resultant of the buoyant forces passes.
Take dimensions are in meter
7. Determine the magnitudes of the
force R and couple M exerted by the nut and bolt on the loaded bracket at O to maintain equilibrium.
8. The small crane is mounted on one
side of the bed of a pickup truck. For the position =40o, determine the magnitude of the force supported by the pin at O and the oil pressure p against the 50 mm diameter piston of the hydraulic cylinder BC.
Watch and Clock Escapements
A Complete Study in Theory and Practice of the Lever, Cylinder and Chronometer Escapements, Together with a Brief Account of the Origin and Evolution of the Escapement in Horology