Gearbox
‘The manufacturer's manual for each gearbox is
supplied.
Maintenance and lubrication should be
according to the recommendations in the
‘manufacturer's manual.
! Caution !
‘Some Gearboxes may use a “permanent”
synthetic lubricant that is not compatible with
oil
‘Regular Maintenance
After one week of operation, check and tighten
all drive belts and set screws. Also all electrical
terminals!
Periodically check the moldblock
synchronization and adjust as necessary.
Lubrication
‘The apparatus includes a central automatic
lubricating pump. The manufacturer's
information is supplied.Page 61 shows a sketch of the distribution
piping. A warning light on the control panel
indicates a low lubricant level. The central oil
pump has a lubricant capacity of 7.5 liters. Use
Esso Febis K 220 or equivalent for this
application, See specification sheet.
The oil to use for the molding track has to be
for sliding machine ways. Don’t use any other
type of oil as it might not have the lubrication
properties, resulting in moldblock vibration,
also known as slip - stick effect.
After one month of operation, change the oil in
the gearbox for the lift motor drive. The
‘manufacturer's manual for the gearbox is
supplied. Service for the gearbox regularly
according manufacturer’s recommendations.
Service all grease nipples every 1500 hours
of operation, Take care not to over grease.
‘There is a grease nipple on the nut for the
travel spindle. It is essential to keep these
lubricated.Corma Inc. 3020/4020 Corrugator Page 61
10 MeClesry Cour, nical Manual
‘Concord, Ont..Canada LAK 223 Mechai
{etephone:208) 669-9997 Date: Sept. 1995
‘Telefax: (905) 738-4744
BOTTOM RUNAIN
TOP RIGHT
‘BRUSH
BOTTOM RIGHT
BRUSH
JOOOG)
A
Keo
&
LUBRICATION DISTRIBUTION
Top tert
BRUSH
mi
OO
‘Conditions: This manval is supplied on condition that it sal ot be reproduced o disclosed to oter parca, in whole rin pa, witout te pror|
consent of CORSA INC.
The equipment described inthis manual is the subject of patent protection in various countries. Additions patent applications maybe pending.
TOOL STEEL
RUNOUT
TOP RETURN
TOOL STEEL
RUNOUT
2
e
z
iS
iE
g